2004 TOYOTA xB air filter

Driving on Rough, Muddy or Snow-Melted Roads
›Inspect ball joints and dust cover
›Inspect brake linings/drums and brake pads/discs
›Inspect drive shaft boots
›Inspect nuts and bolts on chassis and body
›Inspect steering linkage and boots
›Rotate tires
Driving on Unpaved or Dusty Roads
›Inspect brake linings/drums and brake pads/discs
›Inspect or change engine air filter
Extensive Idling or Low-Speed Driving for Long Distances
›Inspect brake linings/drums and brake pads/discs
Using a Car-Top Carrier
›Inspect brake linings/drums and brake pads/discs
›Inspect nuts and bolts on chassis and body
›Replace automatic transmission fluid
›Replace differential oil
General Maintenance Information11
Determining Your Scion’s Maintenance Needs ‹‹

Drive Belts
Inspect for cracks, excessive wear and oiliness. Check the belt tension
and adjust if necessary. Replace the belts if they are damaged.
Drive Shaft Boots
Check the drive shaft boots and clamps for cracks, deterioration
and damage. Replace any deteriorated or damaged parts and, if
necessary, repack the grease. A qualified technician should perform
these operations.
Engine Air Filter
Replace at specified intervals. When performing inspections, check
for damage, excessive wear and oiliness, and replace if necessary.
Engine Coolant
Drain and flush the cooling system and refill with an ethylene-glycol
type coolant. Inspect the radiator, condenser and/or intercooler for
leaves, dirt and insects and clean if necessary. Inspect hoses and con-
nections for corrosion and leaks. Tighten connections and replace parts
as necessary. A qualified technician should perform these operations.
Note:Your Scion is equipped with Genuine Toyota Super Long-Life
Coolant. The replacement intervals for engine coolant recommended
in this booklet are based on replacement with Genuine Toyota Super
Long-Life Coolant or similar high-quality non-silicate, non-amine,
non-borate ethylene-glycol coolant with long-life hybrid organic acid
technology (i.e., a combination of low phosphates and organic acids). If
another type of ethylene-glycol coolant is used, replacement intervals
may be different.
Engine Oil and Oil Filter
Replace the oil filter and drain and refill the engine oil at specified
intervals. For recommended oil grade and viscosity, refer to the
Owner’s Manual.
Engine Valve Clearance
Inspect for excessive lifter noise and engine vibration and adjust if
necessary. A qualified technician should perform this operation.
General Maintenance Information13
Explanation of Maintenance Items ‹‹

Scheduled Maintenance Log 18
›› Maintenance Log
5,000-Mile Maintenance Intervals
7,500-Mile Maintenance IntervalsTo determine the appropriate maintenance
interval for your vehicle, see page 10.
7,500 Miles or 6 Months
❑Replace engine oil and oil filter1
❑Rotate tires
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
5,000 Miles or 4 Months
❑Replace engine oil and oil filter1
Additional Maintenance Items for
Special Operating Conditions:2
❑Inspect the following:__ Ball joints and dust covers
__ Brake linings/drums and brake pads/discs
__ Drive shaft boots
__ Engine air filter
__ Nuts and bolts on chassis and body
__ Steering linkage and boots
❑Rotate tires
10,000 Miles or 8 Months
❑Replace engine oil and oil filter1
Additional Maintenance Items for
Special Operating Conditions:2
❑Inspect the following:__ Ball joints and dust covers
__ Brake linings/drums and brake pads/discs
__ Drive shaft boots
__ Engine air filter
__ Nuts and bolts on chassis and body
__ Steering linkage and boots
❑Rotate tires
DEALERSERVICEVERIFICATION:
D
AT E:MILEAGE: D
EALERSERVICEVERIFICATION:
D
AT E:MILEAGE:
Note: If you drive your vehicle under any of
the special operating conditions noted on
pages 10–11, you may need to perform spe-
cific services at 5,000-mile intervals. See the
5,000-mile maintenance charts for details.

