2004 PONTIAC VIBE boot

Maintenance Schedule......................................6-2
Introduction...................................................6-2
Maintenance Requirements..............................6-2
Your Vehicle and the Environment....................6-2
How This Section is Organized.........................6-3
Part A: Scheduled Maintenance Services...........6-4
Using Your Maintenance Schedule....................6-4
Selecting the Right Schedule...........................6-5
Short Trip/City Scheduled Maintenance..............6-7
Long Trip/Highway Scheduled Maintenance......6-14
Part B: Owner Checks and Services................6-19
At Each Fuel Fill..........................................6-19
At Least Once a Month.................................6-19At Least Twice a Year...................................6-20
At Least Once a Year...................................6-21
Part C: Periodic MaintenanceInspections.........6-24
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection............................6-24
Exhaust System Inspection............................6-24
Fuel System Inspection..................................6-24
Engine Cooling System Inspection...................6-25
Throttle System Inspection.............................6-25
Brake System Inspection................................6-25
Part D: Recommended Fluids and Lubricants. . . .6-26
Part E: Maintenance Record...........................6-28
Section 6 Maintenance Schedule
6-1

Part C: Periodic
MaintenanceInspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer's
service department do these jobs. Make sure any
necessary repairs are completed at once.
Proper procedures to perform these services may be
found in a service manual. SeeService Publications
Ordering Information on page 7-11.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, cha®ng, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the ¯oor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page 2-33.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
6-24

Ignition Transaxle Lock Check..........................6-22
Infants and Young Children, Restraints...............1-29
In¯ation Ð Tire Pressure.................................5-67
Inspection......................................................6-25
Brake System.............................................6-25
Engine Cooling System................................6-25
Exhaust System..........................................6-24
Fuel System...............................................6-24
Part C - Periodic Maintenance.......................6-24
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-24
Throttle System...........................................6-25
Instrument Panel.............................................3-26
Cluster.......................................................3-26
Overview..................................................... 3-2
Storage Area..............................................2-37
Instrument Panel Brightness.............................3-14
Instrument Panel Fuse Block............................5-99
Interior Lamps................................................3-14
J
Jump Starting.................................................5-45
K
Key Lock Cylinders Service..............................6-21
Keyless Entry System....................................... 2-4Keys............................................................... 2-2
L
Lamps...........................................................3-12
Exterior......................................................3-12
Interior.......................................................3-14
Lap-Shoulder Belt...................................1-14, 1-23
LATCH System...............................................1-39
Child Restraints...........................................1-39
Securing a Child Restraint Designed for the
LATCH System........................................1-41
Leaving Your Vehicle......................................... 2-9
Leaving Your Vehicle With the Engine
Running.....................................................2-29
Liftgate/Liftglass................................................ 2-9
Liftgate/Liftglass Release..................................2-10
Liftglass/Liftgate................................................ 2-9
Light.............................................................3-30
Air Bag Readiness.......................................3-30
Anti-Lock Brake System Warning...................3-32
Brake System Warning.................................3-31
Charging System.........................................3-31
Cruise Control.............................................3-39
Door Ajar...................................................3-39
Low Washer Fluid Warning...........................3-39
Malfunction Indicator....................................3-34
Oil Pressure...............................................3-38
Overdrive Off..............................................3-39
7

Light (cont.)
Safety Belt Reminder...................................3-28
Loading Your Vehicle.......................................4-32
Locks............................................................. 2-7
Door........................................................... 2-7
Leaving Your Vehicle..................................... 2-9
Power Door.................................................. 2-8
Rear Door Security Locks............................... 2-8
Long Trip/Highway De®nition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-14
Loss of Control...............................................4-14
Low Washer Fluid Warning Light.......................3-39
Luggage Carrier..............................................2-38
M
Maintenance, Normal Replacement Parts..........5-103
Maintenance Schedule.....................................6-19
At Each Fuel Fill.........................................6-19
At Least Once a Month................................6-19
At Least Once a Year..................................6-21
At Least Twice a Year..................................6-20
Brake System Inspection..............................6-25
Engine Cooling System Inspection.................6-25
Exhaust System Inspection...........................6-24
Fuel System Inspection................................6-24
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-14Maintenance Schedule (cont.)
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-19
Part C - Periodic MaintenanceInspections......6-24
Part D - Recommended Fluids and
Lubricants...............................................6-26
Part E - Maintenance Record........................6-28
Selecting the Right Schedule.......................... 6-5
Short Trip/City Scheduled Maintenance............. 6-7
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-24
Throttle System Inspection............................6-25
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-40
Making Turns.................................................4-38
Malfunction Indicator Light................................3-34
Manual Seats................................................... 1-2
Manual Transaxle............................................2-18
Fluid..........................................................5-25
Operation...................................................2-23
Manual Windows............................................2-11
Matching Transmitter(s) to Your Vehicle............... 2-6
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) ± Customer Assistance....... 7-5
Mirrors..........................................................2-35
Manual Rearview Mirror................................2-35
Outside Convex Mirror.................................2-36
8

Shifting Out of Park (P)...................................2-30
Short Trip/City De®nition.................................... 6-5
Short Trip/City Intervals..................................... 6-5
Short Trip/City Scheduled Maintenance................ 6-7
Shoulder Belt Height Adjuster...........................1-16
Six-Speed......................................................2-24
Skidding........................................................4-14
Some Other Rainy Weather Tips.......................4-18
Special Fabric Cleaning Problems.....................5-90
Speci®cations, Capacities...............................5-101
Speedometer..................................................3-27
Starter Switch Check.......................................6-21
Starting Your Engine.......................................2-18
Steering.......................................................... 4-9
Steering in Emergencies..................................4-11
Steering, Suspension and Front Drive Axle Boot
and Seal Inspection.....................................6-24
Steering Tips..................................................4-10
Storage Areas................................................2-37
Center Console Storage Area........................2-37
Coinholder(s)..............................................2-37
Cupholder(s)...............................................2-37
Glove Box..................................................2-37
Instrument Panel Storage Area......................2-37
Luggage Carrier..........................................2-38
Rear Cargo Accessory Track System..............2-40
Rear Storage Area.......................................2-40
Storing the Flat Tire and Tools..........................5-85
Storing the Spare Tire and Tools.......................5-87
Stuck in Sand, Mud, Ice or Snow......................4-28Sun Visors.....................................................2-13
Sunroof.........................................................2-42
Supplemental Restraint System (SRS)...............1-47
How Does an Air Bag Restrain?....................1-53
Servicing Your Air Bag-Equipped Vehicle.........1-56
What Makes an Air Bag In¯ate?....................1-53
What Will You See After an Air
Bag In¯ates?...........................................1-54
When Should an Air Bag In¯ate?...................1-52
Where Are the Air Bags?..............................1-50
T
Tachometer....................................................3-28
Temperature Display........................................3-28
Testing the Alarm............................................2-14
Theft-Deterrent Systems...................................2-13
Content Theft-Deterrent................................2-13
Throttle System Inspection...............................6-25
Tilt Wheel........................................................ 3-5
Tire In¯ation Check.........................................6-19
Tire Sidewall Labeling......................................5-62
Tire Size.......................................................5-64
Tire Terminology and De®nitions........................5-65
Tires.....................................................5-61, 5-94
Buying New Tires........................................5-71
Chains.......................................................5-75
Changing a Flat Tire....................................5-77
Compact Spare Tire.....................................5-88
12