2004 SUBARU LEGACY brake fluid

11 - 2 8
2Maintenance and service
SAE viscosity No. and Applicable Temperature
Automatic transmission fluid „
Checking the fluid level
The automatic transmission fluid expands largely as
its temperature rises; the fluid level differs according to
fluid temperature. Therefore, there are two different
scales for checking the level of hot fluid and cold fluid
on the dipstick.
Though the fluid level can be checked without warm-
ing up the fluid on the “COLD” range, we recommend
checking the fluid level when the fluid is at operating
temperature. T Checking the fluid level when the fluid is hot
Check the fluid level monthly.
1. Drive the vehicle several miles to raise the temper-
ature of the transmission fluid up to normal operating
temperature; 158 to 176 °F (70 to 80 °C) is normal.
2. Park the vehicle on a level surface and set the park-
ing brake.
3. First shift the selector lever in each position. Then
shift it in the “P” position, and run the engine at idling
speed.-30 -20 -10 0 10 20 30 40
-20 0 60 20
80W
75W/90 80 100
40
85W 90
HSB036BA

11 - 3 6
2Maintenance and service
2. Check the fluid level of the reservoir tank.
When the fluid is hot after the vehicle has been run:
Check that the oil level is between “HOT MIN” and
“HOT MAX” on the surface of the reservoir tank.
When the fluid is cool before the vehicle is run: Check
that the oil level is between “COLD MIN” and “COLD
MAX” on the surface of the reservoir tank.
3. If the fluid level is lower than the applicable “MIN”
line, add the recommended fluid as necessary to bring
the level between the “MIN” and “MAX” line.
If the fluid level is extreme low, it may indicate possible
leakage. Consult your SUBARU dealer for inspection. „
Recommended fluid
“Dexron III” Type Automatic Transmission Fluid
Brake fluid „Checking the fluid level
yNever let brake fluid contact your eyes be-
cause brake fluid can be harmful to your eyes.
If brake fluid gets in your eyes, immediately
flush them thoroughly with clean water. For
safety, when performing this work, wearing eye
protection is advisable. y Brake fluid absorbs moisture from the air.
Any absorbed moisture can cause a dangerous
loss of braking performance. y If the vehicle requires frequent refilling, there
may be a leak. If you suspect a problem, have
the vehicle checked at your SUBARU dealer.
y Never use different brands of brake fluid to-
gether. y When adding brake fluid, be careful not to al-
low any dirt into the reservoir.y Never splash the brake fluid over painted sur-

11 -3 7
2Maintenance and service
– CONTINUED –
faces or rubber parts. Alcohol contained in the
brake fluid may damage them.
Check the fluid level monthly.
1) “MAX” level mark
2) “MIN” level mark
Check the fluid level on the outside of the reservoir. If
the level is below “MIN”, add the recommended brake
fluid to “MAX”.
Use only brake fluid from a sealed container. „
Recommended brake fluid
FMVSS No. 116, fresh DOT 3 or 4 brake fluid
UBB004GB
1
2

11 - 3 8
2Maintenance and service
Clutch fluid (MT vehicles) „
Checking the fluid level
Never let clutch fluid contact your eyes be-
cause clutch fluid can be harmful to your eyes.
If clutch fluid gets in your eyes, immediately
flush them thoroughly with clean water. For
safety, when performing this work, wearing eye
protection is advisable.
yClutch fluid absorbs moisture from the air.
Any absorbed moisture can cause improper
clutch operation.y If the vehicle requires frequent refilling, there
may be a leak. If you suspect a problem, have
the vehicle checked at your SUBARU dealer.y Never use different brands of clutch fluid to-
gether. y When clutch fluid is added, be careful not to
allow any dirt into the tank. 1) “MAX” level mark
2) “MIN” level mark
Check the fluid level on the outside of the reservoir. If
the level is below “MIN” level mark, add the recom-
mended clutch fluid to “MAX” level mark.
Use only clutch fluid from a sealed container. „ Recommended clutch fluid
FMVSS No. 116, fresh DOT 3 or 4 brake fluid
1
2
UBB004HB

