2004 PORSCHE CAYENNE wheel bolts

302
Minor Repairs
Vehicles with side member panels
Rear jacking point2. Attach jack only at the points provided G or I .
Fitting covering cap:
fInsert the covering cap F or H completely in
the slots of the side member panel with both
centring lugs and fold back until it can be felt
to engage.
Wheel change1. Remove 1 or 2 wheel bolts (see corresponding
figure).
Caution!
Risk of damage to the brake discs.
fAlways screw in the assembly aids when changing a wheel.
Screw in one assembly aid on vehicles without PCCB2. Screw in assembly aids instead of wheel bolts.
10_Cayenne_21_KW17.book Seite 302 Donnerstag, 9. April 2009 3:33 15

Minor Repairs
303
Screw in two assembly aids on vehicles with PCCB3. Remove the remaining wheel bolts.
For more information on wheel bolts:
Please see the chapter “WHEEL BOLTS” on
Page 293.
4. Change wheel.5. Insert wheel bolts and tighten by hand. Remo-
ve assembly aids and screw in remaining
wheel bolt.
Initially tighten bolts in diagonally opposite se-
quence so that the wheel is centered.
6. Inflate the tire if necessary.
Please see the chapter “TIRE PRESSURES,
COLD (68 °F/20 °C)” on Page 354.
In vehicles with tire pressure monitoring:
Please see the chapter “SETTING THE TIRE
TYPE AND SIZE” on Page 134.
7. Lower car and remove jack.
8. Tighten wheel bolts in diagonally opposite se-
quence.
Tire Pressure Monitoring:
The settings on the multi-purpose display must be
updated after a wheel change.
fPlease see the chapter “SETTING TIRE PRES-
SURE MONITORING” on Page 132.
Maintenance Note
fImmediately after changing a wheel, use
a torque wrench to check the prescribed
tightening torque of the wheel bolts
(118 ftlb./160 Nm).
Changing a wheel with removal of 17 mm
spacer
Danger!
Risk of accident if the spacers are not
removed before mounting 18 inch tires or
collapsible spare wheel.
f17 mm spacers are always to be removed
before mounting 18 inch tires or a collapsible
spare wheel, because the wheel cannot be fitted correctly. Caution!
Risk of damage to wheel housings if the
spacers on the rear axle are not removed be-
fore fitting the snow chains.
f17 mm spacers must always be removed from the rear axle when snow chains are to be fitted.
fRemove spacers if 18 inch tires, snow chains
or a collapsible spare wheel are mounted.
fIt is not necessary to use a assembly aid for
mounting a wheel or spare wheel of the same
quality.
fFor information on the spacers: Please see the
chapter “SPACERS” on Page 293.
10_Cayenne_21_KW17.book Seite 303 Donnerstag, 9. April 2009 3:33 15

304
Minor Repairs
Puller1. Remove plastic covers from the wheel nuts
with the puller D.2. Remove wheel nuts. 3. Unscrew the wheel bolts A with which the
spacer B is fastened.
4. Remove the spacer B.
5. Screw in assembly aid instead of the wheel
bolt.
6. Fit wheel.
7. Use the wheel bolts A with which the spacer B
was fastened to mount the wheel.
Insert wheel bolts and tighten by hand.
Remove assembly aid and screw in remaining
wheel bolt.
Initially tighten bolts in diagonally opposite
sequence so that the wheel is centered.10_Cayenne_21_KW17.book Seite 304 Donnerstag, 9. April 2009 3:33 15

Minor Repairs
305
8. Inflate the tire if necessary.
Please see the chapter “TIRE PRESSURES,
COLD (68 °F/20 °C)” on Page 354.
On vehicles with Tire Pressure Monitoring:
Please see the chapter “SETTING THE TIRE
TYPE AND SIZE” on Page 134.
9. Lower the car and remove the jack.
10.Tighten wheel bolts in diagonally opposite
sequence.
Maintenance Note
fImmediately after changing a wheel, use
a torque wrench to check the prescribed
tightening torque of the wheel bolts
(160 Nm/118 ftlb.).
fSpacer, steel nuts, and plastic covers should
be stored together.
Fitting the 17 mm spacer1. Remove wheel.
2. Fit the spacer with the wheel bolts A used to
fasten the wheel.
