2004 MERCEDES-BENZ C230 KOMPRESSOR COUPE fuel cap

331 Technical data
Fuels, coolants, lubricants, etc.
Model
Capacity
Fuels, coolants, lubricants, etc.
Fuel tank
including a reserve of
16.4 US gal (62.0 l)
2.1 US gal (8.0 l)
Premium unleaded gasoline:
Posted Octane 91 (Avg. of 96 RON / 86 MON)
Flexible Fuel Vehicles (identified by a label reading Premium
gasoline or E85 only! on fuel filler flap):
Alternative fuel: Ethanol fuel (E85)
Air conditioning system
R-134a refrigerant and special PAG lubricant oil (never R-12)
Windshield washer and
headlamp cleaning sys-
tem:
Without headlamp clean-
ing system
With headlamp cleaning
system
3.2 US qt (3 l)
6.4 US qt (6 l)
MB Windshield Washer Concentrate
1
1Use MB Windshield Washer Concentrate “S” and water for temperatures above freezing point or MB Windshield Washer Concentrate “S” and commercially available
premixed windshield washer solvent/antifreeze for temperatures below freezing point. Follow suggested mixing ratios (page 338).

332 Technical dataFuels, coolants, lubricants, etc.Engine oils
Engine oils are specifically tested for their
suitability in our engines. Therefore, use
only engine oils approved by
Mercedes-Benz. Information on approved
products is available in the Factory Ap-
proved Service Products pamphlet, or at
your authorized Mercedes-Benz Center.Please follow FSS recommendations for
scheduled oil changes. Failure to do so
could result in engine damage not covered
by the Mercedes-Benz Limited Warranty.
Engine oil additives
Do not blend oil additives with engine oil.
They may damage the engine.
Damage or malfunctions resulting from
blending oil additives are not covered by
the Mercedes-Benz Limited Warranty.Air conditioning refrigerant
R-134a (HFC) refrigerant and special PAG
lubricating oil is used in the air condition-
ing system.Never use R-12 (CFC) or mineral-based lu-
bricating oil. Otherwise damage to the
system will occur.
Brake fluid
During vehicle operation, the boiling point
of the brake fluid is continuously reduced
through the absorption of moisture from
the atmosphere. Under extremely strenu-
ous operating conditions, this moisture
content can lead to the formation of bub-
bles in the system, thus reducing the sys-
tem’s efficiency.
Therefore, the brake fluid must be re-
placed every two years, preferably in the
spring.
Only brake fluid approved by
Mercedes-Benz is recommended. Your au-
thorized Mercedes-Benz Center will pro-
vide you with additional information.
!Always check the oil filler cap
(page 240) for important informa-
tion pertaining to the engine oil need-
ing to meet a specific Mercedes-Benz
specification (e.g. MB 229.5). If such
information is printed on the oil filler
cap, only use an engine oil from the list
of approved engine oils in the Factory
Approved Service Products pamphlet
that meets the specification indicated
on the oil filler cap.
!Using engine oils of other specification
may cause the FSS to incorrectly deter-
mine the next service interval and will
result in engine damage not covered by
the Mercedes-Benz Limited Warranty.

336 Technical dataFuels, coolants, lubricants, etc.Coolants
The engine coolant is a mixture of water
and anticorrosion/antifreeze, which pro-
vides:

