2004 PORSCHE CAYENNE fuel pump

268
Maintenance and Car Care
RefuelingfTotal capacity approx. 26.4 gallons
(100 liters), including approx. 3 gallons
(12 liters) reserve.
Danger!
The RF energy from a cellphone can cause a
sparking on bare metal, much like aluminum
foil in a microwave oven. The spark could
ignite gasoline fumes present while refuling.
Static discharge from your body can ignite
gasoline fumes present when you get back
out of the vehicle and touch the fuel nozzle.
In either case, resulting fire can cause
serious damage to the vehicle, serious injury
or death to persons in immediate vicinity.
fDo not use a cellphone while pumping gas.
fDo not re-enter the vehicle while pumping gas.
1. Stop the engine and switch off the ignition.2. Slowly unscrew the tank cap.
Hang the tank cap’s plastic strap on the
hookA on the inside wall of the filler flap.
3. Insert pump nozzle fully into the filler neck with
the handle of the pump nozzle facing down.
4. Do not add further fuel once the correctly
operated automatic pump nozzle has switched
off.
Fuel could spray or could run over when
heated.
5. Replace the tank cap immediately after
refueling and turn it until you hear it and feel it
engage.Maintenance Note
If you lose the tank filler cap, you must replace it
only with an original part.
Caution!
Risk of damage. Decorative foils may bleach
of they come into contact with fuel.
fWipe off any spilt fuel immediately.Portable Fuel Containers
Danger!
Portable fuel containers, full or partially
empty, may leak causing an explosion, or
result in fire in case of an accident.
fNever carry additional fuel in portable contai-ners in your vehicle.
10_Cayenne_21_KW17.book Seite 268 Donnerstag, 9. April 2009 3:33 15

Maintenance and Car Care
269
Fuel RecommendationsYour Porsche is equipped with catalytic conver-
ters and must use UNLEADED FUEL ONLY.
Your engine is designed to provide optimum
performance and fuel economy using unleaded
premium fuel with an octane rating of 98 RON
(93 CLC or AKI). Porsche therefore recom-
mends the use of these fuels in your vehicle.
Porsche also recognizes that these fuels may not
always be available. Be assured that your vehicle
will operate properly on unleaded premium fuels
with octane numbers of at least 95 RON
(90 CLC or AKI), since the engine's “Electronic
Octane™ knock control” will adapt the ignition
timing, if necessary.
It is important to observe the regular service inter-
vals, and particularly the oil change intervals, spe-
cified in your Maintenance Schedule.
The use of UNLEADED FUEL ONLY is critically
important to the life of the catalytic
converters. Deposits from leaded fuels will
ruin the converters and make it ineffective
as an emission control device.
Cars with catalytic converters have a smaller fuel
tank opening, and gas station pumps have smaller
nozzles. This will prevent accidental pumping of
leaded fuel into cars with catalytic converters.Unleaded fuels may not be available outside the
continental U.S. and Canada. Therefore, we
recommend you do not take your car to areas or
countries where unleaded fuel may not be
available.
Octane ratingsOctane rating indicates a fuel's ability to resist
detonation. Therefore, buying the correct octane
gas is important to prevent engine “damage”.
The RON octane rating is based on the research
method. The CLC (U.S. Cost of Living Council oc-
tane rating) or AKI (antiknock index) octane rating
usually displayed on U.S. fuel pumps is calculated
as research octane number plus motor octane
number, divided by 2, that is written as:
The CLC or AKI octane rating is usually lower than
the RON rating:
For example: 95 RON corresponds 90 CLC or
“AKI”
fDo not use fuel additives without Porsche
approval.
Fuels containing ethanolfDo not use any fuels containing more than 10
percent ethanol by volume.
We recommend, however, to change to a different
fuel or station if any of the following problems
occur with your vehicle:
– Deterioration of driveability and performance.
– Substantially reduced fuel economy.
– Vapor lock and non-start problems, especially
at high altitude or at high temperature.
– Engine malfunction or stalling.
RON MON+
2 ----------------------------------
orRM+
2 ---------------
10_Cayenne_21_KW17.book Seite 269 Donnerstag, 9. April 2009 3:33 15

Minor Repairs
319
Fuse assignment – fuse box in engine compartmentNotes
fUse the plastic grippers from the fuse boxes in the dashboard to replace the fuses.
Fuse numbers that are not listed in the table are not assigned in the fuse box.
fFor information on the fuse plan: Please see the chapter “FUSE PLAN AND FUSE BOX IN ENGINE COMPARTMENT” on Page 313. Cayenne
No.Cayenne S/Cayenne GTS/
Cayenne S Transsyberia
No.Designation Rating in A
1
1
Fan
60
22Fan30
7
7
Ignition coils
15
8 - Ignition coils15
-8Tank vent valve, air-conditioning compressor, air-conditioning control unit, intake pipe switch-
over, crankcase vent15
9
-
Engine control unit
20
-
9
Quantity control valve, camshaft adjuster, valve lift adjuster
15
10 -Water run-on pump relay, tank leakage detection, carbon canister shut-off valve, fan, pressure
sensor for air conditioner10
-10Cooling air output stages, pressure sensor for air conditioner,tank leakage detection, exhaust
flap control valve, oil-level sensor10
11
-
Oil-level sensor, air-conditioning compressor, air-conditioning control unit, crankcase vent
15
-
11
Engine control unit, fuel valve
15
12 - Camshaft adjustment, tank vent, fuel valve, variable intake manifold 10
13
13
Fuel pump, right
15
14 14 Fuel pump, left15
15
15
Engine control unit, main relay
10
17 17 Oxygen sensors ahead of catalytic converter 15
18
18
Oxygen sensors behind catalytic converter
7.5
10_Cayenne_21_KW17.book Seite 319 Donnerstag, 9. April 2009 3:33 15