Tightening torque: 160 Nm (118 ftlb.)
3. Fit wheel.
To d o t h i s use the original wheel nuts for
fastening the wheels.
Tightening torque: 160 Nm (118 ftlb.)
Place plastic covers onto the steel nuts.
Note
There is no anti-theft protection for the wheel nuts.Collapsible spare wheelThe collapsible spare wheel is fastened under the
floor in the luggage compartment.
On vehicles with 17 mm spacers:
fBefore fitting a collapsible spare wheel on the
rear axle always remove the corresponding
spacer.
For information on the spacers:
Please see the chapter “SPACERS” on
Page 293.
For information about removing the spacers:
Please see the chapter “CHANGING A WHEEL
WITH REMOVAL OF 17 MM SPACER” on
Page 303.1. Take out rotary knob A and put it on bolt B.
2. Unscrew the screw and take out the collapsible
spare wheel.
3. Mount the collapsible spare wheel on the vehi-
cle before inflating it. Leave the car jacked up.
Please see the chapter “LIFTING THE VEHICLE
WITH A JACK” on Page 299.
4. Inflate the tire.
Please see the chapter “TIRE PRESSURES,
COLD (68 °F/20 °C)” on Page 354.
10_Cayenne_21_KW17.book Seite 305 Donnerstag, 9. April 2009 3:33 15

Minor Repairs
309
Spare wheel
Warning!
Risk of accident. The wheel and tire size and
the tire quality of the spare wheel and normal
wheel may differ.
If a spare wheel that differs from the normal
tires is used, this may impair the driving
behavior.
fThe spare wheel must be used only over short
distances in cases of emergency.
For safety reasons, replace the tires before
the wear indicators appear (webs in the tire
grooves, 1/16 in. (1.6 mm) high).
fNever deactivate the Porsche Stability
Management (PSM) system.
fIf the tire on the spare wheel is older than
4 years, the spare wheel should be used only
in the event of a flat.
fAvoid hard acceleration and high cornering
speeds.
The maximum permitted speed is 50 mph
(80 km/h) if the mounted spare wheel differs
from the other three wheels on the car. This
maximum speed must not be exceeded
because of altered driving characteristics and
for reasons of wear.
fDo not use a spare wheel from a different
vehicle type.
fDo not mount the spare wheel from your car on a different vehicle.Removing spare wheel from bracket
Warning!
Danger of injury if the spare wheel is
removed improperly.
fRemove the spare wheel only when the spare
wheel bracket is locked.
fRemove the spare wheel from the spare wheel
bracket with care. The wheel is very heavy [approx. 77 lbs. (35 kg)].
1. Unscrew all five wheel bolts.
2. Remove the top wheel bolt.
Remove assembly aid from the tool kit and
screw in instead of the wheel bolt.
Remove the remaining wheel bolts.
Fitting spare wheel on bracket
fInsert wheel bolts and tighten by hand.
Remove assembly aid and screw in remaining
wheel bolt.
Initially tighten bolts in diagonally opposite
sequence so that the wheel is centerd.
fPlease see the chapter “TIRE PRESSURES,
COLD (68 °F/20 °C)” on Page 354.
fAfter mounting the wheel, tighten all five wheel
bolts to 111 ftlb. (150 Nm).
