Page 146 of 241
![VOLVO XC70 2004 Owners Manual
2004 VOLVO XC70
Jack for AWD models
CAUTION:
l The car must not be driven with wheels of different dimensions or with a\
spare tire other than the one
that came with the car. The use of diff](/manual-img/45/58552/w960_58552-145.png "VOLVO XC70 2004 Owners Manual
2004 VOLVO XC70
Jack for AWD models
CAUTION:
l The car must not be driven with wheels of different dimensions or with a\
spare tire other than the one
that came with the car. The use of diff")
2004 VOLVO XC70
Jack for AWD models
CAUTION:
l The car must not be driven with wheels of different dimensions or with a\
spare tire other than the one
that came with the car. The use of different size wheels can seriously d\
amage your car's transmission.
l Correct tightening torque on wheel bolts must be observed. The wheel bol\
ts should never be greased
or lubricated. The extended, chromed wheel bolts must not be used with s\
teel rims, as they make it
impossible to fit the hub caps.
Correct tightening order for wheel bolts
Installing the wheel
l Clean the contact surfaces on the wheel and hub.
l Lift the wheel and place it on the hub. Make sure that you align the whe\
el with the guide stud on the
wheel hub prior to installation.
l Install the wheel bolts and tighten hand-tight. Using the lug wrench, ti\
ghten crosswise (see illustration
above) until all bolts are snug.
l Lower the vehicle to the ground and alternately tighten the bolts crossw\
ise to 100 ft. lbs. (136 Nm).
l Install the wheel cap (where applicable).
file:///K|/ownersdocs/2004/2004_XC70/04xc70_07.htm (10 of 11)12/30/200\
6 4:33:03 PM
Page 194 of 241
2004 VOLVO XC70
The engine is equipped with a multiport fuel injection system.
Distributor ignition system
Firing order: 1-2-4-5-3
Electronic ignition setting: Not adjustable
Spark plugs: Champion RC8PYP 8 (or equivalent)
Spark plug gap: 0.028-0.032" (0.7-0.8 mm)
Tightening torque: 18.4 ft. lbs. (25 Nm) WARNING!
The ignition system operates at very high voltages. Special safety preca\
utions must be followed to
prevent injury. Always turn the ignition off when:
l Replacing ignition components e.g. plugs, coil, etc.
l Do not touch any part of the ignition system while the engine is running\
. This may result in a shock
and bodily injury.
Front suspension
Spring strut suspension with integrated shock absorbers and control arms\
linked to the support frame.
Power-assisted rack and pinion steering. Safety type steering column. Th\
e alignment specifications
apply to an unladen car but include fuel, coolant and spare wheel.
Rear suspension
Individual rear wheel suspension with longitudinal support arms, double \
link arms and track rods.
All specifications are subject to change without prior notice.
pg. 150 Electrical system
Electrical system
12 Volt, negative ground.
Voltage-controlled generator. Single-wire system with chassis and engine\
used as conductors. Grounded
on chassis.
file:///K|/ownersdocs/2004/2004_XC70/04xc70_09.htm (9 of 12)12/30/2006\
4:33:07 PM
Page 235 of 241
2004 VOLVO XC70
Securing cargo 68
Servicing
135
Shiftlock
87, 90, 92
Side direction indicator - replacing
125
Side impact airbag system (SIPS)
8
Sideview mirrors
41
Sideview mirrors - heated
38
Sideview mirrors - memory function
41
Snow chains
111
Snow tires
111
Spare tire
72, 112
Spark plugs
134, 149
Specifications
147
Speed-sensitive power steering
96
Sport mode (automatic transmission)
93
SRS
6
SRS diagnostic system
28
Stability Traction Control (STC)
19, 31
Stain removal
130
Start inhibitor (immobilizer)
76, 87
Starting the engine
87, 88
Steel grid
69
Steering wheel adjustment
35
Steering wheel lock
35
Stop and Store bag
64
Storage compartments
59
Storage in the glove compartment
60
Studded tires
111
Subwoofer
72, 168
Supplemental Restraint System
4, 28
Suspension
149
Switches in center console
31
file:///K|/ownersdocs/2004/2004_XC70/04xc70_12.htm (10 of 12)12/30/200\
6 4:33:10 PM
