2004 SATURN ION roof rack

Mirrors...........................................................2-36
Manual Rearview Mirror.................................2-36
Manual Rearview Mirror with OnStar
®................2-36
Automatic Dimming Rearview Mirror with
OnStar
®, Compass and Temperature
Display....................................................2-37
Automatic Dimming Rearview Mirror with
Compass and Temperature Display..............2-40
Outside Remote Control Mirror.......................2-42
Outside Power Mirrors...................................2-42
Outside Convex Mirror...................................2-42OnStar
®System.............................................2-43
Storage Areas................................................2-44
Glove Box...................................................2-44
Cupholder(s)................................................2-44
Center Console Storage Area.........................2-44
Roof Rack System........................................2-45
Convenience Net..........................................2-45
Sunroof.........................................................2-45
Section 2 Features and Controls
2-2
ProCarManuals.com

Roof Rack System
If your vehicle has a roof rack, you can load things on
top of your vehicle.
Notice:Loading cargo on the luggage carrier that
weighs more than 100 lbs. (45 kg) or hangs over the
rear or sides of the vehicle may damage your
vehicle. Load cargo so that it rests on the slats
as far forward as possible and against the side rails,
making sure to fasten it securely.
Don’t exceed the maximum vehicle capacity when
loading your vehicle. SeeLoading Your Vehicle
on page 4-33for more information.
To prevent damage or loss of cargo as you are driving,
check now and then to make sure the roof rack and
cargo are securely fastened.
Convenience Net
If you have a convenience net, the net attaches to the
oor of the trunk. Put small loads behind the net.
The net is not for heavier loads. Store them as far
forward in the trunk as you can.
See your retailer for information on obtaining a
convenience net.
Sunroof
Your vehicle may have a sunroof. With the ignition on,
press and hold the OPEN/VENT part of the switch
and the glass panel will open to the vent position.
Press and hold the OPEN/VENT part of the switch again
to open the glass panel.
Press and hold the CLOSE part of the switch to close
the glass panel. The sunshade can only be closed
by hand.
2-45
ProCarManuals.com

Maintenance Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
(a)Visually inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc. Inspect
disc brake pads for wear and rotors for surface
condition. Inspect drum brake linings for wear or cracks.
Inspect other brake parts, including drums, wheel
cylinders, calipers, parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose or missing parts or
signs of wear.
(c)Visually inspect hoses and have them replaced if
they are cracked, swollen or deteriorated. Inspect
all pipes, ttings and clamps; replace with genuine
Saturn parts as needed. To help ensure proper
operation, a pressure test of the cooling system and
pressure cap and cleaning the outside of the radiator
and air conditioning condenser is recommended at least
once a year.(d)Visually inspect wiper blades for wear or cracking.
Replace blade inserts that appear worn or damaged
or that streak or miss areas of the windshield.
(e)Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced. Also look for any opened or broken air bag
coverings, and have them repaired or replaced. (The air
bag system does not need regular maintenance.)
(f)Lubricate all key lock cylinders, door hinges and
latches, hood hinges and latches, glove box hinges,
sunroof (if equipped) and any folding seat hardware.
More frequent lubrication may be required when
exposed to a corrosive environment. Applying silicone
grease on weatherstrips with a clean cloth will make
them last longer, seal better and not stick or squeak.
(g)Check system for interference or binding and
for damaged or missing parts. Replace parts as needed.
Replace any components that have high effort or
excessive wear. Do not lubricate accelerator or cruise
control cables.
6-8
ProCarManuals.com

Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
Washer SolventOptikleen
®Washer Solvent.
Parking Brake
Cable GuidesChassis Lubricant (GM Part No.
12377985, in Canada 88901242) or
lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Hydraulic
Clutch SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid
(Saturn Part No. 21013073).
Manual
TransaxleDEXRON III Manual Transaxle
Lubricant (Part No. 21019223).
5-Speed
Automatic
TransaxleSaturn T-IV Fluid
(Part No. 22689186).
VTi Variable
TransaxleDEX-CVT Fluid (Part No. 22688912).
VTi Variable
Transaxle
AdditiveDEX-CVT Fluid Additive
(Part No. 22697447).
Usage Fluid/Lubricant
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol
(Saturn Part No. 21038869 or
GM Part No. U.S. 12346293,
in Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood, Trunk
and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
Sunroof TrackLubriplate Lubricant Aerosol
(Saturn Part No. 21038869 or
GM Part No. U.S. 12346293,
in Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Weatherstrip
ConditioningDielectric Silicone Grease
(GM Part No. U.S. 12345579,
in Canada 992887).
6-15
ProCarManuals.com

