2004 MAZDA MODEL B2300 TRUCK jump start

Seating and Safety Restraints 63
Seating 63
Safety restraints 65
Air bags 77
Child restraints 89
Driving 105
Starting 105
Brakes 110
Transmission operation 114
Vehicle loading 124
Trailer towing 128
Recreational towing 135
Roadside Emergencies 137
Hazard flasher switch 137
Fuel pump shut-off switch 137
Fuses and relays 138
Overheating 148
Changing tires 149
Jump starting 157
Wrecker towing 162
Customer Assistance 163
Reporting safety defects (U.S. only) 173
Cleaning 174
Table of Contents
2

WARNING: When a wheel is installed, always remove any
corrosion, dirt or foreign materials present on the mounting
surfaces of the wheel or the surface of the front disc brake hub
and rotor that contacts the wheel. Installing wheels without
correct metal-to-metal contact at the wheel mounting surfaces
can cause the wheel nuts to loosen and the wheel to come off
while the vehicle is in motion, resulting in loss of control.
JUMP STARTING YOUR VEHICLE
WARNING: The gases around the battery can explode if
exposed to flames, sparks, or lit cigarettes. An explosion could
result in injury or vehicle damage.
WARNING: Batteries contain sulfuric acid which can burn skin,
eyes and clothing, if contacted.
Do not attempt to push-start your vehicle. Automatic
transmissions do not have push-start capability; doing so may
damage the catalytic converter.
Preparing your vehicle
When the battery is disconnected or a new battery is installed, the
transmission must relearn its shift strategy. As a result, the transmission
may have firm and/or soft shifts. This operation is considered normal and
will not affect function or durability of the transmission. Over time, the
adaptive learning process will fully update transmission operation.
1.Use only a 12±volt supply to start your vehicle.
2. Do not disconnect the battery of the disabled vehicle as this could
damage the vehicle's electrical system.
3. Park the booster vehicle close to the hood of the disabled vehicle
making sure the two vehiclesdo nottouch. Set the parking brake on
both vehicles and stay clear of the engine cooling fan and other
moving parts.
4. Check all battery terminals and remove any excessive corrosion
before you attach the battery cables. Ensure that vent caps are tight
and level.
5. Turn the heater fan on in both vehicles to protect any electrical
surges. Turn all other accessories off.
Roadside Emergencies
157

Jump starting
1. Start the engine of the booster vehicle and run the engine at
moderately increased speed.
2. Start the engine of the disabled vehicle.
3. Once the disabled vehicle has been started, run both engines for an
additional three minutes before disconnecting the jumper cables.
Removing the jumper cables
Remove the jumper cables in the reverse order that they were
connected.
1. Remove the jumper cable from thegroundmetal surface.
Note:In the illustrations,lightning boltsare used to designate the
assisting (boosting) battery.
2. Remove the jumper cable on the negative (-) connection of the
booster vehicle's battery.
+–+–
+–+–
Roadside Emergencies
160

3. Remove the jumper cable from the positive (+) terminal of the
booster vehicle's battery.
4. Remove the jumper cable from the positive (+) terminal of the
disabled vehicle's battery.
After the disabled vehicle has been started and the jumper cables
removed, allow it to idle for several minutes so the engine computer can
relearnits idle conditions.
+–+–
+–+–
Roadside Emergencies
161

Cleaning your vehicle
engine compartment ..............175
instrument panel ....................178
interior .....................................178
interior trim ............................178
Mazda car care products .......179
plastic parts ............................177
washing ....................................174
waxing .....................................174
wheels ......................................175
wiper blades ............................177
Clock adjust
AM/FM Stereo ...........................18
AM/FM stereo CD .....................20
AM/FM stereo tape/CD/MP3 ....23
Premium AM/FM stereo
CD6/MP3 ...................................26
Single CD ..................................19
Clutch
fluid ..........................................222
operation while driving ..........117
recommended shift speeds ....118
Compass, electronic ..............46±47
calibration .................................48
set zone adjustment .................47
Console ........................................53
Coolant
checking and adding ..............202
refill capacities ................205, 240
specifications ..................243±244
Cruise control
(see Speed control) ....................49
Customer
Assistance ..................163±164, 167
D
Daytime running lamps
(see Lamps) ................................34Dipstick
engine oil .................................194
Doors
lubricant specifications ..........243
Driveline universal joint and
slip yoke ....................................226
Driving under special
conditions ..................119, 121±122
mud ..........................................122
sand .........................................122
snow and ice ...........................123
through water .................122±123
E
Emergencies, roadside
jump-starting ..........................157
Emergency Flashers .................137
Emission control system ..........217
Engine ........................................245
cleaning ...................................175
coolant .....................................202
idle speed control ...................200
limp to safety cooling .............206
lubrication
specifications ..................243±244
refill capacities ........................240
service points ..................190±192
starting after a collision .........137
Engine block heater .................109
Engine oil ..................................194
checking and adding ..............194
dipstick ....................................194
filter, specifications ................198
recommendations ...................198
refill capacities ........................240
specifications ..................243±244
Exhaust fumes ..........................110
Index
250

