2004 SATURN L-SERIES warning light

Adding Coolant
If you need more coolant, add the proper DEX-COOL®
coolant mixtureat the surge tank, but only when the
engine is cool. SeeEngine Overheating on page 5-26
for instructions on “How to Add Coolant to the Coolant
Surge Tank.”
{CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Do not spill coolant on a hot engine.
When replacing the pressure cap, make sure it is
hand-tight.
Coolant Surge Tank Pressure Cap
Notice:If the pressure cap is not tightly installed,
coolant loss and possible engine damage may
occur. Be sure the cap is properly and tightly
secured.
If you replace your coolant surge tank pressure cap, a
Saturn cap is required.
Engine Overheating
You will nd a coolant temperature gage and a coolant
temperature warning light on your vehicle’s instrument
panel. SeeEngine Coolant Temperature Gage on
page 3-33andEngine Coolant Temperature Warning
Light on page 3-32. You will also nd a low coolant level
warning light on your vehicle’s instrument panel. See
Low Coolant Warning Light on page 3-33.
5-26
ProCarManuals.com

If No Steam Is Coming From Your
Engine
An overheat warning, along with a low coolant light, can
indicate a serious problem. SeeLow Coolant Warning
Light on page 3-33.
If you get an engine overheat warning with no low
coolant light, but see or hear no steam, the problem may
not be too serious. Sometimes the engine can get a
little too hot when you:
Climb a long hill on a hot day.
Stop after high-speed driving.
Idle for long periods in traffic.
Tow a trailer.If you get the overheat warning with no sign of steam,
try this for a minute or so:
1. If you have an air conditioner and it’s on, turn it off.
2. Turn on your heater to full hot at the highest fan
speed and open the window as necessary.
3. Try to minimize engine load. If you’re in a traffic
jam, shift to NEUTRAL (N); otherwise, shift to the
highest gear while driving.
If you no longer have the overheat warning, you can
drive. Just to be safe, drive slower for about ten minutes.
If the warning doesn’t come back on, you can drive
normally.
If the warning continues and you have not stopped, pull
over, stop, and park your vehicle right away.
If there is still no sign of steam, you can idle the engine
for three minutes while you’re parked. If you still
have the warning,turn off the engine and get everyone
out of the vehicleuntil it cools down.
You may decide not to lift the hood but to get service
help right away.
5-28
ProCarManuals.com

Brakes
Brake Fluid
Your brake master cylinder
reservoir is lled with
DOT-3 brake uid. See
Engine Compartment
Overview on page 5-12for
the location of the
reservoir.
There are only two reasons why the brake uid level in
the reservoir might go down. The rst is that the
brake uid goes down to an acceptable level during
normal brake lining wear. When new linings are put in,
the uid level goes back up. The other reason is
that uid is leaking out of the brake system. If it is, you
should have your brake system xed, since a leak
means that sooner or later your brakes will not work
well, or will not work at all.So, it is not a good idea to “top off” your brake uid.
Adding brake uid will not correct a leak. If you add uid
when your linings are worn, then you will have too
much uid when you get new brake linings. You should
add (or remove) brake uid, as necessary, only when
work is done on the brake hydraulic system.
{CAUTION:
If you have too much brake uid, it can spill on
the engine. The uid will burn if the engine is
hot enough. You or others could be burned,
and your vehicle could be damaged. Add brake
uid only when work is done on the brake
hydraulic system.
When your brake uid falls to a low level, your brake
warning light will come on. SeeBrake System Warning
Light on page 3-30.
5-36
ProCarManuals.com

Brake Wear
Your vehicle has four-wheel disc brakes.
Disc brake pads have built-in wear indicators that make
a high-pitched warning sound when the brake pads
are worn and new pads are needed. The sound
may come and go or be heard all the time your vehicle
is moving (except when you are pushing on the
brake pedal rmly).
{CAUTION:
The brake wear warning sound means that
soon your brakes will not work well. That
could lead to an accident. When you hear the
brake wear warning sound, have your vehicle
serviced.
Notice:Continuing to drive with worn-out brake
pads could result in costly brake repair.Some driving conditions or climates may cause a brake
squeal when the brakes are rst applied or lightly
applied. This does not mean something is wrong with
your brakes.
Properly torqued wheel nuts are necessary to help
prevent brake pulsation. When tires are rotated, inspect
brake pads for wear and evenly tighten wheel nuts in
the proper sequence to Saturn torque specications.
Brake linings should always be replaced as complete
axle sets.
Brake Pedal Travel
See your retailer if the brake pedal does not return to
normal height, or if there is a rapid increase in pedal
travel. This could be a sign of brake trouble.
Brake Adjustment
Every time you make a moderate brake stop, your brakes
adjust for wear. If you rarely make a moderate or heavier
stop, then your brakes might not adjust correctly. If you
drive in that way, then — very carefully — make a few
moderate brake stops about every 1,000 miles
(1 600 km), so your brakes will adjust properly.
5-38
ProCarManuals.com

