2004 SATURN L-SERIES spare wheel

{CAUTION:
Never use oil or grease on wheel bolts. If you
do, the wheel bolts might come loose. Your
wheel could fall off, causing a serious
accident.
10. Place the compact spare tire on the wheel-mounting
surface.
11. Reinstall the wheel nuts. Tighten each nut by hand
until the wheel is held against the hub.
12. Lower the vehicle by turning the jack handle
counterclockwise.
5-77
ProCarManuals.com

13. Tighten the wheel nuts
rmly in a crisscross
sequence, as shown.
{CAUTION:
Incorrect wheel bolts or improperly tightened
wheel bolts can cause the wheel to come loose
and even come off. This could lead to an
accident. Be sure to use the correct wheel
bolts. If you have to replace them, be sure to
get new Saturn original equipment wheel bolts.
Stop somewhere as soon as you can and have
the bolts tightened with a torque wrench to the
proper torque specication. SeeCapacities
and Specifications on page 5-98for the wheel
bolt torque specication.Notice:Improperly tightened wheel bolts can lead
to brake pulsation and rotor damage. To avoid
expensive brake repairs, evenly tighten the wheel
bolts in the proper sequence and to the proper
torque specication. SeeCapacities and
Specifications on page 5-98for the wheel bolt
torque specication.
14. Lower the jack all the way and remove the jack
from under the vehicle.
15. Tighten the bolts rmly with the wheel wrench.
Do not try to put a wheel cover on your compact spare
tire. It will not t. Store the wheel cover in the trunk
until you have the at tire repaired or replaced.
Notice:Wheel covers will not t on your compact
spare. If you try to put a wheel cover on the compact
spare, you could damage the cover or the spare.
5-78
ProCarManuals.com

1. Place the wheel wrench into the clips on the jack.
2. Install the jack in the left side panel of the trunk
for sedans or the spare tire compartment for
wagons and secure as shown on the jacking
instruction label located in the trunk or cargo area.3. Place the at tire, face down, into the spare tire
compartment. When placing an aluminum at tire
into the spare tire compartment, be very careful
to avoid scraping the wheel face on the hold-down
bolt and other hard surfaces. The hold-down
bolt should pass through the rear most wheel vent
hold. The at tirel will protrude above the trunk
oor in this position.
4. Place the nut onto the hold-down bolt and tighten
down until it is snug.
The compact spare is for temporary use only. Replace
the compact spare tire with a full-size tire as soon
as you can. See the storage instructions label to replace
your compact spare into your trunk or cargo area
separately.
Store the at tire in the compact spare tire compartment
and secure the adapter, extension (aluminum wheel
only) and wing bolt. Store the jack and wheel wrench in
the foam tray. Wagon
5-80
ProCarManuals.com

Compact Spare Tire
Although the compact spare tire was fully inated when
your vehicle was new, it can lose air after a time.
Check the ination pressure regularly. It should be
60 psi (420 kPa).
After installing the compact spare tire on your vehicle,
you should stop as soon as possible and make sure
your compact spare tire is correctly inated. The
compact spare tire is made to perform well at speeds
up to 65 mph (105 km/h) for distances up to 3,000 miles
(5 000 km), so you can nish your trip and have your
full-size tire repaired or replaced where you want.
Of course, it is best to replace your spare with a full-size
tire as soon as you can. Your spare will last longer
and be in good shape in case you need it again.Notice:When the compact spare is installed, don’t
take your vehicle through an automatic car wash
with guide rails. The compact spare can get caught
on the rails. That can damage the tire and wheel,
and maybe other parts of your vehicle.
Do not use your compact spare tire on other vehicles.
And do not mix your compact spare tire or wheel
with other wheels or tires. They won’t t. Keep your
compact spare tire and its wheel together.
Notice:Tire chains won’t t your compact spare.
Using them can damage your vehicle and can
damage the chains too. Don’t use tire chains on
your compact spare.
5-81
ProCarManuals.com

