2004 VOLVO S60 tow

Cleaning floor mats
The floor mats should be vacuumed or brushed clean regularly, especially during winter when they should be taken out
for drying. Spots on textile mats can be removed with a mild detergent.
Bear in mind
Take extra care when removing stains such as ink or lipstick since the coloring can spread.
Use solvents sparingly. Too much solvent can damage the seat padding.
Start from the outside of the stain and work toward the center.
pg. 118 Car care
Paint touch up
Paint damage requires immediate attention to avoid rusting. Make it a habit to check the finish regularly - when
washing the car for instance. Touch-up if necessary.
Paint repairs require special equipment and skill. Contact your Volvo retailer for any extensive damage.
Minor scratches can be repaired by using Volvo touch-up paint.
NOTE: When ordering touch-up paint from your Volvo retailer, use the paint code indicated on the model plate. The
plate is located in the engine compartment.
Color code
Make sure you have the right color. The color code number is on the data plate in the engine compartment.
Minor stone chips and scratches
Material:
Primer - can
Paint - touch-up pen
Brush
Masking tape
If the stone chip has not gone down to the bare metal and an undamaged color coat remains, you can add paint
immediately after removing dirt.
NOTE: When touching up the car, it should be clean and dry. The surface temperature should be above 60° F (15° C).
Minor scratches on the surface
If the stone chip has not penetrated down to the metal and an undamaged layer of paint remains, the touch-up paint can
be applied as soon as the spot has been cleaned.
Deep scratches
1. Place a strip of masking tape over the damaged surface. Pull the tape off so that any loose flakes of paint adhere to
it.
2. Thoroughly mix the primer and apply it with a small brush.
ProCarManuals.com

Oils and fluids
Oil quality
Engine oil must meet the minimum ILSAC specification GF-2, including ACEA A1, API SJ, SJ/CF and SJ/ Energy
Conserving.
Your Volvo has been certified to standards using ILSAC oil specification GF-2 5W -30. Volvo recommends use of oil
with a quality rating equal to or higher than ILSAC GF-2. Equivalent and better oils include ACEA A1, API SJ,
SJ/CF, and SJ/Energy conserving. Lower quality oils may not offer the same fuel economy, engine performance, or
engine protection.
Volvo Cars recommends Castrol.
Depending on your driving habits, premium or synthetic oils may provide superior fuel economy and engine
protection. Consult your Volvo retailer for recommendations on premium or synthetic oils.
Oil additives must not be used.
NOTE: Synthetic oil is not used when the oil is changed at normal maintenance services. This oil is only used at
customer request, at additional charge. Please consult your Volvo retailer.
Operation in hot climates
When temperatures exceed 86° F (30° C) in your area, Volvo recommends, for the protection of your engine, that you
use a heavier weight oil, such as SAE 10W/30. See the viscosity chart below.
Oil viscosity (stable ambient temperatures)
Operation in temperate climates
Incorrect viscosity oil can shorten engine life. Under normal use when temperatures do not exceed 86° F (30° C), SAE
5W/30 will provide good fuel economy and engine protection. See the viscosity chart above.
Extreme engine operation
Synthetic oils meeting SAE 10W/30 and complying with oil quality requirements are recommended for driving in
areas of sustained temperature extremes (hot or cold), when towing a trailer over long distances, and for prolonged
driving in mountainous areas.
Changing oil and oil filter
Oil and oil filter changes should be made at 7,500 mile (12,000 km) intervals.
Volvo does not recommend the use of oil additives.
Synthetic oil is not used when the oil is changed at the normal maintenance service intervals.
ProCarManuals.com

the instrument panel will come on and a warning will be displayed in the text window.
If the yellow warning light in the instrument panel comes on and the text OIL LEVEL LOW/ FILL OIL is displayed,
stop safely as soon as possible and add 1 qt (1 liter) of oil. Check the oil level with the dipstick before restarting the
engine.
If the red warning light in the instrument panel comes on and the text OIL LEVEL LOW/STOP SAFELY-->STOP
ENGINE-->SEE MANUAL is displayed, stop safely as soon as possible and add oil (not more than 1.6 qts (1.5 liters).
Check the oil level with the dipstick before restarting the engine. If no oil level is visible on the dipstick, do not start
the engine. Have the car towed to an authorized Volvo workshop.
pg. 127 Maintenance and service
Washer fluid reservoir
Washer fluid reservoir
The washer fluid reservoir is located in the engine compartment and holds approx. 4.7 US qts. (4.5 liters).
During cold weather, the reservoir should be filled with windshield washer solvent containing antifreeze.
Coolant reservoir
Changing coolant
Normally, the coolant does not need to be changed. If the system must be drained, consult your Volvo retailer.
NOTE: Do not top off with water only. This reduces the rust-protective and antifreeze qualities of the coolant and has
a lower boiling point. It can also cause damage to the cooling system if it should freeze. Top off with Volvo Genuine
Coolant/Antifreeze only (a 50/50 mix of water and antifreeze).
CAUTION:
ProCarManuals.com

