2004 HONDA S2000 battery

If you have recently ref ueled your
vehicle, the indicator coming on
could be a loose or missing f uel f ill
cap. Tighten the cap until it clicks at
least three times. Tightening the cap
will not turn the indicator of f
immediately; it takes at least three
days of normal driving.Your vehicle has certain ‘‘readiness
codes’’ that are part of the on-board
diagnostics f or the emissions
systems. In some states, part of the
emissions testing is to make sure
these codes are set. If they are not
set, the test cannot be completed.If your vehicle battery has been
disconnected or gone dead, these
codes are erased. It takes at least
three days of driving under various
conditions to set the codes again.
To check if they are set, turn the
ignition to ON (II), without starting
the engine. The Malf unction
Indicator Lamp will come on f or 20
seconds. If it then goes of f , the
readiness codes are set. If it blinks 5
times, the readiness codes are not
set. If possible, do not take your
vehicle f or a state emissions test
until the readiness codes are set.
Refer to State Emissions Testing for
more inf ormation, on page .
If this indicator comes on
while driving, it means one
of the engine’s emission control
systems may have a problem. Even
though you may f eel no dif f erence in
your vehicle’s perf ormance, it can
reduce your f uel economy and cause
increased emissions. Continued
operation may cause serious damage. If the indicator comes on repeatedly,
even though it may go of f as you
continue driving, have your vehicle
checked by a dealer as soon as
possible.
188
T aking Care of t he Unexpect ed
Malf unction Indicator L amp
Readiness Code
167
NOTICE:If you keep driving with the
Malf unction Indicator Lamp on, you
can damage your vehicle’s emissions
controls and the engine. Those repairs
may not be covered by your vehicle’s
warranties.

The interior f use box is underneath
the dashboard on the driver’s side.There are two under-hood f use
boxes in the engine compartment.
The primary under-hood f use box is
onthepassenger’ssidenexttothe
battery. To open it, push the two tabs
as shown.
The auxiliary f use box is on the
driver’s side, near the brake f luid
reservoir. To open it, push the tab on
each side, and remove the lid.If something electrical in your
vehicle stops working, check f or a
blown f use f irst. Determine f rom the
chart on pages and ,or the
diagram on the f use box lid, which
f uses control that device. Check
those fuses first, but check all the
f uses bef ore deciding that a blown
f use is the cause. Replace any blown
f uses, and check if the device works.
172 173
Fuses
T aking Care of t he Unexpect ed
Checking and Replacing Fuses
170
INTERIOR
UNDERHOOD
(AUXILIARY)
UNDERHOOD
(PRIMARY)

µ
µ
µ
µ
µ
µ
µµ
µ
µ
µ
No. Amps. No. Amps. Circuits Protected
No. Amps. Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10
11
12
13 40 A
20 A
30 A
20 A
40 A
20 A 14
15
16
17
18
19
20
21
22
23
24
2520 A
15 A
10 A
20 A
15 A
20 A
20 A
30 A
100 A 40 A Magnetic Clutch Relay
Right Headlight
ACG S
Hazard Warning Lights
Cooling Fan
Not used
Stop
Lef t Headlight
ABS F/S
ABS Motor
Battery
IG1 Main
1
2
3
4
5 20 A
70 A
60 A Rear Window Defogger
Not used
Not used
EPS
Air Pump Lighting 1 Relay
Lighting 2 Relay
Horn Relay
Power Window Motor
Right Roof Motor
Not used
Backup ACC
Lef t Roof Motor
Heater Motor
Condenser Fan
Not used
Condenser Fan Relay
Cooling Fan Relay
Fuse Locations
T aking Care of t he Unexpect ed173
(AUXILIARY FUSE BOX)
UNDER-HOOD FUSE BOXES
(PRIMARY FUSE BOX)

