2004 SATURN L-SERIES coolant temperature

Adding Coolant
If you need more coolant, add the proper DEX-COOL®
coolant mixtureat the surge tank, but only when the
engine is cool. SeeEngine Overheating on page 5-26
for instructions on “How to Add Coolant to the Coolant
Surge Tank.”
{CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Do not spill coolant on a hot engine.
When replacing the pressure cap, make sure it is
hand-tight.
Coolant Surge Tank Pressure Cap
Notice:If the pressure cap is not tightly installed,
coolant loss and possible engine damage may
occur. Be sure the cap is properly and tightly
secured.
If you replace your coolant surge tank pressure cap, a
Saturn cap is required.
Engine Overheating
You will nd a coolant temperature gage and a coolant
temperature warning light on your vehicle’s instrument
panel. SeeEngine Coolant Temperature Gage on
page 3-33andEngine Coolant Temperature Warning
Light on page 3-32. You will also nd a low coolant level
warning light on your vehicle’s instrument panel. See
Low Coolant Warning Light on page 3-33.
5-26
ProCarManuals.com

Windshield Washer Fluid
What to Use
When you need windshield or rear window (wagon
models) washer uid be sure to read the instructions
before use. If you will be operating your vehicle in
an area where the temperature may fall below freezing,
use a uid that has sufficient protection against
freezing.
Adding Windshield Washer Fluid
Open the cap with the
washer uid symbol
printed on it and add
washer uid until the tank
is full.Notice:
When using concentrated washer uid, follow
the manufacturer’s instructions for adding
water.
Do not mix water with ready-to-use washer uid.
Water can cause the solution to freeze and
damage your washer uid tank and other parts
of the washer system. Also, water does not
clean as well as washer uid.
Fill your washer uid tank only three-quarters
full when it is very cold. This allows for
expansion if freezing occurs, which could
damage the tank if it is completely full.
Do not use engine coolant (antifreeze) in your
windshield washer. It can damage your washer
system and paint.
5-35
ProCarManuals.com

(c)Visually inspect hoses and have them replaced if
they are cracked, swollen or deteriorated. Inspect
all pipes, ttings and clamps; replace with genuine
Saturn parts as needed. To help ensure proper
operation, a pressure test of the cooling system and
pressure cap and cleaning the outside of the radiator
and air conditioning condenser is recommended at least
once a year.
(d)Visually inspect wiper blades for wear or cracking.
Replace blade inserts that appear worn or damaged
or that streak or miss areas of the windshield.
(e)Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced. Also look for any opened or broken air bag
coverings, and have them repaired or replaced. (The air
bag system does not need regular maintenance.)
(f)Lubricate all key lock cylinders, door hinges and
latches, hood hinges and latches, glove box hinges,
sunroof (if equipped) and any folding seat hardware.
More frequent lubrication may be required when
exposed to a corrosive environment. Applying silicone
grease on weatherstrips with a clean cloth will make
them last longer, seal better and not stick or squeak.(g)Check system for interference or binding and for
damaged or missing parts. Replace parts as needed.
Replace any components that have high effort or
excessive wear. Do not lubricate accelerator or cruise
control cables.
(h)Change automatic transaxle uid and lter if the
vehicle is mainly driven under one or more of these
conditions:
In heavy city traffic where the outside temperature
regularly reaches 90°F (32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police or delivery
service.
If you do not use your vehicle under any of these
conditions, the uid and lter do not require changing.
(i)Drain, ush and rell cooling system. See Engine
Coolant on page 5-23 for what to use. Inspect hoses.
Clean radiator, condenser, pressure cap and ller neck.
Pressure test the cooling system and pressure cap.
(j)A uid loss in any vehicle system could indicate a
problem. Have the system inspected and repaired and
the uid level checked. Add uid if needed.
(k)Or every 12 months, whichever occurs rst. If you
drive regularly under dusty conditions, the lter may
require replacement more often.
6-8
ProCarManuals.com

Child Restraints
Child Restraint Systems...............................1-42
Infants and Young Children...........................1-38
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-50
Older Children.............................................1-35
Securing a Child Restraint Designed for the
LATCH System........................................1-52
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-56
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-54
Securing a Child Restraint in a Rear Seat
Position..................................................1-52
Securing a Child Restraint in the Right Front
Seat Position...........................................1-58
Top Strap...................................................1-46
Top Strap Anchor Location............................1-47
Where to Put the Restraint...........................1-44
Cigarette Lighter.............................................3-17
Cleaning
Inside of Your Vehicle..................................5-82
Outside of Your Vehicle................................5-85
Underbody Maintenance...............................5-88
Weatherstrips..............................................5-85
Cleaning Aluminum or Chrome-Plated Wheels.....5-87
Cleaning Exterior Lamps/Lenses.......................5-86
Cleaning Fabric/Carpet....................................5-82Cleaning Glass Surfaces..................................5-84
Cleaning Interior Plastic Components.................5-84
Cleaning the DVD Player.................................3-68
Cleaning the Mirror.................................2-36, 2-38
Cleaning the Top of the Instrument Panel...........5-84
Cleaning the Video Screen...............................3-68
Cleaning Tires................................................5-87
Cleaning Vinyl................................................5-84
Cleaning Windshield, Backglass and Wiper
Blades.......................................................5-86
Climate Control System...................................3-17
Air Filter, Passenger Compartment.................3-24
Automatic...................................................3-20
Outlet Adjustment........................................3-24
Compact Spare Tire........................................5-81
Compass Calibration...............................2-35, 2-37
Compass Operation.........................................2-37
Compass Variance..................................2-35, 2-37
Control of a Vehicle.......................................... 4-5
Coolant
Engine Temperature Gage............................3-33
Engine Temperature Warning Light.................3-32
Heater, Engine............................................2-22
Low Warning Light.......................................3-33
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Cruise Control................................................3-10
3
ProCarManuals.com