10_Cayenne_21_KW17.book Seite 309 Donnerstag, 9. April 2009 3:33 15

364
Index
Belt tensioner
Functional description
....................................... 42
Belts
...................................................................... 42Adjusting belt height
......................................... 44
Belt tensioner functional description
.................... 42
Care instructions
........................................... 278
Fastening
....................................................... 43
Opening
......................................................... 44
Warning light
................................................... 53
Warning light on the tachometer
......................... 43
Bi-xenon
................................................................ 330Changing bulb for additional high beam
............. 331
Changing bulb for cornering light
...................... 332
Changing gas-discharge headlight
.................... 330
Installing headlights
........................................ 328
Removing headlights
...................................... 327
Brake booster
........................................................ 165
Brake booster faulty warning message
....................... 154
Brake fluid
Change quantity
............................................ 359
Changing
..................................................... 258
Checking level
............................................... 257
Warning light on speedometer
......................... 258
Warning message on multi-purpose display
........ 153
Brake light
Changing bulb
............................................... 338
Installing tail light
........................................... 337
Removing tail light
......................................... 336
Brake pads
Breaking in new brake pads
................................. 6
Warning message on the multi-purpose display
... 153
Warning message, brakes
............................... 165
Brake pedal
........................................................... 164
Brake wear
Warning light
................................................. 165
Brake wear warning message
................................... 165
Brakes
.................................................................. 163Applying/releasing parking brake
..................... 162
Brake pad warning message
........................... 165
Brake pedal
.................................................. 164
Break in new brake pads
..................................... 6
Discs
........................................................... 165
Pads
.................................................. 165
, 166
Parking brake test
......................................... 189
Test stand
.................................................... 189
Warning light
........................................ 163
, 164
Warning message on the multi-purpose display
... 153
Break in hints
............................................................. 6
Breaking in
Engine
............................................................. 6
Engine oil and fuel consumption
during break-in period
......................................... 6
Hints
............................................................... 6
New brake pads and brake discs
.......................... 6
New tires
......................................................... 6
Brief overview
2-zone air-conditioning
...................................... 69
4-zone air-conditioning (front control panel)
.......... 73
4-zone air-conditioning (rear control panel)
........... 74
Manual air-conditioning
..................................... 66
Opening and locking from outside
....................... 18
Panorama roof system
..................................... 96
Sliding/lifting roof
............................................ 91
Windshield wipers
.......................................... 110
Bulbs
Changing bulb for additional high beam
(Bi-Xenon headlights)
...................................... 331
Changing bulb for additional high beam
(halogen headlights)
....................................... 330
Changing bulb for front turn signal (Cayenne GTS)
335
Changing bulb for front turn signal
(Cayenne, Cayenne S, Cayenne S Transsyberia)
.. 333
Changing bulb for high beam
........................... 331
Changing bulb for high beam (halogen headlights)
330
Changing bulb for license plate light
.................. 338
Changing bulb for low beam
................... 329
, 330
Changing bulb for low beam (halogen headlights)
329
Changing bulb for side light (Cayenne GTS)
........ 335
Changing bulb for side light
(Cayenne, Cayenne S, Cayenne S Transsyberia)
.. 333
Changing bulb for side light, halogen
(Cayenne, Cayenne S, Cayenne S Transsyberia)
.. 333
Changing gas-discharge headlight
(Bi-Xenon headlights)
...................................... 330
Chart
........................................................... 342
Overview
...................................................... 342
Replacing brake light
...................................... 338
Replacing rear fog light
................................... 338
Replacing rear turn signal light
......................... 338
Replacing reversing light
................................. 338
Replacing tail light
.......................................... 338
Button overview
2-zone air conditioning
...................................... 70
4-zone air conditioning, front
.............................. 75
4-zone air conditioning, rear
.............................. 76
Manual air-conditioning
...................................... 67
Parking heater
................................................. 81
CCapacities
Brake fluid
.................................................... 359
Coolant
........................................................ 359
Engine oil
..................................................... 359
Fuel
............................................................. 359
Overview
...................................................... 359
Washer fluid
.................................................. 359
Car care
............................................................... 270Airbags
........................................................ 277
Alcantara
...................................................... 277
Cleaning the engine compartment
..................... 273
Decorative foils
............................................. 271
Fabric linings
................................................. 277
Floor mats
.................................................... 277
Headlights, plastic parts, adhesive films
............. 275
Leather
........................................................ 277
Light alloy wheels
.......................................... 276
Paint
............................................................ 273
Safety belts
.................................................. 278
Seals