µ
µ
µµ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Specif ications
T echnical Inf ormation181
Battery
Fuses
Alignment
Tires
Lights
Air conditioning
55 W
12 V 12 V 36 AH/5 HR
0.00 in (0.0 mm)
0.15 in (3.7 mm)0°30’
6°
215/45R17 87W
245/40R17 91W
32 psi (220 kPa , 2.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
60 psi (420 kPa , 4.2 kgf/cm)
T125/70D16 96M 1°30’
12 V 21 W 12 V 21 W
12 V 55 W(H1)
35 W
12 V Capacity
Under-hood
Interior
Toe
Camber
Caster
Size
PressureSee page
173or the fuse box
cover.
See page 172or the fuse label
attached to the inside of the fuse
box door under the dashboard.
Headlights
Daytime running lights
Front turn signal lights
Rear turn signal lights
Side marker lights
Back-up lights
License plate light
Interior light
Trunk light
Side turn signal lights
Refrigerant type
Charge quantity
Lubricant type
HFC-134a (R-134a)
19.4 21.2 oz (550 600 g) SP-10
12 V 5 W
12 V 21 W
12 V 5 W
12 V 5 W
12 V 5 W
5W
12 V Front
Rear
Front
Rear
Front in
Front
Rear
Spare Tire
Front
Rear
Spare Tire
High
Low
Front

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing.
Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F. Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
Keep the vehicle in Neutral.
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes).
St at e Emissions T est ing
T echnical Inf ormation
T esting of Readiness Codes
188

µ
µ
µ µ
µ
µ µ
µ
µ
Your new Honda is covered by these
warranties:
covers your new vehicle, except f or
the battery, emissions control
systems, and accessories, against
def ects in materials and
workmanship.
these two
warranties cover your vehicle’s emis-
sions control systems. Time, mileage,
and coverage are conditional. Please
read the warranty manual for exact
inf ormation.
this warranty gives up
to 100 percent credit toward a
replacement battery. a seat
belt that f ails to f unction properly is
coveredfortheusefullifeof the
vehicle.
Honda Accessories are covered
under this warranty. Time and
mileage limits depend on the type of
accessory and other f actors. Please
read your warranty manual f or
details.
covers all Honda
replacement parts against defects in
materials and workmanship. provides
coverageforaslongasthepur-
chaser of the muf f ler owns the
vehicle.
Restrictions and exclusions apply to
all these warranties. Please read the
2004 Honda Warranty Inf ormation
booklet that came with your vehicle
f or precise inf ormation on warranty
coverages. Your Honda’s original
tires are covered by their
manuf acturer. Tire warranty inf or-
mation is in a separate booklet.
Please ref er to the 2004 Warranty
Manual that came with your vehicle. provides prorated
coverage f or a replacement battery
purchased f rom a Honda dealer.
all exterior body panels
are covered f or rust-through f rom
theinsideforthespecifiedtime
period with no mileage limit.
Warranty Coverages
Warrant y and Cust omer Relat ions
U.S. Owners
Canadian Owners
New Vehicle L imit ed Warrant yEmissions Cont rol Syst ems Def ect sWarrant y and EmissionsPerf ormance Warranty
Original Equipment Bat t ery L imit edWarranty Seat Belt Limited Warranty
Accessory Limited WarrantyReplacement Part s L imit edWarranty Replacement Muf f ler L if et ime
Limited Warranty
Replacement Bat t ery L imit ed
Warranty
Rust Perf orat ion L imit ed Warranty
193

