2004 SATURN VUE cooling

Fuses Usage
ECM/CAM
(3.5L V6 (L66))Camshaft Sensor, Main Relay
Voltage To PCM, Ignition Coils 1-6
ETC (2.2L Four
Cylinder (L61))Engine Control Module (ECM),
Electronic Throttle Control
FUEL PUMP Fuel Pump Relay
CIGAR/AUX2 Cigar Lighter
AUX 1 OUTLET Front Auxiliary Power Outlet
FOG LP Fog Lamp Relay
REAR DEFOG Rear Defog Relay
HORN Horn Relay
LH HDLP Left Headlamp
RH HDLP Right Headlamp
INJECTORS
(3.5L V6 (L66))Fuel Injection
PREM AUD Premium Radio Amplier
HTD SEATS Heated SeatsRelays Usage
COOL FAN
HIGHCooling Fan Motor High
COOL FAN
LOWCooling Fan Motor Low
A/C CLUTCH A/C Clutch
PWR WDWPower Window Switch, Sunroof
Module
FRT WIPER Front Wiper System
RR WIPER Rear Wiper System
WIPER
SYSTEMWiper System
ENG MAIN ECM/CAM, EMISS, INJ, ETC
FUEL PUMP Fuel Pump System
DRL Daytime Running Lamps
REAR DEFOG Rear Defog System
HORN Horn
FOG LP Fog Lamps
5-101
ProCarManuals.com

Capacities and Specications
ApplicationCapacities
English Metric
Air Conditioning Refrigerant R134a
2.2L L4 (L61)
3.5L V6 (L66)1.5 lbs
1.75 lbs0.68 kg
0.79 kg
Cooling System
2.2L L4 (L61)
3.5L V6 (L66)7.4 quarts
9.7 quarts7.0 L
9.2 L
Engine Oil with Filter
2.2L L4 (L61)
3.5L V6 (L66)5.0 quarts
4.5 quarts4.7 L
4.3 L
Fuel Tank 16.5 gallons 62.4 L
Transaxle
Automatic, All-wheel drive
Automatic, Two-wheel drive
Manual
VTi Variable4.1 quarts
4.5 quarts
1.8 quarts
6.9 quarts3.9 L
4.3 L
1.7 L
6.5 L
Wheel Nut Torque 92 ft lb 125Y
All capacities are approximate. When adding, be sure to ll to the approximate level, as recommended in this
manual. Recheck uid level after lling.
5-102
ProCarManuals.com

Scheduled Maintenance
Service MaintenanceIMaintenanceII
Change engine oil and lter. Reset oil life system. SeeEngine Oil on
page 5-15.An Emission Control Service.••
Visually check for any leaks or damage.See footnote (j).••
Inspect engine air cleaner lter. If necessary, replace lter. SeeEngine Air
Cleaner/Filter on page 5-21.An Emission Control Service. See footnote †.••
Rotate tires and check ination pressures and wear. SeeTires on page 5-62.••
Inspect brake system.See footnote (a).••
Check engine coolant and windshield washer uid levels and add uid
as needed.••
Perform any needed additional services. See “Additional Required Services”
in this section.••
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Replace passenger compartment air lter.See footnote (k).•
L4 engine: Inspect throttle system.See footnote (g).•
6-5
ProCarManuals.com

Additional Required Services (cont’d)
Service and Miles (Kilometers)25,000
(41 500)50,000
(83 000)75,000
(125 000)100,000
(166 000)125,000
(207 500)150,000
(240 000)
V6 engine: Change transfer
assembly uid (normal service).
See footnote (m).••
V6 engine: Change rear drive
module uid (severe service).
See footnote (h).•••
V6 engine: Change rear drive
module uid (normal service).•
V6 engine: Inspect valve clearance.•
Engine cooling system service
(or every 5 years, whichever occurs
rst).An Emission Control Service.
See footnote (i).•
Inspect engine accessory drive belt.
An Emission Control Service.••••••
6-8
ProCarManuals.com

Maintenance Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
(a)Visually inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc. Inspect
disc brake pads for wear and rotors for surface
condition. Inspect drum brake linings for wear or cracks.
Inspect other brake parts, including drums, wheel
cylinders, calipers, parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose or missing parts or
signs of wear.
(c)Visually inspect hoses and have them replaced if
they are cracked, swollen or deteriorated. Inspect
all pipes, ttings and clamps; replace with genuine
Saturn parts as needed. To help ensure proper
operation, a pressure test of the cooling system and
pressure cap and cleaning the outside of the radiator
and air conditioning condenser is recommended at least
once a year.(d)Visually inspect wiper blades for wear or cracking.
Replace blade inserts that appear worn or damaged
or that streak or miss areas of the windshield.
(e)Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced. Also look for any opened or broken airbag
coverings, and have them repaired or replaced.
(The airbag system does not need regular maintenance.)
(f)Lubricate all key lock cylinders, door hinges and
latches, hood hinges and latches, glove box hinges,
sunroof (if equipped) and any folding seat hardware.
More frequent lubrication may be required when
exposed to a corrosive environment. Applying silicone
grease on weatherstrips with a clean cloth will make
them last longer, seal better and not stick or squeak.
(g)Check system for interference or binding and
for damaged or missing parts. Replace parts as needed.
Replace any components that have high effort or
excessive wear.
6-9
ProCarManuals.com