storage .............................149±152
Jump-starting your vehicle ......157
K
Keyless remote entry system -
see Remote entry system ...........55
Keys
positions of the ignition .........105
L
Lamps
bulb replacement
specifications chart ..................36
courtesy .....................................36
daytime running light ...............34
fog lamps ...................................34
headlamps .................................34
headlamps, flash to pass ..........35
instrument panel, dimming .....35
interior lamps .....................36±37
replacing
bulbs .................. 36±37, 39, 41±42
Lane change indicator
(see Turn signal) ........................36
LATCH anchors .........................101
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........111
Limited slip axle
(see Traction-Lok) ....................113
Limp to Safety Cooling .............206
Load limits .................................124
Loading instructions .................124
Lubricant specifications ...243±244
Lumbar support, seats ...............64
M
Manual transmission .................117fluid capacities ........................240
lubricant specifications ..........244
reverse .....................................118
Mirrors
automatic dimming rearview
mirror ........................................46
side view mirrors (power) .......49
Motorcraft parts ........................214
O
Octane rating ............................212
Oil (see Engine oil) ..................194
Overdrive .....................................52
Overheating ...............................148
P
Parking brake ............................112
Passive anti-theft system
(PATS) .........................................60
Power distribution box
(see Fuses) ...............................142
Power door locks ........................55
Power point .................................45
Power steering ..........................113
fluid, checking and adding ....220
fluid, refill capacity ................240
fluid, specifications .........243±244
Power Windows ...........................45
Preparing to drive your
vehicle ........................................113
R
Radio ..........................18±19, 22, 26
Single CD ..................................19
Relays ........................................138
Index
252

Remote entry system ...........55±56
arming and disarming the
anti-theft system ......................57
illuminated entry ......................59
locking/unlocking doors .....55±56
replacement/additional
transmitters ...............................58
replacing the batteries .............57
S
Safety Belt Maintenance ............76
Safety belts (see Safety
restraints) ..................65, 67±68, 70
Safety defects, reporting ..........173
Safety restraints ..............65, 67±70
belt minder ...............................73
extension assembly ..................72
for adults .............................67±68
for children .........................89±90
lap belt ......................................70
safety belt maintenance ...........76
warning light and chime ..........72
Safety restraints - LATCH
anchors ......................................101
Safety restraints - tether
anchors ........................................98
Safety seats for children ............93
Seat belts
(see Safety restraints) ...............65
Seats ............................................63
child safety seats ......................93
SecuriLock passive anti-theft
system ..........................................60
Servicing your vehicle ..............188
Setting the clock
AM/FM stereo ...........................18
AM/FM stereo CD .....................20AM/FM stereo tape/CD/MP3 ....23
Premium AM/FM stereo
CD6/MP3 ...................................26
Snowplowing .................................7
Spare tire (see Changing the
Tire) ...................................149±150
Spark plugs, specifications .......245
Special notice
ambulance conversions ..............7
utility-type vehicles ....................7
Specification chart,
lubricants ...........................243±244
Speed control ..............................49
Starting a flex fuel vehicle .......109
Starting your vehicle .......105±106,
108
jump starting ..........................157
Steering wheel
tilting .........................................44
Stereo
Single CD ..................................19
T
Tether anchors ............................98
Tilt steering wheel ......................44
Tires ...........................149, 227±228
changing ..........149±150, 153, 156
snow tires and chains ............239
tire grades ...............................228
treadwear ................................228
Towing .......................................128
recreational towing .................135
trailer towing ..........................128
wrecker ....................................162
Traction-lok rear axle ...............113
Index
253