14-2
Index
A
ABS (Anti-lock Brake System)
...............................7-32
Warning light ................................................. 3-13, 7-33
Accessories ......................................................... 5-3, 11-62
Accessory power outlet ............................................. 6-11
Air cleaner element ..................................................... 11-22
Air conditioner operation ..........................................4-10
Air filtration system ..................................................... 4-21
Air flow selection .......................................................... 4-4
Aluminum wheels ........................................................ 11-51
Antenna system ........................................................... 5-2
Anti-lock Brake System (ABS) ...............................7-32
Arming the system ...................................................... 2-15
Armrest ............................................................................ 1-11
Ashtray ............................................................................. 6-12
AT OIL TEMPerature warning light ......................3-12
Audio set ......................................................................... 5-4
Auto-dimming mirror/compass ...............................3-31
Automatic/Emergency Locking Retractor (A/ELR) ....................................................................... 1-20
Automatic transmission ...................................7-15, 7-21
Capacities ................................................................. 12-4
Fluid ............................................................................ 11-28
Selector lever ................................................ 7-16, 7-22
Shift lock release ......................................... 7-20, 7-28
Temperature warning light ................................3-12BBattery
............................................................................... 11-58
Jump starting ........................................................... 9-15
Replacement (Remote keyless entry system) .................................................................... 2-10
Brake Booster ....................................................................... 11-39
Fluid ............................................................................. 11-36
Pad and lining .......................................................... 11-41
Pedal ........................................................................... 11-39
Brake system ................................................................. 7-31
Warning light ............................................................ 3-14
Braking .............................................................................. 7-30
Breaking-in of new brake pads and
linings ....................................................................... 11-42
Tips .............................................................................. 7-30
Brake pedal
Free play .................................................................... 11-39
Reserve distance ................................................... 11-40
Bulb
Chart ............................................................................ 12-12
Replacing ................................................................... 11-63
C
Capacities ........................................................................ 12-4
Cargo area light ............................................................ 6-2
Catalytic converter ....................................................... 8-4

14-3
Index
Center
Console ..................................................................... 6-6
Ventilators ................................................................. 4-2
Changing
Flat tire ....................................................................... 9-5
Oil and oil filter ........................................................ 11-12
Charge warning light .................................................. 3-12
CHECK ENGINE warning light/ Malfunction indicator lamp ..................................3-11
Checking
Brake pedal free play ........................................... 11-39
Brake pedal reserve distance ...........................11-40
Clutch function ........................................................ 11-40
Clutch pedal free play .......................................... 11-41
Engine oil level ....................................................... 11-11
Fluid level ....................... 11-28, 11-35, 11-36, 11-38
Gear oil level ................................ 11-27, 11-30, 11-32
Child restraint systems ............................................... 1-37
Installation with seatbelt .....................................1-41
Lower and tether anchorages ..........................1-48
Child safety .................................................................... 5
Locks .......................................................................... 2-22
Chime
Key .............................................................................. 3-5
Seatbelt ........................................................... 1-20, 3-10
Cigarette lighter socket ............................................. 6-10Cleaning
Aluminum wheels .................................................. 10-4
I n te rior .. ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. .. 10 -7
Ventilator grille ........................................................ 4-19
Climate control system Manual ....................................................................... 4-5
Automatic ................................................................. 4-11
Clock ................................................................................. 3-18
Clutch fluid ...................................................................... 11-38
Clutch pedal ................................................................... 11-40
Coat hook ....................................................................... 6-20
Coin compartment ....................................................... 6-7
Convenience hook ...................................................... 6-20
Convenient tie-down hooks .....................................6-24
Cooling system ............................................................. 11-17
Corrosion protection ......................................... 8-13, 10-5
Cruise control ................................................................ 7-42
Set indicator light ................................................... 3-18
Cup holder ...................................................................... 6-8
D
Daytime running light system .................................3-21
Differential gear oil Front ............................................................................ 11-30
Rear ............................................................................ 11-32
Dimensions .................................................................... 12-2
Disarming the system ................................................ 2-17

