2004 HONDA PILOT headlights

µµ µ
µ
µ
µ µ
Youshouldcheckthefollowing
items at the specif ied intervals. If
you are unsure of how to perf orm
any check, turn to the appropriate
page listed.
Engine oil level Check every
time you fill the fuel tank. See
page .
Engine coolant level Check the
radiator reserve tank every time
you f ill the f uel tank. See page . Brakes Check the f luid level
monthly. See page .
Tires Check the tire pressure
monthly. Examine the tread f or
wear and foreign objects. See page
.
Automatic transmission Check
the f luid level monthly. See pages . Lights Check the operation of
the headlights, parking lights,
taillights, high-mount brake light,
and license plate lights monthly.
See page .
171
174
176 177 178
188
180
Maintenance Schedule
Maint enance
Owner’s Maintenance Checks
163

Theheadlightswereproperlyaimed
when your vehicle was new. If you
regularly carry heavy items in the
trunk, readjustment may be required.
Adjustments should be perf ormed by
a Honda dealer or other qualif ied
mechanic.
Your vehicle has halogen headlight
bulb. Handle it by its steel base and
protect the glass f rom contact with
your skin or hard objects. If you
touch the glass, clean it with
denaturedalcoholandacleancloth.
NOTE: Halogen headlight bulbs get
very hot when lit. Oil, perspiration,
or a scratch on the glass can cause
the bulb to overheat and shatter.Remove the electrical connector
f rom the bulb by pulling the
connector straight back.
Remove the rubber weather seal
by pulling on the tab.Unclip the end of the hold-down
wire f rom its slot. Pivot it out of
the way, and remove the bulb.
Insert the new bulb and make sure
it is right side up. The tabs on the
base f it into the indentations in the
headlight assembly. Pivot the hold-
down wire back in place, and clip
the end into the slot.
Reinstall the rubber seal and make
sure one of its arrow is pointing up.
Push the electrical connector onto
the new bulb.
1.
2. 3.
4.
5.
6.
Headlight A iming
Replacing a Headlight Bulb
Lights
Maint enance180
CONNECTOR
BULB

Diagnosing why your engine won’t
start f alls into two areas, depending
on what you hear when you turn the
key to START (III):You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run.
When you turn the ignition switch to
START (III), you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Check these things: Check the transmission interlock.
The transmission must be in Park
orNeutralorthestarterwillnot
operate.
Turn the ignition switch to ON (II).
Turn on the headlights and check
their brightness. If the headlights
are very dim or don’t light at all,
the battery is discharged. See
on page .
Turn the ignition switch to START
(III). If the headlights do not dim,
check the condition of the f uses. If
thefusesareOK,thereis
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem (see
on page ). If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is dis-
charged or the connections are
corroded. Check the condition of
the battery and terminal connec-
tions (see page ). You can
then try jump starting the vehicle
f rom a booster battery (see page
).
Are you using the proper starting
procedure? Ref er to on page .
In this case, the starter motor’s
speed sounds normal, or even f aster
than normal, when you turn the
ignition switch to START (III), but
the engine does not run.
202
208 193
202
137
T aking Care of t he Unexpect ed
Nothing Happens or the Starter
Motor Operates Very Slowly Jump Starting
Emergency T owing Starting the
Engine
T he Starter Operates Normally
If theEngineWon’tStart
201

If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pagesand , or the diagram on the
fuse box lid, which fuse or fuses
control that device. The diagram f or
theinteriordriver’ssidefuseboxis
on the kick panel below the f use box.
Check those f uses f irst, but check all
the f uses bef ore deciding that a
blown f use is the cause. Replace any
blown f uses, and check if the device
works.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box. Check each of the large f uses in
the primary under-hood f use box
by looking through the top at the
wise inside. Remove the screws
with a Phillips-head screwdriver.
Check the smaller f uses in the
under-hood f use box and all the
fuses in the interior fuse boxes by
pulling out each f use with the f use
puller provided in the primary
under-hood f use box.
Look f or a burned wire inside the
f use. If it is burned, replace it with
one of the spare f uses of the same
rating or lower.
1.
2. 3.
4.
5.
212 213
Checking and Replacing Fuses
T aking Care of t he Unexpect ed
Fuses
210
BLOWN BLOWN