........................................................... 276
Seat belts
..................................................... 278
Storing your Porsche
...................................... 278
Undercoating
................................................ 274
Use of high-pressure cleaning equipment
........... 271
Washing the vehicle, instructions
...................... 271
Wheel bolts
................................................... 293
Windows
...................................................... 274
Car key (remote control)
Changing battery
........................................... 322
Emergency operation of key in ignition lock
........ 159
Locking the vehicle door
................................... 21
Opening/closing Panorama roof system
.............. 99
Opening/closing sliding/lifting roof
...................... 93
Opening/closing windows
(without Porsche Entry & Drive)
.......................... 89
Unlocking the vehicle door
................................. 20
Car Telephone
........................................................ 219
10_Cayenne_21_KW17.book Seite 364 Donnerstag, 9. April 2009 3:33 15

Index
365
Care instructions
Airbags
........................................................ 277
Alcantara
...................................................... 277
Carpet
......................................................... 277
Cleaning the engine compartment
..................... 273
Fabric linings
................................................. 277
Floor mats
.................................................... 277
Headlights, plastic parts, adhesive films
............. 275
Leather
........................................................ 277
Light alloy wheels
........................................... 276
Paint
............................................................ 273
Safety belts
.................................................. 278
Seals
........................................................... 276
Seat belts
..................................................... 278
Storing your Porsche
...................................... 278
Undercoating
................................................ 274
Use of high-pressure cleaning equipment
............ 271
Washing
....................................................... 271
Wheel bolts
................................................... 293
Windows
....................................................... 274
Cargo
................................................................... 208
Cargo management system
...................................... 208
Inserting and adjusting the strap reel
................. 208
Inserting and adjusting the telescopic bar
........... 208
Inserting and adjusting tie-down rings
................ 210
Overview
...................................................... 208
Carpet, care instructions
.......................................... 277
Catalytic converter
.................................................. 264
Emission control (Check Engine)
....................... 123
Center armrest
Opening front storage compartment
.................. 224
Opening rear storage compartment
................... 224
Center differential lock
............................................. 178
Engaging
...................................................... 178
Central locking system
Changing settings via multi-purpose display
........ 143
Closing the rear window
.................................... 27
Functional description
....................................... 17
Locking the rear lid
.......................................... 23
Locking vehicle door with Porsche Entry & Drive
.... 21
Locking vehicle door with the car key
(remote control)
............................................... 21
Opening and locking vehicle door from inside
........ 28
Unlocking and opening rear lid
............................ 22
Unlocking and opening the rear window
............... 27
Unlocking vehicle door with Porsche Entry & Drive
.20
Unlocking vehicle door with the car key
(remote control)
............................................... 20
When disconnecting battery
............................. 321
Changing bulb for license plate light
........................... 338
Changing wheels
..................................................... 294
Check engine (emission control)
Functional description
..................................... 123
Warning light on the tachometer
....................... 123
Checking hydraulic fluid (power steering)
..................... 259
Child restraint anchorages
.......................................... 54
Child restraint system
Installing with LATCH system
.............................. 53
LATCH restraint system
..................................... 53
Child seat
Installing with LATCH system
.............................. 53
LATCH restraint system
..................................... 53
Prescribed installation direction
.......................... 50
Child seat bracket
..................................................... 53
Cigarette lighter
...................................................... 228
Front
............................................................ 228
Rear
............................................................ 228
Cleaning the engine compartment
.............................. 273
Clock
Button for setting
........................................... 123
Setting on the multi-purpose display
.................. 146
Closing
Automatically closing the rear lid
......................... 25
Closing sliding/lifting roof
.................................. 93
Locking vehicle door from inside
......................... 28
Panorama roof system
...................................... 98
Persons/animals remaining in the vehicle
............. 21
Powerliftgate
................................................... 23
Rear window
................................................... 27
Spare wheel bracket
....................................... 311
Vehicle door with Porsche Entry & Drive (keyless)
.. 21
Vehicle door with the car key (remote control)
....... 21
Closing the rear lid automatically
................................. 25
Clutch
................................................................... 169
Cockpit
Adjusting illumination
...................................... 105
Clock
........................................................... 123
Cooling system temperature gage
.................... 122
Fuel level gage
.............................................. 120
Odometer
..................................................... 121
Oil temperature gage
...................................... 120
Speedometer
................................................ 120
Tachometer
.................................................. 120
Voltage indication
........................................... 121
Voltmeter
...................................................... 121
Warning and indicator lights, overview
................ 117
