2004 MERCEDES-BENZ C320S air conditioning

339 Technical data
Layout of poly-V-belt drive
Layout of poly-V-belt drive
C230KompressorSport
1Power steering pump
2Idler pulley
3Supercharger
4Automatic belt tensioner
5Air conditioning compressor
6Crankshaft
7Coolant pump
8Generator (alternator)
C 240/C 320 (all models)
1Automatic belt tensioner
2Power steering pump
3Air conditioning compressor
4Crankshaft
5Coolant pump
6Generator (alternator)
7Idler pulley
C32AMG
1Idler pulley
2Idler pulley
3Supercharger
4Automatic belt tensioner
5Power steering pump
6Air conditioning compressor
7Crankshaft
8Coolant pump
9Generator (alternator)

351 Technical data
Fuels, coolants, lubricants, etc.
Model
Capacity
Fuels, coolants, lubricants, etc.
Air conditioning system
R-134a refrigerant and special PAG lubricant oil
(never R-12)
Windshield washer
3.2 US qt (3.0 l)
MB Windshield Washer Concentrate
1
Windshield washer and
headlamp cleaning system*
6.4 US qt (6.0 l)
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing point or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 358).

352 Technical dataFuels, coolants, lubricants, etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, only
use engine oils approved by
Mercedes-Benz. Information on approved
engine oils is available in the Factory
Approved Service Products pamphlet, or at
your authorized Mercedes-Benz Center.Please follow FSS recommendations for
scheduled oil changes. Failure to do so
could result in engine damage not covered
by the Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air
conditioning system.Never use R-12 (CFC) or mineral-based
lubricating oil. Otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of
bubbles in the system, thus reducing the
system’s efficiency.
Therefore, the brake fluid must be
replaced every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your
authorized Mercedes-Benz Center will
provide you with additional information.
!Always check the oil filler cap
(page 255) for important information
pertaining to the engine oil needing to
meet a specific Mercedes-Benz specifi-
cation (e.g. MB 229.5). If such informa-
tion is printed on the oil filler cap, only
use an engine oil from the list of ap-
proved engine oils in the Factory Ap-
proved Service Products pamphlet that
meets the specification indicated on
the oil filler cap.
Using engine oils of other specification
may cause the FSS to incorrectly deter-
mine the next service interval and will
result in engine damage not covered by
the Mercedes-Benz Limited Warranty.

367 Index
A
ABS 23, 72, 361
ABS control 72
Malfunction indicator lamp 274
Messages in display 284
Accelerator position,
automatic transmission* 147
Accident
In case of 49
Activating
Air conditioning (cooling)
Automatic climate control* 170
Climate control 160
Air recirculation mode
Automatic climate control* 167
Climate control 158
Anti-theft alarm system* 78
Automatic climate control* 163
Central locking (control system) 133
Charcoal filter 169
Climate control 155Climate control system 159
Defrosting
Automatic climate control* 167
Climate control 158
Easy-entry/exit feature* 134
ESP 76
Exterior headlamps 46
Exterior lamps 103
Exterior rear view mirror
parking position* 150
Hazard warning flasher 106
Headlamps 46
High beams 106
Ignition 31
Immobilizer 52
Rapid seat heating* 98
Rear fog lamp 104, 105
Rear window defroster 153
Residual heat 171
Seat heating* 98
Tow-away alarm* 80
Windshield wipers 48Adding
Coolant 257
Engine oil 255
Additional turn signals 310
Adjustable air vents,
rear passenger compartment
Automatic climate control* 172
Climate control 161
Adjusting 32
Air distribution
Automatic climate control* 166
Climate control 157
Air volume
Automatic climate control* 166
Climate control 157
Backrest contour 97
Backrest side bolsters 97
Backrest tilt
Manual seat 33
Power seat* 35
Exterior rear view mirrors 38

368 Index
Head restraint height, front seats
Manual seat 34
Power seat* 35
Head restraint height, rear seats 94
Head restraint tilt, front seats
Manual seat 34
Power seat* 36
Head restraint tilt, rear seats 96
Head restraints, rear seats
Folding back 95
Folding back with release
switch 95
Placing upright 95
Instrument cluster illumination 109
Interior rear view mirror 38
Manual seat 33
Mirrors 38
Multicontour seat* 97
Power seat* 35
Rear seat head restraints 94Seat belt height 42
Seat cushion depth 97
Seat cushion tilt
Manual seat 33
Power seat* 35
Seat fore and aft adjustment
Manual seat 33
Power seat* 35
Seat height
Manual seat 33
Power seat* 35
Seats 32
Steering column height,
electrical* 38
Steering column height,
manual 37
Steering column length,
electrical* 38
Steering column length,
manual 37
Steering wheel 36Air conditioning (cooling)
Turning off
Automatic climate control* 170
Climate control 160
Turning on
Automatic climate control* 170
Climate control 160
Air conditioning refrigerant 352
Air distribution
Adjusting
Automatic climate control* 166
Climate control 157
Air pressure see Tire inflation pressure
Air recirculation mode
Activating
Automatic climate control* 167
Climate control 158
Deactivating
Automatic climate control* 168
Climate control 159