CONT INUED
Accessories.................................
Installation .105
...............
Accessory Power Socket . 70
ACCESSORY (Ignition Key .......................................
Position) .53
....................
Additives, Engine Oil . 130
...............................
Airbag (SRS) .9, 18
..............................
Air Conditioning .74
.......................
Air Pressure, Tires .146
.............................
Alarm, Anti-theft .53
......................................
Antif reeze .132
Anti-lock Brakes (ABS) ....................
Indicator Light .41, 118
...................................
Operation .117
.
Anti-thef t Steering Column Lock . 53
............................
Anti-thef t System .94
......................................
Audio Panel .71
..................................
Audio System .78
...............
Automatic Speed Control . 95 ............................
Capacities Chart .180
.............
Carbon Monoxide Hazard . 34
........................
Cargo, .107
..............
CAUTION, Explanation of . ii
...........................................
CD Care .85
........................
CD Error Messages .86
.....................................
CD Changer .84
.......
CD Changer Error Messages . 87
.........................................
CD Player .83
........................
Certif ication Label .178
...................................
Chains, .150
Changing Oil ........................................
How to .130
......................................
When to .121
....................
Changing a Flat Tire .155
...
Charging System Indicator . 40,166
............
Checklist, Bef ore Driving . 112
........
Back-up Light Replacement . 141Battery
Charging System ...........................
Indicator .40, 166
............................
Jump Starting .162
..............................
Maintenance .151
............................
Specif ications .181
................................
Bef ore Driving .99
....................................
Belts,Seat .8,15
.............................
Beverage Holder .70
..................................
Booster Seats .31
............................................
Brakes .116
...........
Anti-lock System (ABS) . 117
.............
Break-in, New Linings . 100
...........................................
Fluid .136
.........................................
Parking .67
.................
System Indicator . 40,168
..............
Wear Indicators, Disc . 117
.............................
Braking System .116
.................
Break-in, New Vehicle . 100
..
Brightness Control, Instruments . 49
........................
Brights, Headlights .48
.........................
Bulb Replacement .137
..........................
Back-up Lights .141
.................................
Headlights .137
...........
Side Turn Signal Lights . 139
............................
Specif ications .181 ............
Turn Signal Lights . 139,141
..............................
Bulbs, Halogen .137
how to carry
tires
Index
B A C
I

..............................
Economy, Fuel .104
............
Emergencies on the Road . 153
.............
Battery, Jump Starting . 162
................
Changing a Flat Tire . 155
.....
Charging System Indicator . 166
..................
Checking the Fuses . 170
.........
Hazard Warning Flashers . 49
.....
Low Oil Pressure Indicator . 166
...
Malf unction Indicator Lamp . 167
..................
Overheated Engine . 163
...........................
Emergency Brake .67
......................
Emergency Flashers .49
............
Emergency Trunk Opener . 55
.......................
Emissions Controls .185
.....................................
Child Saf ety .22
..............................
Booster Seats .31
...................................
Child Seats .26
.....
Important Saf ety Reminders . 25
..........................
Larger Children .30
......................
Risk With Airbags .23
.............................
Small Children .26
.......................................
Child Seats .26
Cleaning .................................
Floor Mats .143
...................................
Seat Belts .143
...................................
Clutch Fluid .136
........................
CO in the Exhaust .185
.........................
Compact .154
.............
Controls, Instruments and . 70
..............................
Convertible Top .61
...............
Convertible Top Cover . 63
..
Lowering the Convertible Top . 61
................................
Maintenance .65
.....
Raising the Convertible Top . 64
Coolant ........................................
Adding .132
....................................
Checking .103
.........................
Proper Solution .132
...................
Temperature Gauge . 45Crankcase Emission Control
........................................
System .185
..............
Cruise Control Operation . 95
................
Cruise Control Indicator . 42
......................................
Cup Holder .70
Customer Relations ................................
Inf ormation .192
................
DANGER, Explanation of . ii
.......................................
Dashboard .38
................
Daytime Running Lights . 48
Daytime Running Lights .......................................
Indicator .42
.................................
Dead Battery .162
............
Def ects, Reporting Saf ety . 194
................
Def rosting the Windows . 77
....................................
Dimensions .180
...............
Dimming the Headlights . 48
Dipstick ..................................
Engine Oil .103
..........................
Directional Signals .48
........
Disc Brake Wear Indicators . 117
.....................
Disposal of Used Oil .132
...................
Do Not Tow a Trailer . 118Doors
..............
Locking and Unlocking . 54
..............................
Monitor Light .41
......................
Power Door Locks .54
..........
DOT Tire Quality Grading . 182
Downshif ting, 6-speed Manual
.............................
Transmission .114
...........................................
Driving .111
....................................
Economy .104
spare tire
Index
D
E
II