2004 JAGUAR XJ transmission

4-62 On the Road
Towing a Trailer
Your Jaguar Retailer, and the main
motoring organisations can advise you on
towing, towing weight capacities and
about regulations that apply in other
countries.
The following are important points of
safety, stability and comfort upon which
further advice should be sought:
• Maximum braked towing weight is permissible, provided long periods of
uphill driving on gradients over 8%
are not undertaken.
• In high altitude mountainous regions, the thinner atmosphere can reduce
engine performance. Above 3280 feet
(1000 metres) the stipulated
maximum permitted gross train
weight must be reduced by 10% for
every 3280 feet (1000 metres) in
altitude.
• The kerbside weight of the vehicle can be found on page 8 - 4.
• When towing at the maximum permissible rear axle load keep within
legal towing speeds but in any case do
not exceed 62 mph (100 km/h). • Tyres must be inflated to the normal
(higher) pressures shown on the tyre
pressure label on the fuel filler flap.
• The recommended maximum tow-ball nose weight is shown
on page 8 - 5. Having a lower nose
weight or exceeding the maximum
nose weight limit may impair the
vehicle’s handling.
• When towing, the nose weight of the trailer and the tow-bar assembly must
be deducted from the permissible
maximum load, see page 8 - 5.
• Avoid heavy braking. As the overrun brake on the traile r is not connected
to the ABS, heavy trailer braking
could critically affect the stability of
the outfit as a whole.
• Ensure that the towing vehicle’s engine, transmission, suspension,
brakes and tyres are fully efficient and
regularly serviced. Similarly check the
wheels, tyres, brakes and wheel
bearings of the trailer. Caution:
1. When not in use, it is
recommended that the removable
tow-ball is either securely stowed
in the luggage compartment or,
preferably, not in the vehicle.
Do not leave it loose in the
vehicle.
2. It is essential that only a Jaguar tow-bar and Jaguar electrical tow-
bar kit are supplied and fitted by a
Jaguar Retailer. Contact your
Jaguar Retailer for details of
additional parts that are advised
to be fitted before towing. This is
particularly important with this
vehicle having air suspension.
If unapproved towing equipment
is used whilst towing, the air
suspension speed lowering
function will not be inhibited.
This may result in a change in
trailer weight distribution and
attitude.

6 - 4 Roadside Emergency
Trunk Underfloor Access
The space under the trunk floor houses
the spare wheel, battery, jack and rear
fuse box.
To raise the floor panel, press down the
rear of handle (A) then, holding the
handle at the front, swing the floor panel
upwards ( B). Hook the handle securely
over the top edge of the trunk
opening ( C).
Emergency Starting
This vehicle is fitted with automatic
transmission. In the event of a discharged
battery preventing a normal engine start,
the vehicle cannot be started by pushing
or towing. Either use jump leads
connected to a booster battery (e.g. on
another vehicle) or fit a fully charged
battery (see page 7 - 15).
Emergency Starting Using
Jump Leads
Both the booster and discharged battery
should be treated with great care when
using jump leads. Al ways use high quality
leads capable of carrying the starter
current of the vehicle to be started.
Before commencing, the following
precautions must be taken:
• When the battery of another vehicle is being used, ensure that the vehicles
do not touch. Alternatively, remove
the charged battery and place near to,
not on, the vehicle with the
discharged battery.
• Ensure that both vehicles have all electrical services OFF,
the parkbrakes applied and the
transmission in the ‘P’ (park) position.
• Where the jump leads are of a different colour, e.g. red and black,
use red for positive (+). This aids
identification and helps to avoid
crossing positive (+) to negative (–).
Take extra care to avoid crossing the
polarity when using cables of the
same colour.

Roadside Emergency 6 - 11
Vehicle Recovery
The preferred vehicle recovery method is
by using a flat bed transporter or rear
suspended tow.
Caution:
1. If the vehicle has defective transmission, to prevent further
damage, it must be towed with
the rear wheels clear of the
ground.
2. Ensure that the recovery team do not tow with sling-type
equipment since damage to the
bodywork may result.
3. Do not tow the vehicle by suspending the front end.
Transporting
If the vehicle is being transported on a
trailer or flat bed transporter,
the parkbrake must be applied,
the wheels chocked and the gear selector
lever moved to position ‘N’ or ‘D’ but
NEVER to ‘P’.
The vehicle must be securely tied down
to the transporter or trailer, see next
page.

6 - 12 Roadside Emergency
Transporter tie-down procedure
!WARNING:
Avoid body contact with a hot
exhaust pipe when securing the
vehicle to the transporter.
IMPORTANT – Use straps over the
wheels/tyres only, to secure the vehicle to
the transporter.
Caution: Do not use the tie-down
brackets on the vehicle rear
underbody; these are for Jaguar
factory use only. In time, with the
engine switched off, the vehicle body
will drop due to settling of the air
suspension system and cause the tie-
down chains/straps to become slack if
connected to these brackets.
The towing eye is not designed for
securing the vehicle during
transportation. Vehicle failure
The removable towing eye is primarily for
emergency use when towing for SHORT
DISTANCES, e.g. removing the vehicle if it
is causing an obstruct
ion or for winching
the vehicle onto a re covery transporter.
To prevent damage to the automatic
transmission whilst the vehicle is being
towed with the rear wheels on the
ground, towing distance must be
restricted to 0.5 miles (0.8 kilometres).
Towing speed must not exceed 30 mph
(48 km/h).
Always obey towing regulations.
In certain countries the registration
number of the towing vehicle and an
‘ON TOW’ sign or warning triangle must
be displayed in a prominent position at
the rear of the vehicle being towed. When being towed, the gear selector
lever must be in neutral (position ‘N’)
with the ignition key turned to
position ‘II’ to release the steering lock
and render the indicators, horn and
brake lights operational.
!WARNING:
When the engine is not running the
steering and brakes will no longer be
power-assisted.
Therefore, be prepared for relatively
heavy steering and the need for
greatly increased brake pedal
pressure.