14-4
Index
Disc brake pad wear warning indicators
............7-31
Dome light ............................................................ 6-2, 11-76
Door locks ....................................................................... 2-3
Door open warning lights .........................................3-15
Drive belts ....................................................................... 11-26
Driving Drinking ..................................................................... 7
Drugs .......................................................................... 7
Foreign countries .................................................. 8-6
Car/Mobile phone .................................................. 8
Pets ............................................................................. 9
Tips ............................................. 7-14, 7-19, 7-28, 8-6
Tired or sleepy ........................................................ 8
Snowy and icy roads ............................................ 8-12
E
Electrical system .......................................................... 12-3
Emergency Locking Retractor (ELR) ..................1-19
Engine
Compartment overview .......................................11-8
Coolant ...................................................................... 11-18
Exhaust gas (Carbon monoxide) ....................6, 8-3
Hood ........................................................................... 11-5
Oil ................................................................................. 11-11
Overheating ............................................................. 9-19
Starting ...................................................................... 7-10
Stopping .................................................................... 7-12Exterior care
................................................................... 10-2
F
Flat tires ............................................................................ 9-5
Floor mat .......................................................................... 6-21
Fluid level
Automatic transmission .......................................11-28
Brake ... .. ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. ... ... .. ... .. ... ... .. .. 1 1 -3 6
Clutch .......................................................................... 11-38
Power steering ........................................................ 11-35
Fog light switch ............................................................. 3-24
Folding down the rear seat .......................................1-14
Front Differential gear oil ................................................. 11-30
Fog light ..................................................................... 11-69
Seatbelt pretensioners ........................................1-34
Seats ........................................................................... 1-2
Turn signal light, parking light and
marker light ............................................................ 11-69
Front-wheel drive warning light ..............................3-15
Fuel .................................................................................... 7-2
Economy hints ......................................................... 8-2
Filler lid and cap ..................................................... 7-4
Gauge ......................................................................... 3-8
Requirements .......................................................... 7-2
Fuses ................................................................................. 11-59
Fuses and circuits ........................................................ 12-6

14-6
Index
Manual heating and air conditioning system
...4-5
Manual transmission .................................................. 7-12
Manual transmission oil ............................................ 11-27
Map light ................................................................ 6-3, 11-76
Maximum load limits .................................................. 8-29
Meters and gauges ..................................................... 3-7
Mirrors .............................................................................. 3-31
Moonroof .............................................................. 2-32, 9-29
N
New vehicle break-in driving – the first 1,000 miles (1,600 km) .......................8-2
O
Odometer/Trip meter ................................................. 3-7
Off road driving ............................................................. 8-8
Oil pressure warning light ........................................3-12
Oil filter ............................................................................. 11-12
Oil level Engine ........................................................................ 11-11
Manual transmission ............................................ 11-27
Rear differential ...................................................... 11-32
OnStar®
Personal calling ...................................................... 6-17
Services .................................................................... 6-15
Subscription plans ................................................ 6-15
System ....................................................................... 6-13Limitations
................................................................. 6-18
Virtual advisor .......................................................... 6-17
Outside mirrors .............................................................. 3-33
Overheating engine ..................................................... 9-19
P
Parking Brake stroke ............................................................. 11-43
Light switch ............................................................... 3-23
Power Door locking switches .......................................... 2-5
Steering ...................................................................... 7-30
Steering fluid ............................................................ 11-35
Windows .................................................................... 2-23
Printed antenna ............................................................ 5-2
R
Rear Combination lights ................................................. 11-71
Differential gear oil ................................................. 11-32
Gate ............................................................................. 2-31
Seats ........................................................................... 1-10
Rear seat
Folding down (Wagon) ......................................... 1-14
Rear window Defogger switch ...................................................... 3-28
Wiper and washer switch ....................................3-27