Corrosion protection


Freeze protection


Boiling protection (by increasing the
boiling point)
The cooling system was filled at the factory
with a coolant providing freeze protection
to approximately -22°F (-30°C) and corro-
sion protection.
If the antifreeze mixture is effective to
-22°F (-30°C), the boiling point of the cool-
ant in the pressurized cooling system is
reached at approximately 266°F (130°C).The coolant solution must be used
year-round to provide the necessary corro-
sion protection and increase boil-over pro-
tection. Refer to Service Booklet for
replacement interval.
Coolant system design and coolant used
stipulate the replacement interval. The
replacement interval published in the Ser-
vice Booklet is only applicable if MB 325.0
anticorrosion/antifreeze solution or other
Mercedes-Benz approved products of
equal specification (see Factory Approved
Service Products pamphlet) are used to re-
new the coolant concentration or bring it
back up to the proper level.
To provide important corrosion protection,
the solution must be at least 45% anticor-
rosion/antifreeze (equivalent to freeze
protection to approx. - 22°F [-30°C]).If you use a solution that is more than 55%
anticorrosion/antifreeze (freeze protec-
tion to approx. - 49°F [-45°C]), the engine
temperature will increase due to the lower
heat transfer capability of the solution.
Therefore, do not use more than this
amount of anticorrosion/antifreeze.
If the coolant level is low, water and
MB 325.0 anticorrosion/antifreeze should
be used to bring it up to the proper level
(have cooling system checked for signs of
leakage). Please make sure the mixture is
in accordance with label instructions.
The water in the cooling system must meet
minimum requirements, which are usually
satisfied by normal drinking water. If you
are not sure about the water quality, con-
sult your authorized Mercedes-Benz
Center.

338 Technical dataFuels, coolants, lubricants, etc.Windshield washer system and headlamp cleaning system
Both the windshield and headlamp washer
systems are supplied from the windshield
washer fluid reservoir.
The washer fluid reservoir has a capacity of
approx.

6.4 US qt (6.0 l) in vehicles with head-
lamp cleaning system*


3.2 US qt (3.0 l) in vehicles without
headlamp cleaning system

Refill the reservoir with MB Windshield
Washer Concentrate and water (or con-
centrate and commercially available
premixed windshield washer sol-
vent/antifreeze, depending on ambient
temperatures).Windshield and headlamp washer fluid
mixing ratio
For temperatures above freezing point use
MB Windshield Washer Concentrate “S”
and water:


1 part “S” to 100 parts water
[40 ml “S” to 1 gallon (4 liters) water]
For temperatures below freezing point use
MB Windshield Washer Concentrate “S”
and commercially available premixed
windshield washer solvent/antifreeze:


1 part “S” to 100 parts solvent
[40 ml “S” to 1 gallon (4 liters) solvent].
Warning!
G
Washer solvent/antifreeze is highly flamma-
ble. Do not spill washer solvent/antifreeze
on hot engine parts, because it may ignite
and burn. You can be seriously burned.

350 Index
Warning lamp 259
Break-in period 222
Bulbs, replacing 293
Additional turn signals 293
Brake lamps 294
Fog lamps 293
Front lamps 293
High beam 293
High mounted brake lamp 294
License plate lamps 294, 299
Low beam 293
Parking lamps 293, 294, 296, 297
Rear fog lamp 294
Rear fog lamps 298
Side marker lamps 294, 298
Standing lamps 293, 294, 296, 297
Tail lamp assemblies 294, 298
Turn signal lamps 293, 294
Button
Audio system 162C
CAC (Customer Assistance Center) 341
Calling up
Range (distance to empty) 134
Service indicator 250
CAN system 341
Capacities
Fuels, coolants, lubricants, etc. 330
Cargo compartment
Lighting 104
Cassette operation
Playing cassettes 172
Cassette player
Operating 116
Catalytic converter 231
CD changer* 175
CD operation 175
CD player
Operating 116
Center console 25Lower part 26
PASS.AIRBAG OFF indicator
lamp 263
Upper part 25
Centigrade
Setting temperature units 123
Central locking
From inside 88
Switch 88
Switching on/off
(control system) 129
Unlocking from inside 88
Central locking switch 88
Changing
Batteries (SmartKey) 290
Key setting 129
Changing CDs 175
Charging
Vehicle battery 308
CHECK ENGINE
malfunction indicator lamp 260
Check gas cap
Message in display 277

