2004 ISUZU TF SERIES oil pressure

7C-44 CLUTCH

Checkpoint Trouble Cause Countermeasure

Replace the release bearingRelease bearing broken
Clean the related parts and/or
replace the facing
Replace the crankshaft rear oil
seal
Defective crankshaft rear oil
seal
NG NG
OK OKGrease or oil adhering to the
facing
Clutch diaphragm springReplace the clutch pressure
plate assemblyWeak or broken clutch
diaphragm spring
Replace the driven plate
assemblyWorn facing
NG NG
OKFacing Continued from the previous page

CLUTCH 7C-47

3. CLUTCH SHUDDER

Checkpoint
Trouble Cause
Countermeasure

Grease or oil adhering to the
facing
Clean the related parts and/or
replace the facing
Replace the transmission front
cover oil seal
Replace the pressure plate
assembly
Defective transmission front
cover oil seal
Pressure plate unevenly wornPressure plate
Clean the related parts and/or
replace the facing
Tighten the connections
Repair or replace the
applicable parts
Too much grease
Poorly connected components
causing looseness and
abrasion
OK
NG NG NG NG
OK
Power train
Clean and grease the spline
contact surface
Insufficient grease on the
spline contact surface of the
splined hub
Driven plate
Clean or repair the top gear
shaft spline
Replace the top gear shaft
Clean the related parts and/or
replace the facing
Replace the crankshaft rear oil
seal
Corrosion or step wear on the
top gear shaft spline
Defective crankshaft rear oil
seal
OKNG NG NG
OK
Continued on the next page

ELECTRICAL-BODY AND CHASSIS 8A-25
Light Name Rated Power
V-W Number of
Bulbs Lens
Color Remarks
W/O Tacho 5Illumination light 14-2
W/ Tacho 7White
Turn Signal 14-1.12 2 Green
High Beam 14-1.12 1 Blue
Low Fuel 14-1.12 1 Amber
A/T Oil Temp 14-1.12 1 Red
Brake system 14-1.12 1 Red
4WD 14-1.12 1 Green
Seat belt 14-1.12 1 Red
Oil pressure 14-1.12 1 Red
ABS 14-1.12 1 Amber
SEDIMENTER 14-1.12 1 Red
AIR BAG 14-1.12 1 Red
Brake 14-1.12 1 Red
Charge 14-1.12 1 Red
Check Trans 14-1.12 1 Red
Check 4WD 14-1.12 1 Red
Power drive 14-1.12 1 Amber
3rd start 14-1.12 1 Green
4L 14-1.12 1 Green
Cruise Set 14-1.12 1 Green
Check Engine 14-1.12 1 Amber
Front Fog 14-1.12 1 Green
Rear foglight 14-1. 12 1 Amber
Glow 14-1.12 1 Amber
P LED 1 Green
R LED 1 Green
N LED 1 Green
D LED 1 Green
3 LED 1 Green
2 LED 1 Green












Indicator/
Warning
light
A/T shift
indicator
L LED 1 Green

ELECTRICAL-BODY AND CHASSIS 8A-261
2. Even when the parking brake lever is pulled, the indicator light does not go off

Checkpoint Trouble Cause Countermeasure

Adjust the SW. installation
position or replace the parking
brake SW. Incorrect the parking brake
SW. adjustment or brake SW.
faulty
NG Thermo unit malfunction
Replace the brake fluid level
SW., or vacuum SW., or
repair a short circuit between
the parking brake SW.
connector 1
C-39
(Lever: 1
R-4) and 9 B-23
or the brake fluid level SW.
connector 2
C-37 and 9
B-23, (or the vacuum SW.
connector 1
C-38 and 9
B-23 : 4JH1-TC ONLY)
Check to see if the indicator
light goes off when the parking
brake SW. connector 1
C-39
(Lever: 1
R-4) is
di t d
Brake fluid level SW. or
vacuum SW. faulty or short
circuit
NG OK

Parking brake SW. installation
position and function




3. Oil pressure warning light does not go off while engine is running


Refer to ENGINE Section

Refer to ENGINE Section
NG Thermo unit malfunction

Repair a short circuit between
1
E-1 and 3 B-24

Check to see the warning light
goes off when the oil pressure
SW. connector
1
E-1 is disconnected


Short circuit


Replace the oil pressure unit
(or the oil pressure SW.)
Continuity between the oil
pressure SW. connector
1
E-1 and the body ground
when the engine is operating