(h)Severe service is when the vehicle is mainly driven
under one or more of these conditions:
In heavy city traffic where the outside temperature
regularly reaches 90°F (32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
(i)Drain, ush and rell cooling system. See Engine
Coolant on page 5-28 for what to use. Inspect hoses.
Clean radiator, condenser, pressure cap and ller neck.
Pressure test the cooling system and pressure cap.
(j)A uid loss in any vehicle system could indicate a
problem. Have the system inspected and repaired and
the uid level checked. Add uid if needed.
(k)Or every 12 months, whichever occurs rst. If you
drive regularly under dusty conditions, the lter may
require replacement more often.
(m)Change the uid the rst time the vehicle is
serviced after 100,000 miles (166 000 km) and
when the vehicle is serviced after each subsequent
50,000 miles (83 000 km).(n)Severe service is when the vehicle is mainly driven
under one or more of these conditions:
In very high temperatures — over 110°F (43°C).
In very low temperatures — under -20°F (-29°C).
When doing frequent trailer towing.
Owner Checks and Services
These owner checks and services should be performed
at the intervals specied to help ensure the safety,
dependability and emission control performance of your
vehicle. Your Saturn retailer can assist you with these
checks and services.
Be sure any necessary repairs are completed at once.
Whenever any uids or lubricants are added to your
vehicle, make sure they are the proper ones, as shown
inRecommended Fluids and Lubricants on page 6-14.
At Each Fuel Fill
It is important to perform these underhood checks at
each fuel ll.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. SeeEngine Oil on page 5-15for further
details.
6-10
ProCarManuals.com

Control of a Vehicle.......................................... 4-7
Coolant
Engine Temperature Gage............................3-34
Engine Temperature Warning Light.................3-33
Heater, Engine............................................2-17
Low Warning Light.......................................3-34
Surge Tank Pressure Cap.............................5-31
Cooling System..............................................5-34
Cruise Control........................................3-11, 3-14
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users............................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to Saturn.................. 7-9
Reporting Safety Defects to the Canadian
Government.............................................. 7-9
Reporting Safety Defects to the United
States Government.................................... 7-8
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information......... 7-9
D
Daytime Running Lamps..................................3-17
Daytime Running Lamps Indicator Light.............3-40
Defensive Driving............................................. 4-3Defogging and Defrosting.................................3-22
Delayed Locking............................................... 2-8
Dinghy Towing (All-Wheel Drive and
Front-Wheel Drive with VTi Transaxle)............4-46
Dinghy Towing (Manual or Five-Speed
Automatic Transaxle*)...................................4-47
Disabling the Theft-Deterrent Feature.................3-74
Doing Your Own Service Work........................... 5-4
Dolly Towing (All-Wheel Drive Vehicles)..............4-48
Dolly Towing (Front-Wheel Drive Vehicles)..........4-48
Dome Lamp...................................................3-19
Door
Delayed Locking........................................... 2-8
Locks.......................................................... 2-7
Power Door Locks......................................... 2-8
Programmable Automatic Door Locks............... 2-9
Rear Door Security Locks............................... 2-9
Driver
Position, Safety Belt.....................................1-15
Seat Height Adjuster...................................... 1-3
Six-Way Power Seat...................................... 1-3
Driver Behavior................................................ 4-2
Driving
At Night.....................................................4-30
City...........................................................4-35
Defensive..................................................... 4-3
Drunken....................................................... 4-4
Environment................................................. 4-2
4
ProCarManuals.com

Engine Air Cleaner/Filter Replacement...............5-21
Engine Cooling When Trailer Towing..................4-61
Engine Oil Additives........................................5-19
Entry Lighting.................................................3-19
Environmental Concerns..................................4-19
Event Data Recorders (EDR)............................. 7-7
Express-Down Window....................................2-12
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-17
F
Filter
Engine Air Cleaner......................................5-21
Finding a Category (CAT) Station......................3-53
Finding a Station............................3-44, 3-46, 3-51
Finish Care....................................................5-93
Finish Damage...............................................5-95
Five-Speed....................................................2-21
Five-Speed Automatic and VTi Variable..............2-18
Fixed Mast Antenna........................................3-75
Flash-to-Pass................................................... 3-8
Flat Tire........................................................5-77
Flat Tire, Changing.........................................5-78Fluid
Automatic Transaxle.....................................5-25
Manual Transaxle........................................5-27
Windshield Washer......................................5-40
FM Stereo.....................................................3-74
Fog Lamps....................................................3-18
Folding Rear Seat............................................ 1-8
Folding Seatback, Passenger............................. 1-8
Following Distance..........................................4-59
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6
Filling a Portable Fuel Container....................5-10
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-41
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
Low Warning Light.......................................3-42
Fuses
Fuses and Circuit Breakers...........................5-98
Windshield Wiper.........................................5-98
6
ProCarManuals.com