E
Electrical System
Add-On Equipment......................................5-91
Fuses and Circuit Breakers...........................5-92
Power Windows and Other Power Options......5-92
Windshield Wiper Fuses...............................5-91
Emergency Trunk Release Handle (Sedan).........2-15
Emissions Inspection and Maintenance
Programs...................................................3-36
Engine
Air Cleaner/Filter.........................................5-20
Battery.......................................................5-39
Change Engine Oil Light...............................3-38
Check and Service Engine Soon Light............3-34
Coolant......................................................5-23
Coolant Heater............................................2-22
Coolant Temperature Gage...........................3-33
Coolant Temperature Warning Light................3-32
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-12
Exhaust.....................................................2-31
Oil .............................................................5-16
Overheating................................................5-26
Reduced Power Light...................................3-38
Starting......................................................2-21
Engine Compartment Fuse Block......................5-95
Engine Cooling When Trailer Towing..................4-46
Engine Oil Additives........................................5-18
Entry Lighting.................................................3-15Event Data Recorders (EDR)............................. 7-8
Express-Down Window....................................2-17
Extender, Safety Belt.......................................1-35
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-20
Finding a Station............................3-42, 3-45, 3-50
Finish Care....................................................5-86
Finish Damage...............................................5-88
Fixed Mast Antenna........................................3-73
Flash-to-Pass................................................... 3-7
Flat Tire........................................................5-69
Flat Tire, Changing.........................................5-70
Floor Console Fuse Blocks...............................5-92
Fluid
Automatic Transaxle.....................................5-23
Power Steering...........................................5-34
Windshield Washer......................................5-35
FM ...............................................................3-71
Fog Lamps....................................................3-14
Folding Rear Seat............................................ 1-8
Following Distance..........................................4-44
Fuel............................................................... 5-5
Additives...................................................... 5-7
California Fuel.............................................. 5-6
5
ProCarManuals.com

Fuel (cont.)
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-8
Fuels in Foreign Countries.............................. 5-7
Gage.........................................................3-40
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-6
Low Warning Light.......................................3-40
Fuses
Fuses and Circuit Breakers...........................5-92
Windshield Wiper.........................................5-91
G
Gage
Engine Coolant Temperature.........................3-33
Fuel..........................................................3-40
Speedometer..............................................3-27
Tachometer.................................................3-27
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-6
Glove Box.....................................................2-41
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-4
Head Restraints............................................... 1-7
Headlamp High/Low-Beam Changer.................... 3-7
Headlamps..............................................3-7, 3-13
Bulb Replacement.......................................5-46
Halogen Bulbs............................................5-46
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-47
Headphones...................................................3-59
Heated Seats................................................... 1-5
Height Adjuster, Driver Seat............................... 1-3
Highway Hypnosis...........................................4-23
Hill and Mountain Roads..................................4-24
Hitches..........................................................4-43
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-5
How to Add Coolant to the Coolant
Surge Tank.................................................5-31
How to Check................................................5-62
How to Check Power Steering Fluid..................5-34
How to Inspect the Engine Air Cleaner/Filter.......5-20
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-16
Hydroplaning..................................................4-19
6
ProCarManuals.com

I
If No Steam Is Coming From Your Engine..........5-28
If Steam Is Coming From Your Engine...............5-27
If the Light Is Flashing.....................................3-35
If the Light Is On Steady.................................3-35
If You Are Caught in a Blizzard.........................4-28
If You Are Stuck in Sand, Mud, Ice or Snow.......4-30
If You Do Decide to Pull a Trailer......................4-41
Ignition Positions.............................................2-20
Infants and Young Children, Restraints...............1-38
Ination - Tire Pressure...................................5-61
Installing the Cargo Shade...............................2-44
Instrument Panel
Cluster.......................................................3-26
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-15
Interior Lamps................................................3-15
J
Jump Starting.................................................5-40
K
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Lamps
Exterior......................................................3-13
Fog Lamps.................................................5-49
Interior.......................................................3-15
Lap Belt........................................................1-32
Lap-Shoulder Belt...........................1-17, 1-26, 1-29
LATCH System
Child Restraints...........................................1-50
Securing a Child Restraint Designed for the
LATCH System........................................1-52
Leaving Your Vehicle.......................................2-12
Leaving Your Vehicle With the
Engine Running..........................................2-29
Liftgate Release (Wagon).................................2-14
Liftgate/Trunk.................................................2-13
Light
Air Bag Readiness.......................................3-28
Anti-Lock Brake System Warning...................3-31
Battery Warning..........................................3-29
Brake System Warning.................................3-30
Change Engine Oil......................................3-38
Daytime Running Lamps Indicator..................3-39
Engine Coolant Temperature Warning.............3-32
Low Coolant Warning...................................3-33
Low Fuel Warning.......................................3-40
Low Washer Fluid Warning...........................3-39
7
ProCarManuals.com