Oil pressure unit (or oil
pressure SW) faulty
NG NG OK
OK

Engine oil pressure

8A-274 ELECTRICAL-BODY AND CHASSIS





Terminal Connector No. B-23
No. C24SE
1
ABS CONT. (BRAKE)
2


3


4


5


6


7


8


9
BRAKE
10
CHARGE
11
TURN (RIGHT)
12


13


14


15


16


17
ILLUMI (-)
18
ILLUMI (+)

Terminal Connector No. B-24
No. C24SE
1


2
4LO
3
OIL PRESSURE
4


5
4WD
6
CHECK 4WD
7


8


9
SPEED (+)
10
4P OUTPUT
11


12
STARTER
13
TEMP
14
FUEL
15
FRONT FOG
16


17
CHECK ENGINE
18
AIR BAG
19
SEAT BELT
20
BEAM (+)
21
TURN (LEFT)
22
BEAM (-)
23
BEAM (+)
24


25


26
POWER GND
27
SPEED (-)
28
GND UNIT
29
+B
30
IGN

8A-428 ELECTRICAL-BODY AND CHASSIS


No. Connector face No. Connector face
E-1
(4JH1-TC)
White Oil pressure switch E-10
SilverEngine ground
E-2
(C24SE)
(6VE1)


Magnetic clutch E-11
(6VE1)

Neutral switch
E-3
(4JH1-TC)
Black
Magnetic clutch AC COMP E-11
(4JH1-TC)
Natural
green
Neutral switch
E-4
~
E-5 NOT USED E-12
(6VE1)

Neutral switch
E-6
(C24SE)
(6VE1)


(6VE1) Fuel injector (C24SE) E-12
(4JH1-TC)
Natural
green
Neutral switch
E-6
(4JH1-TC)

Injector pump E-13
~
E-17 NOT USED
E-7
(C24SE)
(6VE1)


(6VE1) Fuel injector (C24SE) E-18
(C24SE)

Ignition coil
E-8
(C24SE)
(6VE1)


(6VE1) Fuel injector (C24SE) E-19
(4JH1-TC)
Blue Thermo meter unit
E-9
(C24SE)
(6VE1)


(6VE1) Fuel injector (C24SE) E-20
~
E-21 NOT USED
E-9
(4JH1-TC)
Gray T.D.C sensor E-22
(4JH1-TC)
BrownTPS 1 main

8A-430 ELECTRICAL-BODY AND CHASSIS


No. Connector face No. Connector face
E-54
(6VE1)
Ignition coil E-62
(6VE1)
Cam position sensor
E-54
(4JH1-TC)
Black A/T term ASM E-64
(C24SE)
(6VE1)
Oil pressure switch (P/STRG)
E-55
(6VE1)
Ignition coil E-65
(C24SE)
(6VE1)
Thermo unit
E-56
(6VE1)
Ignition coil E-66
(C24SE)
(6VE1)
Duty solenoid
E-57
(6VE1)
Ignition coil E-67
NOT USED
E-58
(6VE1)
Ignition coil E-68
(C24SE)
Throttle position sensor
E-59
(C24SE)
(6VE1)
(6VE1) Crank position sensor (C24SE) E-68
(6VE1)
Throttle position sensor
E-60
(C24SE)
ECM E-69
(6VE1)
Temperature sensor
E-60
(6VE1)
ECM-A E-70
(C24SE)
IACV
E-61
(6VE1)
ECM-B E-70
(6VE1)
IACV

ELECTRICAL-BODY AND CHASSIS 8A-431


No. Connector face No. Connector face
E-71

NOT USED E-80
(6VE1)
Cylinder revolution
E-72
(C24SE)
(6VE1)
Engine earth-A E-81
(6VE1)
Speed sensor
E-73
(6VE1)
Engine earth-A E-82
(6VE1)
Transmission wire
E-74
(C24SE)
(6VE1)
Engine earth-B E-83
(6VE1)
Oil temperature sensor
E-75
(C24SE)
(6VE1)
Oil pressure switch E-84
(C24SE)
Knock sensor
E-76
(6VE1)
EGR valve E-85
(C24SE)
MAP sensor
E-77
(C24SE)
O2 sensor E-86
(4JA1-L)
SilverThermo switch; QOS
E-77
(6VE1)
O2 sensor RH-Front E-87
(4JA1-L)
WhiteSolenoid CSD
E-78
(6VE1)
O2 sensor LH-Front E-88
(4JA1-L)
SilverThermo switch; EGR
E-79
(6VE1)
Neutral start switch E-89
(4JA1-L)
White

Immobilizer engine control unit