A
Accessory Power Outlets.................................3-16
Activating the Theft-Deterrent Feature................3-69
Adding Windshield Washer Fluid.......................5-35
Additives, Fuel................................................. 5-7
Add-On Electrical Equipment............................5-91
Adjusting the Speakers
(Balance/Fade)............................3-44, 3-47, 3-52
Air Bag
Readiness Light..........................................3-28
Air Bag Systems.............................................1-62
Adding Equipment to Your Air Bag-Equipped
Vehicle...................................................1-72
How Does an Air Bag Restrain?....................1-68
Servicing Your Air Bag-Equipped Vehicle.........1-71
What Makes an Air Bag Inate?....................1-68
What Will You See After an Air Bag Inates?......1-69
When Should an Air Bag Inate?...................1-67
Where Are the Air Bags?..............................1-64
Air Cleaner/Filter, Engine.................................5-20
Airbag Sensing and Diagnostic Module (SDM)...... 7-8
AM ...............................................................3-71
AM-FM Radio.................................................3-42
Antenna, Fixed Mast.......................................3-73
Anti-lock Brake System (ABS)............................ 4-7
Anti-Lock Brake, System Warning Light..............3-31
Appearance Care............................................5-82
Care of Safety Belts....................................5-85
Chemical Paint Spotting...............................5-88Appearance Care (cont.)
Cleaning the Inside of Your Vehicle................5-82
Cleaning the Outside of Your Vehicle..............5-85
Finish Damage............................................5-88
Sheet Metal Damage...................................5-87
Underbody Maintenance...............................5-88
Vehicle Care/Appearance Materials................5-89
Weatherstrips..............................................5-85
Ashtrays........................................................3-17
Assist Handles...............................................2-41
Audio Output..................................................3-61
Audio System(s).............................................3-41
AM-FM Radio.............................................3-42
Care of Your Cassette Tape Player................3-72
Care of Your CD and DVD Player..................3-73
Care of Your CDs and DVDs........................3-73
Fixed Mast Antenna.....................................3-73
Radio with Cassette and CD.........................3-50
Radio with CD............................................3-45
Setting the Time..........................................3-41
Theft-Deterrent Feature................................3-69
Understanding Radio Reception.....................3-71
Automatic Climate Control System.....................3-20
Automatic Dimming Mirror Operation..........2-35, 2-37
Automatic Headlamp System............................3-14
Automatic Operation........................................3-21
Automatic Transaxle........................................2-21
Fluid..........................................................5-23
Operation...................................................2-23
1
ProCarManuals.com

B
Backing Up....................................................4-44
Battery..........................................................5-39
Battery Replacement......................................... 2-7
Battery Run-Down Protection............................3-16
Battery Warning Light......................................3-29
Before Leaving on a Long Trip.........................4-23
Before You Drive............................................3-59
Brake
Parking......................................................2-27
System Warning Light..................................3-30
Brake Fluid....................................................5-36
Brake Wear...................................................5-38
Brakes..........................................................5-36
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-19
Bulb Replacement...........................................5-46
Center High-Mounted
Stoplamp (CHMSL)..........................5-49, 5-50
Fog Lamps.................................................5-49
Halogen Bulbs............................................5-46
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-47
Replacement Bulbs......................................5-52
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps................................5-50, 5-52
Buying New Tires...........................................5-64
C
California Fuel.................................................. 5-6
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Specications............................5-98
Carbon Monoxide...................4-26, 4-40, 2-13, 2-31
Care of
Safety Belts................................................5-85
Your Cassette Tape Player............................3-72
Your CD and DVD Player.............................3-73
Your CDs and DVDs....................................3-73
Cargo Cover..................................................2-43
Cassette Tape Messages.................................3-54
Cassette Tape Player Service............................. 6-9
CD Adapter Kits.............................................3-54
CD Messages........................................3-49, 3-58
Center Console Storage Area...........................2-41
Center High-Mounted Stoplamp (CHMSL)....5-49, 5-50
Center Rear Passenger Position (Wagon)...........1-31
Chains, Tires..................................................5-68
Check
Engine Light...............................................3-34
Checking Coolant............................................5-25
Checking Engine Oil........................................5-16
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-88
2
ProCarManuals.com