Scheduled Maintenance Log19
Maintenance Log ‹‹
1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.2Specific services apply to specific operating conditions. See pages 10–11 for details.
15,000 Miles or 12 Months
15,000 Miles or 12 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Inspect the following:__ Ball joints and dust covers
__ Brake lines and hoses
__ Brake linings/drums and
brake pads/discs
__ Drive shaft boots
Additional Maintenance Items for Special Operating Conditions:2
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
__ Engine coolant level
__ Exhaust pipes and mountings
__ Steering gear box
__ Steering linkage and boots

Scheduled Maintenance Log 20
›› Maintenance Log
5,000-Mile Maintenance Intervals
7,500-Mile Maintenance IntervalsTo determine the appropriate maintenance
interval for your vehicle, see page 10.
22,500 Miles or 18 Months
❑Replace engine oil and oil filter1
❑Rotate tires
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
20,000 Miles or 16 Months
❑Replace engine oil and oil filter1
Additional Maintenance Items for
Special Operating Conditions:2
❑Inspect the following:__ Ball joints and dust covers
__ Brake linings/drums and brake pads/discs
__ Drive shaft boots
__ Engine air filter
__ Nuts and bolts on chassis and body
__ Steering linkage and boots
❑Rotate tires
25,000 Miles or 20 Months
❑Replace engine oil and oil filter1
Additional Maintenance Items for
Special Operating Conditions:2
❑Inspect the following:__ Ball joints and dust covers
__ Brake linings/drums and brake pads/discs
__ Drive shaft boots
__ Engine air filter
__ Nuts and bolts on chassis and body
__ Steering linkage and boots
❑Rotate tires
DEALERSERVICEVERIFICATION:
D
AT E:MILEAGE: D
EALERSERVICEVERIFICATION:
D
AT E:MILEAGE:
Note: If you drive your vehicle under any of
the special operating conditions noted on
pages 10–11, you may need to perform spe-
cific services at 5,000-mile intervals. See the
5,000-mile maintenance charts for details.

Scheduled Maintenance Log21
Maintenance Log ‹‹
1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.2Specific services apply to specific operating conditions. See pages 10–11 for details.3Required under the terms of the Emission Control Warranty.4Applies to manual transmission models only.
30,000 Miles or 24 Months
30,000 Miles or 24 Months
❑Replace engine air filter
❑Replace engine oil and oil filter1
❑Replace spark plugs3
❑Rotate tires
❑Inspect the following:__ Ball joints and dust covers
__ Brake lines and hoses
__ Brake linings/drums and
brake pads/discs
__ Differential oil
__ Drive shaft boots
__ Engine coolant level
__ Exhaust pipes and mountings
Additional Maintenance Items for Special Operating Conditions:2
❑Inspect nuts and bolts on chassis and body
❑Replace differential oil4
❑Replace manual transmission oil
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
__ Fuel lines and connections, fuel
tank band and fuel tank vapor
vent system hoses
__ Fuel tank cap gasket
__ Radiator core and condenser
__ Steering gear box
__ Steering linkage and boots
__ Transmission fluid or oil

Scheduled Maintenance Log 22
›› Maintenance Log
5,000-Mile Maintenance Intervals
7,500-Mile Maintenance IntervalsTo determine the appropriate maintenance
interval for your vehicle, see page 10.
37,500 Miles or 30 Months
❑Replace engine oil and oil filter1
❑Rotate tires
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
35,000 Miles or 28 Months
❑Replace engine oil and oil filter1
Additional Maintenance Items for
Special Operating Conditions:2
❑Inspect the following:__ Ball joints and dust covers
__ Brake linings/drums and brake pads/discs
__ Drive shaft boots
__ Engine air filter
__ Nuts and bolts on chassis and body
__ Steering linkage and boots
❑Rotate tires
40,000 Miles or 32 Months
❑Replace engine oil and oil filter1
Additional Maintenance Items for
Special Operating Conditions:2
❑Inspect the following:__ Ball joints and dust covers
__ Brake linings/drums and brake pads/discs
__ Drive shaft boots
__ Engine air filter
__ Nuts and bolts on chassis and body
__ Steering linkage and boots
❑Rotate tires
DEALERSERVICEVERIFICATION:
D
AT E:MILEAGE: D
EALERSERVICEVERIFICATION:
D
AT E:MILEAGE:
Note: If you drive your vehicle under any of
the special operating conditions noted on
pages 10–11, you may need to perform spe-
cific services at 5,000-mile intervals. See the
5,000-mile maintenance charts for details.

Scheduled Maintenance Log23
Maintenance Log ‹‹
1Reset the oil replacement reminder (“MAINT REQD”) light after replacing engine oil.2Specific services apply to specific operating conditions. See pages 10–11 for details.
45,000 Miles or 36 Months
45,000 Miles or 36 Months
❑Replace engine oil and oil filter1
❑Rotate tires
❑Inspect the following:__ Ball joints and dust covers
__ Brake lines and hoses
__ Brake linings/drums and
brake pads/discs
__ Drive shaft boots
Additional Maintenance Items for Special Operating Conditions:2
❑Inspect engine air filter
❑Inspect nuts and bolts on chassis and body
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
__ Engine coolant level
__ Exhaust pipes and mountings
__ Steering gear box
__ Steering linkage and boots