352 Index
AUDIO menu 114
Convenience submenu 129
Display digital speedometer 114
Functions 110, 113
Instrument cluster submenu 122
Lighting submenu 125
Malfunction memory menu 117
Menus 112, 113, 343
Multifunction display 109
Multifunction steering wheel 110
NAV menu 117
Selecting radio system 115
Settings menu 118
Standard display menu 114
Submenus 111, 113
TEL* menu 134
Trip computer menu 132
Vehicle submenu 128
Convenience submenu 129
Activating easy-entry/exit
feature 130Setting key dependency 131
Setting parking position for
exterior rear view mirror 132
Coolant 241, 336
Adding 241
Anticorrosion/antifreeze
quantity 336
Capacities 330
Checking level 241
Messages in display 271, 272
Temperature 232
Temperature indicator 106
Warning lamp 272
Coolant level
Checking 235, 241
Cruise control 194, 342
Canceling 195
Driving downhill 195
Driving uphill 195
Fine adjustment 196
Message in display 274
Saving current speed 195Setting speeds 196
Cruise control lever 194
Cruising range, fuel 335
Cup holder
Cleaning 255
In front seat armrest 201
Customer Assistance Center (CAC) 341
D
Daytime running lamp mode 100
Setting 125, 126
Deactivating
Air conditioning (cooling) 156
Air recirculation mode 155
Alarm 79
Anti-theft alarm system 79
Central locking (control system) 129
Climate control 151
Cruise control 195
Defrost 154
ESP 76

356 IndexFront seat head restraints
Installing 90
Manual seat 90
Power seat* 91
Removing 90
Front seats
Heater 93
FSS (Flexible Service System) 249, 342
Fuel 234
Additives 334
Cruising range 335
E85 (Ethanol fuel) 335
Fuel reserve warning lamp 262
Gasoline additives 334
Premium
unleaded gasoline 234, 331, 333
Requirements 333
Reserve warning 23
Switching (Flexible fuel vehicle) 334
Technical data 330
Fuel additives 334Fuel consumption statistics
After start 133
Since last reset 133
Fuel filler flap 233
Locking 233
Opening 291
Unlocking 233
Fuel requirements 333
Fuel reserve tank
Message in display 277
Fuel tank
Capacity 331
Filler flap 233
Fuels, coolants, lubricants etc.
Capacities 330
Functions (control system) 110, 113
Resetting 120
Fuse box 317
Fuse chart 317
Fuse extractor 318
Fuses 317Auxiliary fuse box in trunk 318
Fuse box in engine compartment 317
Fuse box in passenger
compartment 317
Fuse chart 317
Fuse extractor 318
G
Garage door opener 27, 214
Gasoline see Fuel 234
Gasoline additives 334
Gear range 342
Automatic transmission 141
Limiting 141
Shifting into optimal 140
Gear range limit
Canceling 140
Gear selector lever 291
Cleaning 255
Position 142
Unlocking manually 291
Global
Locking 83
Unlocking 83

361 Index
Mechanical key 288, 289
Memory function 95, 343
Recalling positions from memory 96
Storing exterior rear view mirror
parking positions 97
Storing key dependent settings 96
Menus 110
AUDIO 114
Control system 343
In control system 112, 113
Malfunction memory 117
NAV 117
Settings menu 118
Standard display 114
Submenus 111
TEL* 134
Trip computer 132
Microphone
Hands-free microphone 27
Miles/kilometers in speedometer
Setting 124Mirrors
Adjusting 39
Automatic antiglare for
rear view mirror 146
Exterior rear view mirror 40
Exterior rear view mirror
parking positions 132
Interior rear view mirror 39
Storing exterior rear view mirror
parking position 97
MON 234
MON (Motor Octane Number) 343
Mph or km/h in speedometer 124
Multifunction display 109, 343
Displaying gear range 141
Selecting language 124
Standard display 113
Multifunction display messages
ABS 268
BAS 265
Battery 269
Brake fluid 270
Brake pads 270Check engine 260
Check gas cap 277
Coolant 272
Coolant level 271
Cruise control 274
Display 274
Doors 274
Engine 260
Engine oil 276
ESP 266
Fuel reserve tank 277
Hood 277
Key 277
Lamps 277, 279–??
Parking brake 269
Steering column
not properly locked 282
Steering gear oil level 282
Tele Aid* 283
Telephone* 283
Trunk lid 283