Reporting Safety Defects
Canadian Government................................... 7-9
Saturn......................................................... 7-9
United States Government.............................. 7-9
Restraint System Check
Checking Your Restraint Systems...................1-59
Replacing Restraint System Parts
After a Crash..........................................1-59
Restraint Systems
Checking....................................................1-59
Replacing Parts...........................................1-59
Retained Accessory Power (RAP)......................2-19
Right Front Passenger Position, Safety Belts........1-22
Roadside
Assistance Program....................................... 7-5
Roof Rack System..........................................2-45
Routing, Engine Drive Belt...............................6-17
Running Your Engine While You Are Parked.......2-35
S
Safety Belt
Pretensioners..............................................1-28
Reminder Light............................................3-30
Safety Belts
Care of......................................................5-89
Driver Position............................................1-14Safety Belts (cont.)
How to Wear Safety Belts Properly................1-14
Questions and Answers About Safety Belts........1-13
Rear Safety Belt Comfort Guides for
Children and Small Adults.........................1-26
Rear Seat Passengers.................................1-22
Right Front Passenger Position......................1-22
Safety Belt Extender....................................1-28
Safety Belt Use During Pregnancy.................1-21
Safety Belts Are for Everyone......................... 1-8
Safety Chains.................................................4-42
Safety Warnings and Symbols.............................. iii
Scheduled Maintenance..................................... 6-4
Seatback, Folding Passenger............................. 1-6
Seats
Driver Seat Height Adjuster............................. 1-3
Head Restraints............................................ 1-5
Manual........................................................ 1-2
Passenger Folding Seatback........................... 1-6
Reclining Seatbacks...................................... 1-3
Split Folding Rear Seat.................................. 1-7
Securing a Child Restraint
Designed for the LATCH System...................1-44
Rear Seat Position......................................1-44
Right Front Seat Position..............................1-47
Security While You Travel.................................. 7-5
12
ProCarManuals.com

Service........................................................... 5-3
Adding Equipment to the Outside of
Your Vehicle.............................................. 5-4
Doing Your Own Work................................... 5-4
Engine Soon Light.......................................3-36
Publications Ordering Information...................7-10
Vehicle Message.........................................3-45
Service Bulletins.............................................7-10
Service Engine Soon Light...............................3-36
Service Manuals.............................................7-10
Setting Preset Stations....................3-48, 3-51, 3-57
Setting the Time
Radios with Radio Data Systems (RDS).........3-47
Radios without Radio Data
Systems (RDS)........................................3-46
Setting the Tone (Bass/Treble)..........3-49, 3-52, 3-58
Sheet Metal Damage.......................................5-92
Shift Lock Release..........................................2-26
Shift Speeds..................................................2-29
Shifting Into Park (P).......................................2-31
Shifting Out of Park (P)...................................2-33
Shoulder Belt Height Adjuster (Sedan)...............1-16
Skidding........................................................4-14
Some Other Rainy Weather Tips.......................4-19
Special Fabric Cleaning Problems.....................5-88
Specications, Capacities...............................5-102Speedometer..................................................3-29
Split Folding Rear Seat..................................... 1-7
Starting Your Engine.......................................2-20
Steering.......................................................... 4-9
Steering in Emergencies..................................4-11
Steering Tips..................................................4-10
Steering Wheel, Tilt Wheel................................. 3-7
Storage Areas
Center Console Storage Area........................2-44
Convenience Net.........................................2-45
Cupholder(s)...............................................2-44
Glove Box..................................................2-44
Roof Rack System.......................................2-45
Storing the Flat or Spare Tire and Tools................5-84
Stuck in Sand, Mud, Ice or Snow......................4-30
Sun Visors.....................................................2-16
Sunroof.........................................................2-45
T
Tachometer....................................................3-29
Taillamps
Stoplamps, and Back-Up Lamps....................5-55
Temperature and Compass Display....................2-37
Temperature Display........................................2-40
Theft-Deterrent, Radio.....................................3-68
13
ProCarManuals.com