2004 HONDA PILOT oil dipstick

Wait a f ew minutes af ter turning the
engine of f bef ore you check the oil.Remove the dipstick (orange
handle).
Wipe of f the dipstick with a clean
cloth or paper towel.
Insert it all the way back into its
tube. Remove the dipstick again and
check the level. It should be
between the upper and lower
marks.
If it is near or below the lower mark,
see on page . Look at the coolant level in the
radiator reserve tank. Make sure it is
between the MAX and MIN lines. If
it is below the MIN line, see
on page f or
inf ormation on adding the proper
coolant.
Refer to on page f or inf ormation
on checking other items in your
Honda.
1.
2.
3. 4.
163174
171
Service Station Procedures
Bef ore Driving
Oil Check
A dding OilEngine Coolant Check
A dding
Engine Coolant
Owner’s Maintenance
Checks
127
UPPER MARK
LOWER MARK MAX
MINRESERVE TANK
DIPSTICK

Fluid Locations
Maint enance170
RADIATOR CAP
ENGINE OIL DIPSTICK
(Orange loop)
BRAKE FLUID
(Gray cap)
WASHER FLUID
(Blue cap)
AUTOMATIC
TRANSMISSION
FLUID DIPSTICK
(Yellow loop)
POWER STEERING
FLUID (Red cap) COOLANT
RESERVOIR
ENGINE OIL FILL CAP

Put a new washer on the drain bolt,
then reinstall the drain bolt.
Tighten it to:
Remove the oil f ilter and let the
remaining oil drain. A special
wrench (available from your
Honda dealer) is required.
Install a new oil f ilter according to
the instructions that come with it. Turn of f the engine, let it sit f or
several minutes, then check the oil
level on the dipstick. If necessary,
add more oil.
Refill the engine with the recom-
mended oil.
Engine oil change capacity
(including f ilter):
Replace the engine oil f ill cap.
Start the engine. The oil pressure
indicator light should go out within
5 seconds. If it does not, turn of f
the engine and check your work.
Let the engine run f or several
minutes, then check the drain bolt
and oil f ilter f or leaks.
5.
6.
7.
8.
9.
3.
4.
Changing the Oil and Filter
Maint enance173
NOTICE:
OIL FILTER
29 lbf·ft (39 N·m , 4.0 kgf·m)
5.1 US qt (4.8
) Improper disposal of engine
oil can be harmf ul to the environment.
If you change your own oil, please
dispose of the used oil properly. Put it
in a sealed container and take it to a
recycling center. Do not discard it in a
trash bin or dump it on the ground.

µµ
To thoroughly f lush the
transmission, the technician
should drain and ref ill it with
Honda ATF-Z1 (Automatic
Transmission Fluid), then drive
the vehicle f or a short distance.
Do this three times. Then drain
and ref ill the transmission a f inal
time.
Insert the dipstick all the way back
into the transmission.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to add f luid,
contact your Honda dealer. Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
The timing belt should be replaced
at the intervals shown in the
maintenance schedule. Replace the
belt at 60,000 miles (100,000 km) if
you regularly drive your vehicle in
one or more of these conditions:
In very high temperatures
(over 110°F, 43°C).
In very low temperatures
(under 20°F, 29°C).
Frequently tow a trailer.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole.
6.
Maint enance
Timing Belt
Dif f erential Oil
A utomatic T ransmission Fluid, Dif f erential Oil, T iming Belt
177
FILLER BOLT
CORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)

Let the vehicle sit f or a minute.
Open the hood, and check the oil
level (see page ). An engine
very low on oil can lose pressure
during cornering and other driving
maneuvers.
If necessary, add oil to bring the
level back to the full mark on the
dipstick (see page ).
Start the engine, and watch the oil
pressure light. If it does not go out
within ten seconds, turn off the
engine. There is a mechanical
problem that needs to be repaired
bef ore you can continue driving.
(Seeon page
).
This light should never
come on when the engine is
running. If it starts f lashing or stays
on, the oil pressure has dropped very
low or lost pressure. Serious engine
damage is possible and you should
take immediate action. Saf ely pull of f the road, and shut
of f the engine. Turn on the hazard
warning lights.
If the charging system
indicator comes on brightly
when the engine is running, the
battery is not being charged.
Immediately turn of f all electrical
accessories. Try not to use other
electrically operated controls such as
the power windows. Keep the engine
running; starting the engine will
discharge the battery rapidly.
Go to a service station or garage
where you can get technical
assistance.
1.
2.
3.
4.
171
127
208
L ow Oil Pressure Indicator
Emergency T owingCharging System Indicator
T aking Care of t he Unexpect ed
L ow Oil Pressure L ight, Charging System Indicator
206
NOTICE:
Running the engine with low
oil pressure can cause serious
mechanical damage almost immediately.
Turn of f the engine as soon as you can
saf ely get the vehicle stopped.

Î
................................
Cancel Button .117
............................
Capacities Chart .218
.............
Carbon Monoxide Hazard . 42
........................
Cargo, .131
Cassette Player ..............................................
Care .95
.....................................
Operation .98
..............
CAUTION, Explanation of . ii
...........................................
CD Care .95
.....................................
CD Changer .94
.........
CD Changer Error Message . 97
.........................................
CD Player .93
.............
CD Player Error Message . 96
........................
Certif ication Label .216
...................................
Chains, .192
....................
Changing a Flat Tire .197
Change Oil ........................................
How to .172
.............................
When to .164, 165
...
Charging System Indicator . 48,206
............
Checklist, Bef ore Driving . 136
..................
Childproof Door Locks . 65
.....................................
Child Saf ety .25
..............................
Booster Seats .39 ...................................
Child Seats .30
.....
Important Saf ety Reminders . 25
..........................................
Inf ants .29
..........................
Larger Children .38
.........................................
LATCH .33
......................
Risks with Airbags .26
.............................
Small Children .30
.........................................
Tethers .37
.........
Where Should a Child Sit? . 26
Child Seats .........................................
LATCH .33
...........................
Lower Anchors .33
..........
Tether Anchorage Points . 37
.................
Climate Control System . 86
.........................
Clock, Setting the .103
..............................................
Clock .103
.....................
Code, Audio System .102
........................
CO in the Exhaust .223
............
Cold Weather, Starting in . 137
.......................
Compact Spare .196
...................
Console Compartment . 77
...............
Consumer Inf ormation . 230
.............
Controls, Instruments and . 45
Coolant ........................................
Adding .174
....................................
Checking .127 .........................
Proper Solution .174
...................
Temperature Gauge . 55
Crankcase Emissions Control ........................................
System .223
................
Cruise Control Indicator . 51
............
Cruise Control Operation . 116
.....................................
Cup Holders .77
....
Customer Service Inf ormation . 230
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 46
................
Daytime Running Lights . 59
Daytime Running Lights .......................................
Indicator .51
.................................
Dead Battery .202
............
Def ects, Reporting Saf ety . 232
................
Def ogger, Rear Window . 60
..........
Def rosting the Windows . 83,85
....................................
Dimensions .218
...............
Dimming the Headlights . 58
Dipstick ..........
Automatic Transmission . 176
..................................
Engine Oil .127
..........................
Directional Signals .58
how to carry
tires tire
Index
C
D
II