374 IndexCoolant 257, 356
Adding 257
Anticorrosion/antifreeze
quantity 356
Capacities 350
Checking level 257
Messages in display 287–289
Temperature 248
Temperature display 110
Coolant level
Checking 257
Cruise control 206, 362
Canceling 207
Driving downhill 207
Driving uphill 207
Fine adjustment 208
Message in display 290
Setting current speed 207
Setting speeds 208
Cruise control lever 206
Cruising range, fuel 355Cup holder
Cleaning 271
In front of seat armrest 217
In rear seat armrest 218
Customer Assistance Center see CAC
D
Daytime running lamp mode 104
Setting 129
Deactivating
Air conditioning (cooling)
Automatic climate control* 170
Climate control 160
Air recirculation mode
Automatic climate control* 168
Climate control 159
Alarm 79
Anti-theft alarm system* 79
Automatic climate control* 163
Central locking (control system) 133
Climate control 155
Climate control system 159Cruise control 207
Defrosting
Automatic climate control* 167
Climate control 158
Engine with the SmartKey 52
ESP 75
Exterior lamps 103
Exterior lamps delayed shut-off 131
Front fog lamps 131
Hazard warning flasher 106
Headlamps 51
Interior lighting delayed shut-off 132
Rapid seat heating* 98
Rear window defroster 153
Seat heating* 98
Tow-away alarm* 80
Deep water see Standing water
Defogging
Windshield
Automatic climate control* 166
Climate control 157

387 Index
R
Radio
Selecting stations 119
Station search 119
Station selection setting 132
Radio operation 179
Radio see Radio operation
Radio transmitters,
control and operation 246
Range (distance to empty)
Calling up 138
Rapid seat heating*
Switching off 98
Switching on 98
Reading lamp 27
Rear bench seat
Foldable* 212
Rear door window
Blocking operation 70
Rear fog lamp 311
Bulb 311
Switching on 105Rear lamp bulbs
Replacing 315
Rear lamps
Messages in display 293–296
Rear lamps see Tail lamps
Rear outer seats
Adjusting head restraint height 94
Rear passenger compartment,
adjustable air vents
Automatic climate control* 172
Climate control 161
Rear seat head restraints 94
Adjusting 94
Adjusting tilt 96
Folding back 95
Folding back with
switch in center console 95
Installing 97
Outer seats 96
Placing upright 95
Removing 96
Rear view mirrors see MirrorsRear window defroster 153
Rear window sunshade* 152
Reconnecting
Vehicle battery 325
Refrigerant
Air conditioning 352
Refueling 249
Regular checks 251
Reinstalling vehicle battery 324
Remote control
SmartKey 82
Remote door unlock
With Tele Aid* 230
Remote Vehicle Diagnostics 364
Removing
Minispare wheel 302
Ski sack* 212
Vehicle battery 324
Vehicle tool kit 300
Wheel 319
Wiper blades 316

393 Index
Technical data
Air conditioning refrigerant 352
Brake fluid 352
Coolant 350
Coolants 356
Electrical system 346
Engine oil additives 352
Engine oils 352
Flexible fuel vehicles 354
Fuel requirements 353
Fuels 350
Gasoline additives 354
Lubricants 349
Main dimensions 347
Premium unleaded gasoline 353
Rims and tires 342
Weights 348
Windshield washer 351
Windshield washer and headlamp
cleaning* system 351, 358Tele Aid* 223
Emergency calls 224
Information 227
Initiating an emergency call
manually 226
Message in display 299
Remote door unlock 230
Roadside assistance 226
SOS button 226
Stolen vehicle tracking services 230
System self-check 224
Tele Aid System 223, 365
Upgrade signals 229
Telematics* 365
Telephone* 24, 222
Answering a call 139
Dialing a number from
the phone book 140
Emergency call 198
Ending a call 139
Hands-free microphone 27Loading phone book 140
Message in display 299
Operation 138, 193
Redialing 140
Signal strength 139
Temperature
Display mode 127
Grades of tires 360
Setting interior temperature
Automatic climate control* 165
Climate control 156
Setting units in display 127
Tires 262
Tightening torque
(Wheel bolts) 321, 365
Tilt
Head restraint
Manual seat 34
Power seat* 36
Time
Setting hours 126
Setting minutes 126