2004 TOYOTA SOLARA transmission

’04 Solara_U (L/O 0402)
296
2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
Do not reuse iridiumtipped spark
plugs by cleaning or regapping.
Do not overfill automatic transmis-
sion fluid, or the transmission
could be damaged.
Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
Be careful not to scratch the glass
surface with the wiper frame.
When closing the engine hood,
check to see that you have not for-
gotten any tools, rags, etc.
Front
Rear
When jacking up your vehicle with the
jack, position the jack correctly as
shown in the illustrations.
CAUTION
When jacking, be sure to observe the
following to reduce the possibility of
personal injury:
Follow jacking instructions.
Do not put any part of your body
under the vehicle supported by the
jack. Personal injury may occur.
Do not start or run the engine while
your vehicle is supported by the
jack.
Stop the vehicle on a level firm
ground, firmly set the parking brake
and put the transmission in “P”
(automatic) or reverse (manual).
Block the wheels on the opposite
side of the jack up point if neces-
sary.
Make sure to set the jack properly
in the jack point. Raising the ve-
hicle with jack improperly posi-
tioned will damage the vehicle or
may allow the vehicle to fall off the
jack and cause personal injury.
Positioning the jack

’04 Solara_U (L/O 0402)
297
2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Never get under the vehicle when
the vehicle is supported by the jack
alone; use vehicle support stands.
Do not raise the vehicle with some-
one in the vehicle.
When raising the vehicle, do not
place any objects on top of or un-
derneath the jack.
NOTICE
Make sure to place the jack correctly,
or your vehicle may be damaged.
Here is a list of parts and tools you will
need to perform do−it−yourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Toyota Genuine Motor Oil” or equiva-
lent
See page 300 in Section 7−2 for de-
tails about engine oil selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based non−silicate, non−amine, non−ni-
trite, and non−borate coolant with long−
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a
mixture of 50% coolant and 50% deion-
ized water.
Tools:
Funnel (only for adding coolant)CHECKING BRAKE FLUID
Parts (if level is low):
SAE J1703 or FMVSS No.116 DOT 3
brake fluid
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Automatic transmission fluid
DEXRONII or III
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts)
Parts and tools

’04 Solara_U (L/O 0402)
305
2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Clean all dirt from the outside of the res-
ervoir tank and look at the fluid level. If
the fluid is cold, the level should be in the
“COLD” range. Similarly, if it is hot, the
fluid level should be in the “HOT” range.
If the level is at the low side of either
range, add automatic transmission fluid
DEXRONII or III to bring the level within
the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the reser-
voir cap, visually check the steering box
case, vane pump and hose connections
for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
Keep your tire inflation pressures
at the proper level.
The recommended cold tire inflation
pressures, tire sizes and the com-
bined weight of occupants and cargo
(vehicle capacity weight) are de-
scribed on pages 326 and 330. They
are also on the tire and loading infor-
mation label.
You should check the tire inflation
pressure every two weeks, or at least
once a month. And do not forget the
spare!
Checking tire inflation
pressure

’04 Solara_U (L/O 0402)
329
2004 SOLARA from Feb. ’04 Prod. (OM33640U)
AUTOMATIC TRANSAXLE
Fluid capacity (drain and refill), L (qt.,
Imp. qt.):
3.5 (3.7, 3.1)
Fluid type:
Toyota Genuine ATF Type T−IV
Change automatic transmission fluid only
as necessary.
Generally, it is necessary to change
automatic transmission fluid only if your
vehicle is driven under one of the Special
Operating Conditions listed in your
“Scheduled Maintenance Guide” or
“Owner ’s Manual Supplement”. When
changing the automatic transmission fluid,
use only “Toyota Genuine ATF Type T−IV”
(ATF JWS3309 or NWS6500) to aid in
assuring optimum transaxle performance.
Notice: Using automatic transmission
fluid other than “Toyota Genuine ATF
Type TIV” may cause deterioration in
shift quality, locking up of your trans-
mission accompanied by vibration, and
ultimately damage the automatic trans-
mission of your vehicle.
Please contact your Toyota dealer for fur-
ther details.BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):
With vehicle stability control system
78 (3.1)
Without vehicle stability control system
68.5 (2.7)
Pedal free play, mm (in.):
1—6 (0.04—0.24)
Pad wear limit, mm (in.):
1.0 (0.04)
Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf):
6—9 clicks
Fluid type:
SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type:
Automatic transmission fluid DEXRONII
or III

