IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
5.4L 4V V8 engine
1. Battery
2. Automatic transmission fluid dipstick
3. Engine oil filler cap
4. Power steering fluid reservoir
5. Engine oil dipstick
6. Brake fluid reservoir
7. Engine coolant reservoir
8. Air filter assembly
9. Windshield washer fluid reservoir
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus) Maintenance and Specifications
307
4. Open the hood. Protect yourself from engine heat.
5. Locate and carefully remove the
engine oil level indicator (dipstick).
6. Wipe the indicator clean. Insert the indicator fully, then remove it
again.
• If the oil level is between the MIN and MAX marks, the oil level is
acceptable. DO NOT ADD OIL.
• If the oil level is below the MIN
mark, add enough oil to raise the
level within the MIN-MAX range.
• Oil levels above the MAX mark may cause engine damage. Some oil
must be removed from the engine by a service technician.
7. Put the indicator back in and ensure it is fully seated.
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus) Maintenance and Specifications
309
Adding engine oil
1. Check the engine oil. For instructions, refer to Checking the engine
oil in this chapter.
2. If the engine oil level is not within the normal range, add only certified
engine oil of the recommended viscosity. Remove the engine oil filler cap
and use a funnel to pour the engine oil into the opening.
3. Recheck the engine oil level. Make sure the oil level is not above the
MAX mark on the engine oil level indicator (dipstick).
4. Install the indicator and ensure it is fully seated.
5. Fully install the engine oil filler cap by turning the filler cap clockwise
1/4 of a turn until the cap is fully seated.
To avoid possible oil loss, DO NOT operate the vehicle with the
engine oil level indicator and/or the engine oil filler cap removed.
Engine oil and filter recommendations
Look for this certification
trademark.
Use SAE 5W-20 engine oil.
Only use oils “ Certified For Gasoline Engines ” by the American
Petroleum Institute (API). To protect your engine ’ s warranty use
Motorcraft SAE 5W-20 or an equivalent 5W-20 oil meeting Ford
specification WSS-M2C153 – H. SAE 5W-20 oil provides optimum fuel
economy and durability performance meeting all requirements for
your vehicle ’ s engine .
Do not use supplemental engine oil additives, cleaners or other engine
treatments. They are unnecessary and could lead to engine damage that
is not covered by Ford warranty.
Change your engine oil according to the appropriate schedule listed in
the scheduled maintenance guide.
Ford production and aftermarket (Motorcraft) oil filters are designed for
added engine protection and long life. If a replacement oil filter is used
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus)Maintenance and Specifications
310
an automatic transmission application requiring MERCON may
cause transmission damage. Use of any fluid other than the
recommended fluid may cause transmission damage. 2
Indicates only approximate dry-fill capacity. Some applications may vary
based on cooler size and if equipped with an in-tank cooler. The amount
of transmission fluid and fluid level should be set by the indication on
the dipstick ’ s normal operating range.3
Add the coolant type originally equipped in your vehicle. 4
Your vehicle ’ s rear axle is filled with a synthetic rear axle lubricant and
is considered lubricated for life. These lubricants are not to be checked
or changed unless a leak is suspected, service is required or the axle has
been submerged in water. The axle lubricant should be changed any time
the axle has been submerged in water.
Service refill capacities are determined by filling the rear axle 23mm (0.9
inch) below the bottom of the filler hole. 5
Add 118 ml (4 oz.) of Additive Friction Modifier XL-3 or equivalent
meeting Ford specification EST-M2C118 – A for complete refill of Limited
Slip axles. For complete refills, fill using the Additive Friction Modifier
first. 6
Use of synthetic or synthetic blend motor oil is not mandatory. Engine
oil need only meet the requirements of Ford specification
WSS-M2C153 – H and the API Certification mark.
