2004 Peugeot Partner VU Dag ABS

PEUGEOT SERVICING25
22-12-2003
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st service
A C Intermediate
DRAIN/REFILLÐ Engine oilÐ Bleed fuel filter (diesel)Ð Oil filterÐ Petrol filter (according to engine)REPLACEÐ Diesel filter or element (according to engine)Ð Air filter elementÐ Spark plugs (petrol)Ð Engine oil (check + top-up) Ð Manual gearbox oil (check + top-up) Ð Battery (check + top-up) if cap is removableLEVELÐ Screen wash (check + top-up)Ð Coolant (check + top-up)Ð Brake fluid (check + top-up)Ð Power steering fluid (check + top up according to specification)Ð Operation of lights and indicatorsÐ Condition of glass, headlamp and light lenses and mirrorsÐ HornÐ Windscreen washer jetsÐ Condition of wiper bladesÐ Condition and tension of the ancillary drive beltsÐ HandbrakeÐ Condition of hydraulic circuits (hoses and covers)CHECKÐ Condition of rubber boots and gaitersÐ Brake pads Ð Play in hubs, link rods, ball joints, flexible mountingsÐ Shock absorbersÐ Rear drum brake lining wearÐ Condition and pressure of tyres (including spare wheel)Ð Emission control check as per current legislation (petrol)Ð Smoke opacity (diesel)Ð Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions. : Arduous conditions. * According to destination.

27
PEUGEOT SERVICING
22-12-2003
Recommendations for recommended lubricants The oils which appear in the table opposite are suitable for mostpurposes. The diagram opposite states the optimum range of viscosity depen-ding on the temperatures at whichthe oils are to be used. It is also possible to use "superior quality" synthetic oils. In the absence of semi-synthetic or
synthetic oils, oils of ACEA A1/A2
and API SH/SJ/SL quality (for petrol
engines), or ACEA B1/B2 and APICD/CF quality (for diesel engines)may be used by following the"Arduous Conditions" servicingschedule which specifies shorterintervals. Do not hesitate to ask for advice
from a PEUGEOT dealer to maintaindriving pleasure and to minimise themaintenance cost of your vehicle. For countries outside Europe, please
contact a local PEUGEOT dealer.
ONLY ONLY
Manual Gearbox ESSO GEAR OIL BVTOTAL TRANSMISSION BV75W80 PR 9736.41 75W80 PR 9730.A2
Power steering ESSO ATF D TOTAL Fluide AT42 PR 9730.94 PR 9730.A3
Other recommended products
Brake fluid PEUGEOT DOT4 Coolant
PROCOR TM 108/GLYSANTIN G33 or REVKOGEL 2000
ONLY protection to Ð35 ¼C

INSTRUMENTS AND CONTROLS
28
22-12-2003
1.
Seat belt not fastened warning light*
2. Passenger air bag disarmingwarning light*
3. Front and side air bags warninglight
4. Front fog lamps indicator light
5. Anti-lock braking system (ABS)warning light
6. Rear fog lamp indicator light
7. Diesel pre-heat warning light
8. Left hand direction indicator
9. Total distance recorder, serviceindicator and engine oil levelindicator 10.
Right hand direction indicator
11 . Engine diagnostics warning light
12. Main beam headlamps indicator light
13. Handbrake, low brake fluid leveland electronic brake forcedistribution warning light
14. Dipped beam headlampsindicator light
15. Battery charge warning light
16. Engine oil pressure andtemperature warning light
17. Water in diesel filter warning light
18. Low coolant level warning light 19.
Coolant temperature indicator
20. Total distance recorder button
21. Central (STOP) warning light
22. Speedometer
23. Rev counter
24. Lighting rheostat button
25. Fuel level indicator
26. Low fuel level warning light
* According to destination.
INSTRUMENT PANEL: PETROL-DIESEL MANUAL GEARBOX

INSTRUMENTS AND CONTROLS29
22-12-2003
Handbrake, low brake
fluid level and Electronic BrakeForce Distribution
system faultwarning light
Linked to the central (STOP) warninglight. This indicates one of the following:
Ð that the handbrake is applied or not fully released,
Ð an excessive drop in brake fluid level (if the warning light remains on even when the handbrake isreleased),
Ð a fault in the Electronic Brake Force Distribution system, if lit at
the same time as the ABS warninglight.
You must stop.
Consult a PEUGEOT dealer.
INSTRUMENTS AND CONTROLS
A permanently lit warning light or one flashing
,with the engine
running, indicates an operatingfault of the unit concerned. Theillumination of certain warninglights may be accompanied byan audible signal and a message
on the multifunction display. Donot ignore this warning: consulta PEUGEOT dealer as soon aspossible.
If the central STOP warning light comes on when you are driving,
stop your vehicle immediately,where it is safe to do so.
Anti-lock braking system (ABS)warning light
This comes on for 3 seconds each time the ignition is switched on. If the warning light remains on or comes on above 8 mph (12 km/h),
this indicates an ABS malfunction.
However, the vehicle retains conven- tional servo-assisted braking. Lighting of this warning light, accompanied by an audible signal,
indicates an ABS fault.
Consult a PEUGEOT dealer.
Diesel engine low coolant levelwarning light
Linked to the central (STOP) warn-ing light.
You must stop.
Wait for the engine to cool before topping up the level. The cooling circuit is pressurised.In the event of breakdown and to prevent any risk of burns , unscrew
the cap by two turns to allow thepressure to drop. When the pressure has dropped, remove the cap and top up the level.
Consult a PEUGEOT dealer.
Central (STOP) warning light
Linked to the warning lights:
Ð "engine oil pressure and tempera- ture",
Ð "low coolant level",
Ð "handbrake",
Ð "low brake fluid level",
Ð "electronic brake force distribution system fault".
Linked with the "coolant tempera-
ture" indicator.
You must stop if the light flashes with the engine running.
Consult a PEUGEOT dealer. Engine oil pressure and temperaturewarning light
Linked to the central (STOP) warn-ing light.
You must stop. This warning light indicates one of the following:
Ð insufficient oil pressure,
Ð a lack of oil in the lubrication cir- cuit. Top up the level.
Ð an oil temperature which is too high. The warning light is acom-
panied by an audible signal. Tolower the oil temperature, reduceyour speed.
Consult a PEUGEOT dealer.