Child Restraints
Child Restraint Systems...............................1-42
Infants and Young Children...........................1-38
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-50
Older Children.............................................1-35
Securing a Child Restraint Designed for the
LATCH System........................................1-52
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-56
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-54
Securing a Child Restraint in a Rear Seat
Position..................................................1-52
Securing a Child Restraint in the Right Front
Seat Position...........................................1-58
Top Strap...................................................1-46
Top Strap Anchor Location............................1-47
Where to Put the Restraint...........................1-44
Cigarette Lighter.............................................3-17
Cleaning
Inside of Your Vehicle..................................5-82
Outside of Your Vehicle................................5-85
Underbody Maintenance...............................5-88
Weatherstrips..............................................5-85
Cleaning Aluminum or Chrome-Plated Wheels.....5-87
Cleaning Exterior Lamps/Lenses.......................5-86
Cleaning Fabric/Carpet....................................5-82Cleaning Glass Surfaces..................................5-84
Cleaning Interior Plastic Components.................5-84
Cleaning the DVD Player.................................3-68
Cleaning the Mirror.................................2-36, 2-38
Cleaning the Top of the Instrument Panel...........5-84
Cleaning the Video Screen...............................3-68
Cleaning Tires................................................5-87
Cleaning Vinyl................................................5-84
Cleaning Windshield, Backglass and Wiper
Blades.......................................................5-86
Climate Control System...................................3-17
Air Filter, Passenger Compartment.................3-24
Automatic...................................................3-20
Outlet Adjustment........................................3-24
Compact Spare Tire........................................5-81
Compass Calibration...............................2-35, 2-37
Compass Operation.........................................2-37
Compass Variance..................................2-35, 2-37
Control of a Vehicle.......................................... 4-5
Coolant
Engine Temperature Gage............................3-33
Engine Temperature Warning Light.................3-32
Heater, Engine............................................2-22
Low Warning Light.......................................3-33
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Cruise Control................................................3-10
3
ProCarManuals.com

Playing the Radio...........................3-42, 3-45, 3-50
Playing the Single CD Player...........................3-54
Playing the Six–Disc CD Player........................3-56
Power............................................................. 1-4
Accessory Outlets........................................3-16
Door Locks.................................................2-10
Electrical System.........................................5-92
Reduced Engine Light..................................3-38
Steering Fluid.............................................5-34
Windows....................................................2-17
Power Steering...............................................4-10
Programmable Automatic Door Locks.................2-11
Q
Questions and Answers About Safety Belts.........1-15
R
Radios..........................................................3-41
AM-FM Radio.............................................3-42
Care of Your Cassette Tape Player................3-72
Care of Your CD and DVD Player..................3-73
Care of Your CDs and DVDs........................3-73
Radio with Cassette and CD.........................3-50
Radio with CD............................................3-45
Setting the Time..........................................3-41
Theft-Deterrent............................................3-69
Understanding Reception..............................3-71Rear Door Security Locks................................2-11
Rear Safety Belt Comfort Guides......................1-33
Rear Seat Entertainment System.......................3-59
Rear Seat Outside Passenger
Positions (Wagon).......................................1-28
Rear Seat Passenger Positions (Sedan).............1-25
Rear Seat Passengers, Safety Belts..................1-25
Rear Window Defogger............................3-20, 3-23
Rear Window Wiper/Washer (Wagon).................. 3-9
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display................2-36
Rearview Mirror, Automatic Dimming with OnStar
®,
Compass and Temperature Display..................2-34
Rearview Mirror with OnStar
®...........................2-33
Rearview Mirrors.............................................2-33
Reclining Seatbacks.......................................... 1-5
Recommended Fluids and Lubricants.................6-12
Recreational Vehicle Towing.............................4-32
Reduced Engine Power Light............................3-38
Remote Control..............................................3-64
Remote Keyless Entry System............................ 2-4
Remote Keyless Entry System, Operation............ 2-5
Removing the Cargo Cover..............................2-44
Removing the Flat Tire and Installing the
Spare Tire..................................................5-74
Removing the Spare Tire and Tools (Sedan).......5-71
Removing the Spare Tire and Tools (Wagon)......5-72
Removing the Wheel.......................................5-74
Replacement Bulbs.........................................5-52
Replacing Brake System Parts..........................5-39
10
ProCarManuals.com