Fluid type: ATF
Replace: No fluid change required
NOTE: If a problem should occur in the power steering system or if the car has no electrical current and must be
towed, it is still possible to steer the car. However, keep in mind that greater effort will be required to turn the steering
wheel.
Contents | Top of Page
ProCarManuals.com

7 Child safety latch label
*The Vehicle Identification Number (VIN) should always be quoted in all correspondence concerning your vehicle
with the retailer and when ordering parts.
pg. 147 Specifications
Dimensions and weights
Dimensions
Length 180 in. (458 cm)
Width 71 in. (180 cm)
Height 56.2 in. (143 cm)
Wheelbase 107 in. (272 cm)
Front track 61.5 in. (156 cm)
Rear track 61.4 (156 cm)
Turning circle, between curbs 35.4- 38.7 ft. (10.8- 11.8 m)
Cargo capacity, trunk SAE V1 - 13.9 (394)
Max. loads:
Max. roof load 220 lbs 100 kg
Max. trailer weight
without brakes 1100 lbs (500 kg)
with brakes 2" ball 3300 lbs (1500 kg)
1 7/ 8" ball 3300 lbs (1500 kg)
Max. tongue weight ** 165 lbs (75 kg)
** See also section "Trailer towing"
ProCarManuals.com

2 0 0 4
VOLVO S60
Index
pg. 207 Index
A
A/C (air conditioning) 48
, 51
ABSii , 23 , 92
Accessory bracket62
Adjustable steering wheel29
Advanced User Mode (AUM) - radio166
Air bags - dual threshold/stage5
Air distribution45 , 48 , 52
Air quality sensor49
Air vents45
Airbag - Side Impact (SIPS)10
Airbags4
Airbags (front)4
Alarm67 , 74
All Wheel Drive90
All Wheel Drive - snow chains109
All Wheel Drive - towing97
Anti-lock Brake System (ABS)ii , 23
Approach lighting32
Ashtray37 , 61
Audio157
Audio systems - general information175
Audio systems - specifications174
AUM166
AUTO47
AUTO (climate control)47
Automatic Climate Control, ECC46
Automatic gearbox83
Automatic transmission86
Automatic transmission - adaptive system87
Automatic transmission - kickdown87
Automatic transmission - Sport mode89
Auxiliary lamps27
Average speed35
ProCarManuals.com

Side marker lamp137
SIPS airbags10
Ski hatch64
Snow chains109
Snow tires109
Spare tires110
Spare wheel64
Spark plugs154
Specifications145
Speedometer22
Spoiler lamps30
Sport mode89
SRS4
Stability system94
Stability systems94
Stability Traction Control (STC)94
Start inhibitor (immobilizer)68
Starting the car81
STC27
Steering82
Steering wheel adjustment29
Steering wheel lock82
Stone chips118
STOP ENGINE26
Storage compartments61
Studded tires109
Sun visor41
Supplemental Restraint System (SRS)4
Supplemental Restraint System (SRS) - warning light25
Suspension152
Switches in the center console27
T
Tachometer22
Temperature47
Temperature gauge22
Temporary spare tire110
Text window - messages26
TIME FOR REGULAR SERVICE26
Tires economy108
Tires economy - improving108
Tires108
Tires - tread wear indicators111
Towing96
Towing - cars with All Wheel Drive97
ProCarManuals.com

Towing a trailer99
Trailer indicator lamp25
Trailer towing99
Transmission - automatic86
Transmission - Geartronic88
Transmission - manual85
Trip computer35
Trip odometer22
Trunk - opening from the inside72
Trunk - unlocking71
Turn signals - normal turns32
Turn signals - lane change position32
Type designations146
U
Uniform Tire Quality Grading113
, 114
Unlocking71
Unlocking the trunk71
Use of Additives79
V
Valet key68
Vanity mirror59
Vehicle Identification Number (VIN)146
Vehicle loading110
Vehicle weights148
VIN (Vehicle Identification Number)146
Volvo and the environmentiii
W
W - Winter87
, 89
Warning23
Warning symbol in center of dashboard23
Warranties120
Washer fluid reservoir124 , 127
Washing the car116
Waxing117
Weight distribution84
Weights148
Wheels108
WHIPS14
Windshield washer33
Windshield washer fluid reservoir127
Windshield wipers33
Winter tires108
Winter/Wet driving mode104
Wiper blades129
ProCarManuals.com