6 - 24 Roadside Emergency
Engine compartment fuse boxFuse No Fuse
Type Rating
(amps) Colour
Circuit
F1 ATO 10A Red Front ignition, UHEGO, fu el pump, rear ignition relay coils
F2 – F3 Not used
F4 ATO 30A Green Powerwash pump
F5 Not used
F6 ATO 40A Orange Air suspension compressor
F7 ATO 40A Orange Right-hand front screen heater or wiper park zone heater
F8 ATO 20A Yellow Right-hand dipped beam
F9 ATO 20A Yellow Left-hand dipped beam
F10, F11 Not used
F12 ATO 10A Red Engine control module
F13 ATO 10A Red Fuel injectors
F14 ATO 10A Red Purge valve, EGR valve, canister close valve (CCV), port deactivation, V6 intake manifold
tuning valves (IMTV), MAFS, air filter solenoid, radiator fan controller
F15 Not used
F16 ATO 20A Yellow Right-hand main beam, left-hand main beam
F17 ATO 10A Red Engine control module, transmission control module
F18 ATO 15A Blue Front fog lights, instrument cluster front fog status

Roadside Emergency 6 - 27
F17 ATO 5A Tan ABS module
F18 Not used
F19 ATO 5A Tan Ignition relay, ECM, REM, fuel pump relay, start relay
F20 ATO 5A Tan Telephone transceiver, TV module, VICS (Japan), voice module, rear telematics
F21 – F23 Not used
F24 ATO 10A Red PATS transponder
F25 ATO 10A Red Right-hand direction indicator and repe ater, right-hand front lamp, header console map
lamp
F26 ATO 15A Blue Screenwash pump
F27 ATO 10A Red ACC module
F28 ATO 10A Red Climate control modules (front and rear), driver’s door module (DDM)
F29 ATO 10A Red Air bag module, occupancy se nsing module, passenger weight sensor
F30 ATO 10A Red Voice, front/rear sound, DVD, telematics, TV
F31 ATO 15A Blue Sunroof
F32 ATO 5A Tan Front/rear parking aid, trailer tow module, battery backed sounder, voice module, telephone receiver
F33 ATO 5A Tan Transmission control, J-gate, generator
F34 ATO 5A Tan Navigation system
Fuse No
Fuse
Type Rating
(amps) Colour
Circuit

7-12 Maintenance
Capacities
US Quarts Litres
Engine oil:
– Normally aspirated V8 engines, including oil filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
– Supercharged V8 engines, including oil filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.45
6.2 6.0
6.8
The rear axle (final drive unit) and automatic transmission unit (gearbox) will not normally require to
be checked or topped up.
Windscreen washer reservoir:
– Without headlight power wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
– With headlight power wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4.0
6.35 4.5
7.0

Index
Adaptive cruise control . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 51
Air conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Alarms and audible signals . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
– audible signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
– error signal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 16
– full alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 15
Alloy wheels – care of . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Anti-freeze . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
Anti-lock braking system (ABS) . . . . . . . . . . . . . . . . . . . . 4 - 47
Audible warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 10
Automatic car wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 23
Automatic climate control . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Automatic transmission . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 43
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 13
– back-up sounder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
– charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 15
– electrolyte level – check/top up . . . . . . . . . . . . . . . . . . 7 - 15
– lead connection/disconnection . . . . . . . . . . . . . . . . . . 7 - 16
– reconnection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 18
Brake fluid level check . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 9
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 47
Brightwork – polishing . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24 Bulb renewal
– front direction indicator . . . . . . . . . . . . . . . . . . . . . . . 6 - 15
– front fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– front parking (side) light . . . . . . . . . . . . . . . . . . . . . . . . 6 - 16
– headlight – dipped beam . . . . . . . . . . . . . . . . . . . . . . . 6 - 15
– headlight – main beam . . . . . . . . . . . . . . . . . . . . . . . . 6 - 16
– number plate light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– rear light assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 19
– side marker . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 18
– side repeater indicator . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 17
– top access cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 - 14
C
Capacities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 12
Carpets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 22
Catalytic converters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 68
Checks and top up
– brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 9
– engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 11
– engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 6
– power steering fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 8
– washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 10
Child restraint tether anchorages . . . . . . . . . . . . . . . . . . 3 - 29
Child safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 23
– door locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 14
Chromework – polishing . . . . . . . . . . . . . . . . . . . . . . . . . 7 - 24
Climate control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 3
Clock adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 32
Coolant level – check/top up . . . . . . . . . . . . . . . . . . . . . . 7 - 11
Cruise (speed) control . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 - 49