LUBRICANT SPECIFICATIONS
Item Ford part
name Ford part
number Ford
specification
Hinges, latches,
striker plates
and rotors, seat
tracks, fuel filler
door hinge and
spring Multi-Purpose
Grease XG-4 or XL-5 ESR-M1C159-A
or ESB-M1C93-B
Lock cylinders Penetrating and
Lock Lubricant Motorcraft XL-1 ESB-M2C75-B
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus) Maintenance and Specifications
351
safety belts ..............................302
washing ....................................299
waxing .....................................299
wheels ......................................300
wiper blades ............................301
Clock ..........................................117
Compass, electronic
set zone adjustment ...............138
Console ......................................148
overhead ..........................114 – 116
rear ..........................................149
Controls
power seat ...............................170
steering column ......................129
Coolant
checking and adding ..............313
refill capacities ................317, 349
specifications ..................351, 354
Cruise control
(see Speed control) ..................126
Customer Assistance ................262
Ford accessories for your
vehicle .....................................304
Ford Extended Service
Plan ..........................................292
Getting assistance outside the
U.S. and Canada .....................296
Getting roadside assistance ...262
Getting the service you
need .........................................290
Ordering additional owner ’ s
literature .................................297
The Dispute Settlement
Board .......................................292
Utilizing the
Mediation/Arbitration
Program ...................................295 D
Daytime running lamps
(see Lamps) ..............................100
Defrost
rear window ..............................98
Dipstick
automatic transmission
fluid ..........................................330
engine oil .................................308
Doors
lubricant specifications ..........351
Driveline universal joint and
slip yoke ....................................332
Driving under special
conditions ..................238, 245, 248
sand .........................................247
snow and ice ...........................249
through water .................247, 251
E
Electronic message center .......136
Emergencies, roadside
jump-starting ..........................282
Emission control system ..........326
Engine ........................................354
cleaning ...................................300
coolant .....................................313
fail-safe coolant ......................317
idle speed control ...................311
lubrication
specifications ..................351, 354
refill capacities ........................349
service points ..........................307
starting after a collision .........263
Engine block heater .................220
Engine oil ..................................308
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus)Index
362
change oil soon warning,
message center .......................308
checking and adding ..............308
dipstick ....................................308
filter, specifications ........310, 348
recommendations ...................310
refill capacities ........................349
specifications ..................351, 354
Exhaust fumes ..........................220
Extended Rear Park Assist ......238
F
Fail safe cooling ........................317
Floor mats .................................149
Fluid capacities .........................349
Foglamps .....................................99
Four-Wheel Drive vehicles .......240
control trac .............................240
description ..............................241
driving off road .......................243
electronic shift ........................242
indicator light .........................240
preparing to drive your
vehicle .....................................227
Fuel ............................................319
calculating fuel
economy ..........................139, 323
cap ...........................................321
capacity ...................................349
choosing the right fuel ...........321
comparisons with EPA fuel
economy estimates .................326
detergent in fuel .....................322
filling your vehicle with
fuel ...........................319, 321, 323
filter, specifications ........323, 348
fuel pump shut-off switch .....263
improving fuel economy ........323
octane rating ...................322, 354 quality ......................................322
running out of fuel .................322
safety information relating to
automotive fuels .....................319
Fuses ..................................265 – 266
G
Garage Door Opener (see
Homelink wireless control
system) ......................................132
Gas cap (see Fuel cap) ............321
Gas mileage (see Fuel
economy) ...................................323
Gauges .........................................14
GAWR (Gross Axle Weight
Rating) .......................................252
calculating ...............................254
definition .................................252
driving with a heavy load ......252
location ....................................252
GVWR (Gross Vehicle Weight
Rating) .......................................252
calculating .......................252, 254
definition .................................252
driving with a heavy load ......252
location ....................................252
H
Hazard flashers .........................263
Headlamps ...................................99
aiming ......................................101
autolamp system .......................99
bulb specifications ..................103
daytime running lights ...........100
flash to pass ............................100
high beam ...............................100
replacing bulbs .......................105
turning on and off ....................99
2004 Navigator (nav)
Owners Guide (post-2002-fmt)
USA English (fus) Index
363