Service........................................................... 5-3
Adding Equipment to the Outside of Your
Vehicle..................................................... 5-5
Doing Your Own Work................................... 5-4
Engine Soon Light.......................................3-34
Publications Ordering Information...................7-10
Vehicle Soon Light.......................................3-39
Service Bulletins.............................................7-11
Service Engine Soon Light...............................3-34
Service Manuals.............................................7-10
Setting Preset Stations....................3-43, 3-46, 3-51
Setting the Time.............................................3-41
Setting the Tone (Bass/Treble)..........3-44, 3-47, 3-52
Sheet Metal Damage.......................................5-87
Shift Lock Release..........................................2-26
Shifting Into Park (P).......................................2-28
Shifting Out of Park (P)...................................2-30
Shoulder Belt Height Adjuster...........................1-19
Skidding........................................................4-14
Some Other Rainy Weather Tips.......................4-20
Special Fabric Cleaning Problems.....................5-83
Specications, Capacities.................................5-98
Speedometer..................................................3-27
Split Folding Rear Seat..................................... 1-8
Starting Your Engine.......................................2-21
Steering........................................................4-10
Steering in Emergencies..................................4-11
Steering Tips..................................................4-10
Steering Wheel, Tilt Wheel................................. 3-5
Stereo RCA Jacks..........................................3-60Storage Areas
Center Console Storage Area........................2-41
Glove Box..................................................2-41
Load Floor Storage Box...............................2-42
Roof Rack System.......................................2-42
Storing a Flat or Spare Tire and Tools...............5-79
Stuck in Sand, Mud, Ice or Snow......................4-30
Sun Visors.....................................................2-18
Sunroof.........................................................2-45
T
Tachometer....................................................3-27
Taillamps
Turn Signal, Stoplamps and
Back-up Lamps................................5-50, 5-52
TCS Warning Light..........................................3-32
Temperature and Compass Display....................2-34
Temperature Display........................................2-37
Theft-Deterrent, Radio.....................................3-69
Theft-Deterrent System...................................... 2-6
Theft-Deterrent Systems...................................2-18
Passlock
®...................................................2-18
Tilt Wheel........................................................ 3-5
Tire Ination Check........................................... 6-9
Tire Sidewall Labeling......................................5-54
Tire Size.......................................................5-58
Tire Terminology and Denitions........................5-59
Tires.............................................................5-54
12
ProCarManuals.com

Buying New Tires........................................5-64
Chains.......................................................5-68
Changing a Flat Tire....................................5-70
Compact Spare Tire.....................................5-81
If a Tire Goes Flat.......................................5-69
Ination - Tire Pressure................................5-61
Inspection and Rotation................................5-62
Uniform Tire Quality Grading.........................5-65
Wheel Alignment and Tire Balance.................5-67
Wheel Replacement.....................................5-67
When It Is Time for New Tires......................5-64
To Use the Engine Coolant Heater....................2-22
Top Strap......................................................1-46
Top Strap Anchor Location...............................1-47
Torque Lock...................................................2-29
Total Weight on Your Vehicle’s Tires..................4-42
Towing
Recreational Vehicle.....................................4-32
Towing a Trailer..........................................4-40
Your Vehicle...............................................4-32
Traction
Control System (TCS).................................... 4-9
Control System Warning Light.......................3-32
Trailer Brakes.................................................4-43
Transaxle
Fluid, Automatic...........................................5-23
Transaxle Operation, Automatic.........................2-23
Trap-Resistant Trunk Kit...................................2-15
Trunk Ajar Light..............................................3-39
Trunk (Sedan)................................................2-13Trunk/Liftgate.................................................2-13
Turn and Lane-Change Signals.......................... 3-6
Turn Signal/Multifunction Lever........................... 3-6
Turn Signals When Towing a Trailer..................4-45
U
Understanding Radio Reception........................3-71
Uniform Tire Quality Grading............................5-65
Unlocking the Theft-Deterrent Feature After a
Power Loss................................................3-70
Used Replacement Wheels..............................5-68
Using Cleaner on Fabric..................................5-83
Using the Recovery Hook................................4-31
V
Vehicle
Control........................................................ 4-5
Damage Warnings........................................... iv
Loading......................................................4-34
Service Soon Light......................................3-39
Symbols......................................................... iv
Vehicle Data Collection and Event Data
Recorders.................................................... 7-8
Vehicle Identication
Number (VIN).............................................5-90
Service Parts Identication Label...................5-91
13
ProCarManuals.com