’04 Solara_U (L/O 0402)
332
2004 SOLARA from Feb. ’04 Prod. (OM33640U)
31. PANEL 10 A: Glove box light, multi−in-
formation display, instrument cluster
lights, instrument panel lights
32. ECUIG 10 A: SRS airbag system,
anti−lock brake system, vehicle stability
control system, traction control system,
brake assist system, compass, anti−
glare inside rear view mirror, electric
moon roof, power windows, multiplex
communication system
33. HTR 10 A: Air conditioning system,
rear window defogger, outside rear
view mirror defoggers
34. WASH 15 A: Windshield washer
35. S/HTR 20 A: Seat heaters
36. GAUGE1 10 A: Gauges and meters,
multi−information display, shift lock con-
trol system, turn signal lights, back−up
lights, cruise control system, charging
system, theft deterrent system, auto-
matic transmission
37. WIP 25 A: Windshield wipers
38. RAD1 20 A: Car audio system39. ECUB 10 A: Multiplex communication
system (power door lock system, secu-
rity system, auto−door locking system,
automatic light control system, head-
light delay off system, tail light auto
cut system, illuminated entry system,
daytime running light system, wireless
remote control system), air conditioning
system, front passenger occupant clas-
sification system, gauges and meters,
vehicle stability control system
40. DOME 7.5 A: Ignition switch light, inte-
rior light, personal lights, trunk light,
vanity lights, wireless remote control
system, multi−information display
41. ECU ACC 7.5 A: Power rear view mir-
rors, multi−information display, gauges
and meters, automatic transmission,
multiplex communication system
42. CIG 15 A: Power outlet
43. P/POINT 15 A: Power outlet
44. RAD2 10 A: Car audio system
45. MIR HTR 10 A: Outside rear view mir-
ror defoggers, multiport fuel injection
system/sequential multiport fuel injec-
tion systemFuses (type C)
46. DEF 40 A: Rear window defogger, out-
side rear view mirror defoggers
47. MAIN 40 A: Headlights, daytime run-
ning light system, multiport fuel injec-
tion system/sequential multiport fuel in-
jection system, “HEAD LH LWR”,
“HEAD RH LWR”, “HEAD LH UPR”,
“HEAD LH UPR” and “DRL” fuses
48. ABS No.1 50 A: Anti−lock brake sys-
tem, vehicle stability control system,
traction control system, brake assist
system
49. CDS 30 A: Electric cooling fan
50. RDI 30 A: Electric cooling fan
51. HTR 50 A: Air conditioning system
52. TSK 30 A (convertible): Convertible
top control system, quarter windows
53. PWR 30 A:
Side power windows
54. P/SEAT 30 A: Power seats
Fuses (type D)
55. ALT 120 A: “HEAD LH LWR”, “HEAD
RH LWR”, “DRL”, “A/C”, “AM2”, “HEAD
LH UPR”, “HEAD RH UPR”, “ALT−S”,
“IGN”, “IG2”, “DOOR1”, “EFI”, “HORN”,
“D.C.C”, “A/F”, “ABS No.2”, “ETCS”,
“HAZ”, “DEF”, “MAIN”, “ABS No.1”,
“CDS”, “RDI” and “HTR (50 A)” fuses

’04 Solara_U (L/O 0402)
2004 SOLARA from Feb. ’04 Prod. (OM33640U)
Publication No. OM33640U
Part No. 01999-33640
Printed in Japan 01−0402−00
Quick index
If a service reminder indicator or warning buzzer comes on 129. . . . . . . .
If your vehicle will not start 256. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
If your engine stalls while driving 259. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
If your vehicle overheats 260. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
If you have a flat tire 261. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
If your vehicle needs to be towed 271. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tips for driving during break−in period 222. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
How to start the engine 248. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General maintenance 287. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gas station information
Fuel type:
2AZ−FE engine: UNLEADED gasoline, Octane Rating 87
(Research Octane Number 91) or higher
3MZ−FE engine: UNLEADED gasoline, Octane Rating 87
(Research Octane Number 91) or higher.
For improved vehicle performance, the use of premium unleaded
gasoline with an Octane Rating of 91 (Research Octane Number 96)
or higher is recommended.
See page 222 for detailed information.
Fuel tank capacity:
70 L (18.5 gal., 15.4 lmp. gal.)
Engine oil:
API grade SL “Energy−Conserving” or ILSAC multigrade engine oil is
recommended.
See page 301 for detailed information.
Automatic transmission fluid:
Toyota Genuine ATF Type T−IV
Tire information: See pages 305 through 313.
Tire inflation pressure: See page 330.
hU1
C