YOUR PARTNER IN DETAIL
52
22-12-2003
To remove the head restraint, place it in the top position, pressthe tabs and pull it upwards.
To put it back in position, locate the stems of the restraint in theholes, taking care to keep themin line with the seat back.
2- Seat back angle adjustment Turn the knob.
3- Forwards-backwards adjustment (driver) Lift the control and slide the seat forwards or backwards.
SEATS
1- Head restraint height
adjustment
To raise or lower the restraint, slide it.
The adjustment is correct when the upper edge of thehead restraint is level withthe top of the head.

YOUR PARTNER IN DETAIL
56
22-12-2003
GENERAL POINTS RELATING TO CHILD SEATS Although one of PEUGEOT's main criteria when designing your vehicle, the safety of your children also depends on you.
For maximum safety, please follow these precautions:
Ð Since 1992,
all children under the age of 10 must travel in approved child
seats* suited to their weight , on seats fitted with a seat belt.
Ð A child weighing less than 9 kg must travel in the rearwards facing position both in the front and in the rear. PEUGEOT recommends that children should travel in the "rearwards facing" position up to the age of two.
Ð Statistically, the safest seats in your vehicle for the transportation of chil- dren are the rear seats. PEUGEOT recommends that children travel in the rear even when a "rearwards facing" child seat is used.
Ð If a child is travelling on a booster seat, check that the lap section of the seat belt passes over the child's thighs correctly. The chest section of the seat beltmust be positioned on the child's shoulder without touching the neck. PEUGEOTrecommends that you use a booster seat with a back, fitted with a seat beltguide at shoulder level.
Ð Remember to fasten the seat belt or the child seat harness keeping the slack
in relation to the child's body to a minimum , even for short journeys.
* According to current legislation in the country.
** Consult the relevant administration in your country for information regarding the rules for transporting children on the front passenger seat.Rules for transporting children on the front passenger seat** Children under the age of 10 must not travel in the forwards facing position, unless the rear seats arealready occupied by other childrenor the rear seats cannot be used(absent or folded). In this case,adjust the front passenger seat tothe intermediate position and leavethe passenger air bag armed. The transportation of children in the rearwards facing position is permit-
ted. In this position, it is essential to
disarm the passenger air bag.Otherwise, the child would risk beingkilled or seriously injured if the airbag were to inflate.

HANDBRAKE Applying When parking, pull the handbrake to immobilise your vehicle. Releasing Pull the handle and press the button to release the handbrake.Illumination of this warninglight and of the STOPwarn-
ing light, accompanied byan audible signal (while the
vehicle is moving), indicates that thehandbrake is still applied or has not
been released fully. ANTI-LOCK BRAKING SYSTEM (ABS)
The ABS with Electronic Brake Force Distribution (EBFD) increasesthe stability and manoeuvrability ofyour vehicle, particularly on poor orslippery road surfaces. Note: when changing wheels (tyres
and rims), make sure that these are approved. The anti-lock braking system comes into operation automatically whenthere is a risk of wheel lock. Illumination of this warning light, accompanied by an audible signal,indicates a malfunction of the elec-tronic brake force distribution, whichcan cause a loss of control of thevehicle when braking.
Stop immediately.
Contact a PEUGEOT dealer.
YOUR PARTNER IN DETAIL
80
22-12-2003
Normal operation of the ABS may make itself felt by slight vibrationsof the brake pedal. In emergency braking, press very firmly without releasingthe pressure.

Rear lights
1 - Fog lamp (P 21 W).
2 - Direction indicators (P 21 W).
3 - Reversing lights (P 21 W).
4 - Brake lights/Side lights (P 21/5 W).Ð Open the rear door.
Ð Unscrew the nut
A.
Ð Push the light unit gently towards the interior of the vehicle to unclip the two side retaining clips.
Ð Remove the light unit and disconnect it.
Ð Unclip the bulb holder by pressing the tabs B.
Ð Change the faulty bulb.
PRACTICAL INFORMATION
94
22-12-2003
Number plate lights (W 5 W) Unclip the translucent protector to gain access to the bulb.