Child Restraints
Child Restraint Systems...............................1-42
Infants and Young Children...........................1-38
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-50
Older Children.............................................1-35
Securing a Child Restraint Designed for the
LATCH System........................................1-52
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-56
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-54
Securing a Child Restraint in a Rear Seat
Position..................................................1-52
Securing a Child Restraint in the Right Front
Seat Position...........................................1-58
Top Strap...................................................1-46
Top Strap Anchor Location............................1-47
Where to Put the Restraint...........................1-44
Cigarette Lighter.............................................3-17
Cleaning
Inside of Your Vehicle..................................5-82
Outside of Your Vehicle................................5-85
Underbody Maintenance...............................5-88
Weatherstrips..............................................5-85
Cleaning Aluminum or Chrome-Plated Wheels.....5-87
Cleaning Exterior Lamps/Lenses.......................5-86
Cleaning Fabric/Carpet....................................5-82Cleaning Glass Surfaces..................................5-84
Cleaning Interior Plastic Components.................5-84
Cleaning the DVD Player.................................3-68
Cleaning the Mirror.................................2-36, 2-38
Cleaning the Top of the Instrument Panel...........5-84
Cleaning the Video Screen...............................3-68
Cleaning Tires................................................5-87
Cleaning Vinyl................................................5-84
Cleaning Windshield, Backglass and Wiper
Blades.......................................................5-86
Climate Control System...................................3-17
Air Filter, Passenger Compartment.................3-24
Automatic...................................................3-20
Outlet Adjustment........................................3-24
Compact Spare Tire........................................5-81
Compass Calibration...............................2-35, 2-37
Compass Operation.........................................2-37
Compass Variance..................................2-35, 2-37
Control of a Vehicle.......................................... 4-5
Coolant
Engine Temperature Gage............................3-33
Engine Temperature Warning Light.................3-32
Heater, Engine............................................2-22
Low Warning Light.......................................3-33
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Cruise Control................................................3-10
3
ProCarManuals.com

E
Electrical System
Add-On Equipment......................................5-91
Fuses and Circuit Breakers...........................5-92
Power Windows and Other Power Options......5-92
Windshield Wiper Fuses...............................5-91
Emergency Trunk Release Handle (Sedan).........2-15
Emissions Inspection and Maintenance
Programs...................................................3-36
Engine
Air Cleaner/Filter.........................................5-20
Battery.......................................................5-39
Change Engine Oil Light...............................3-38
Check and Service Engine Soon Light............3-34
Coolant......................................................5-23
Coolant Heater............................................2-22
Coolant Temperature Gage...........................3-33
Coolant Temperature Warning Light................3-32
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-12
Exhaust.....................................................2-31
Oil .............................................................5-16
Overheating................................................5-26
Reduced Power Light...................................3-38
Starting......................................................2-21
Engine Compartment Fuse Block......................5-95
Engine Cooling When Trailer Towing..................4-46
Engine Oil Additives........................................5-18
Entry Lighting.................................................3-15Event Data Recorders (EDR)............................. 7-8
Express-Down Window....................................2-17
Extender, Safety Belt.......................................1-35
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-20
Finding a Station............................3-42, 3-45, 3-50
Finish Care....................................................5-86
Finish Damage...............................................5-88
Fixed Mast Antenna........................................3-73
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-69
Flat Tire, Changing.........................................5-70
Floor Console Fuse Blocks...............................5-92
Fluid
Automatic Transaxle.....................................5-23
Power Steering...........................................5-34
Windshield Washer......................................5-35
FM ...............................................................3-71
Fog Lamps....................................................3-14
Folding Rear Seat............................................ 1-8
Following Distance..........................................4-44
Fuel............................................................... 5-5
Additives...................................................... 5-7
California Fuel.............................................. 5-6
5
ProCarManuals.com