Collapsible spare wheel
PSM (Porsche Stability Management)
.................186
Tire size
.................................... 350
, 351
, 352
Collapsible spare wheel in the luggage compartment
.....305
Comfort function
Panorama roof system
......................................99
Comfort lighting
Dimming
.......................................................109
Comfort tire pressure
Data (bar/psi)
................................................354
Coming Home function
Setting lighting off delay
..................................146
Switching on
..................................................109
Compass
Setting on the multi-purpose display
..................147
Compressor
...........................................................307
Connection (on vehicles without air suspension)
...307
Storage location
(on vehicles without air suspension)
...................292
Tire filling connection
(on vehicles with air suspension)
.......................308
Control panel
............................................................79
2-zone air conditioning
......................................70
4-zone air conditioning, front
..............................75
4-zone air conditioning, rear
...............................76
Disabling control panel
for air-conditioned areas at the rear
.....................79
Manual air-conditioning
......................................67
Parking heater
.................................................81
Control systems
Overview (PTM, PTM Plus, PSM, PASM, PDCC)
....181
Coolant
Antifreeze
.....................................................255
Change quantity
.............................................359
Checking level
...............................................255
Cooling system
Engine coolant level warning
............................122
Engine coolant temperature warning
..................122
Temperature gage
..........................................122
Warning on multi-purpose display
......................122
Cornering light
........................................................330
Changing bulb (Bi-Xenon headlights)
...................332
Installing headlights
........................................328
Removing headlights
.......................................327
Cornering light,static
................................................332
Crankcase ventilation
...............................................264
Crossing obstacles
..................................................201
10_Cayenne_21_KW17.book Seite 365 Donnerstag, 9. April 2009 3:33 15

Index
379
Size
............................................................. 350
Snow chains (general information)
..................... 289
Spare wheel (general information)
..................... 309
Storage
........................................................ 287
Tire pressure plate
......................................... 348
Tire pressure, data (bar/psi)
............................ 354
Tire sealant
................................................... 296
Tracks
......................................................... 350
Wheel balancing
................................... 189
, 287
Wheel bolt wrench
.......................................... 292
Wheel bolts (care instructions)
.......................... 293
Winter tires (general information)
...................... 288
Windows
Adjusting after connecting battery
....................... 90
Care instructions
............................................ 274
Closing with button in door handle
(with Porsche Entry & Drive)
............................... 90
Opening/closing with car key
(without Porsche Entry & Drive)
.......................... 89
Opening/closing with rocker switch
..................... 87
Windshield
Washer fluid
.................................................. 258
Windshield washer system
Adding washer fluid
........................................ 258
Antifreeze
..................................................... 258
Filling capacity
............................................... 359
Windshield wiper/washer stalk
Rain sensor adjustment
................................... 112
Rear window wiping plus washer system
............ 113
Switching on intermittent operation
of rear window wiper
...................................... 113
Switching on rain sensor
................................. 111
Windshield wiping plus washer system
............... 113
Windshield, fast wiping
.................................... 112
Windshield, slow wiping
................................... 112
Wiping rear window once (one-touch function)
..... 113
Wiping windshield once (one-touch function)
........ 112
Windshield wipers
Brief overview
............................................... 110
Care instructions
............................................ 274
Changing rear wiper blade
............................... 262
Rain sensor adjustment
................................... 112
Rear window wiping plus washer system
............ 113
Replacing front wiper blades
............................ 261
Stalk
............................................................ 111
Switching on intermittent operation
of rear window wiper
...................................... 113
Switching on rain sensor
................................. 111
Windshield wiping plus washer system
............... 113
Windshield, fast wiping
.................................... 112
Windshield, slow wiping
................................... 112
Wiping rear window once (one-touch function)
...... 113
Wiping windshield once (one-touch function)
........ 112
Winter driving
......................................................... 321
Winter tires
............................................................ 350
General information
........................................ 288
Overview
...................................................... 350
Storage
........................................................ 287
Wheel change
................................................ 302
Wiper blades
Care instructions
............................................ 274
Changing (rear)
.............................................. 262
Replacing (front)
............................................. 261
With Porsche Entry & Drive
......................................... 19
Working on your vehicle
........................................... 250
Wrench socket (security wheel bolt)
............................ 294
XXenon
Changing bulb for additional high beam
(Bi-Xenon headlights)
....................................... 331
Changing bulb for cornering light
(Bi-Xenon headlights)
....................................... 332
Changing gas-discharge headlight
(Bi-Xenon headlights)
....................................... 330
Installing headlights
........................................ 328
Removing headlights
....................................... 327
10_Cayenne_21_KW17.book Seite 379 Donnerstag, 9. April 2009 3:33 15