µ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Specif ications
T echnical Inf ormation219
Lights
Battery
Fuses
Engine
Alignment
Tires
60 W/55 W
12 V
60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
T155/90D16 110M P235/70R16 104S 1°88’
0°50’ 0°50’
0.00 in (0.0 mm)
0.00 in (0.0 mm) 10.0 : 1
211.8 cu-in (3,471 cm
)
3.50 x 3.66 in (89.0 x 93.0 mm)
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V 12 V
12 V
12 V
5W
27 W/8 W
5W
21 W/5 W
21 W/5 W
21 CP (18 W)
5W
18 W
6.2 W
5W
1.1 W
3.8 W
12 V 65 AH/20 HR 14 V 12 V 12.4 W 1.4 W
Headlights
Front side marker lights
Front turn signal lights/
Parking lights
Rear side marker lights
Rear turn signal/hazard lights
Stop/Taillights
Backup lights
License plate lights
High-mount brake light
Individual map lights
Tailgate light
Vanity mirror light
Door (Courtesy) light
Grabrail lights
Console lights
Capacity Interior
Under-hood
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Water cooled 4-stroke SOHC,
V6 gasoline engine
Toe-in
Camber
Caster
Size
Pressure See page
213or the fuse label
attached to the dashboard.
See page 213or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 212or the fuse box
cover.
PZFR5F-11
PKJ16CR-L11
Front/Rear
Spare
Front/Rear
Spare Front
Rear
Front
Rear
Front
Driver’s side
Passenger’s side
(1157 NA)
(168)
(7443)
(7443) (921)
(168)
(921)
(204)
(HB2)
(168)
Front
Rear
Front
Rear
Front NGK:
DENSO:

CONT INUED
BatteryCharging System ...........................
Indicator .48, 206
............................
Jump Starting .202
..............................
Maintenance .193
............................
Specif ications .219
..............................
Bef ore Driving .123
....................................
Belts,Seat .8,16
...........................
Beverage Holders .77
..................................
Booster Seats .39 Brakes
...........
Anti-lock System (ABS) . 145
.............
Break-in, New Linings . 124
...........................................
Fluid .178
....................
Bulb Replacement .182
.........................................
Parking .75
.................
System Indicator . 49,208
........................
Wear Indicators .145
.............................
Braking System .144
.................
Break-in, New Vehicle . 124
..
Brightness Control, Instruments . 59
........................
Brights, Headlights .58
Bulb Replacement ..............................
Brake Lights .182
................
Front Parking Lights . 181
........
Front Side Marker Lights . 183
.................................
Headlights .180
........
High-mount Brake Lights . 182
.................................
Rear Bulbs .182
............................
Specif ications .219
.............
Turn Signal Light . 181,182
..............................
Bulbs, Halogen .180
...
Accessories and Modif ications . 129
ACCESSORY (Ignition Key .......................................
Position) .64
..............
Accessory Power Sockets . 77
....................
Additives, Engine Oil . 172
...............................
Airbag (SRS) .9, 19
.....
Airbags, Additional Infomation . 19
...
Additional Safety Precautions . 24
.............................
Airbag Service .24
How the Side Airbag Of f ......................
Indicator Works .23
..
How the SRS Indicator Works . 23
How Your Front Airbags .........................................
Work .20
...
How Your Side Airbags Work . 22
........................
SRS Components .19
................
Air Conditioning System . 82
.......................
Rear A/C Control .87
.......................
Air Pressure, Tires .188
......................................
Antif reeze .174
Anti-lock Brakes (ABS) ....................
Indicator Light .49, 146
...................................
Operation .145
..............
Anti-thef t, Audio System . 102 .
Anti-thef t Steering Column Lock . 64
..................................
Audio System .88
...
Automatic Seat Belt Tensioners . 18
...
Automatic Lighting Off Feature . 58
.............
Automatic Speed Control . 116
..............
Automatic Transmission . 138
..........................
Capacity, Fluid .218
...............
Checking Fluid Level . 176
.......................................
Shif ting .138
.
Shif t Lever Position Indicator . 138
................
Shif t Lever Positions . 139
....................
Shif t Lock Release . 141
Index
A
B
I

Î
................................
Cancel Button .117
............................
Capacities Chart .218
.............
Carbon Monoxide Hazard . 42
........................
Cargo, .131
Cassette Player ..............................................
Care .95
.....................................
Operation .98
..............
CAUTION, Explanation of . ii
...........................................
CD Care .95
.....................................
CD Changer .94
.........
CD Changer Error Message . 97
.........................................
CD Player .93
.............
CD Player Error Message . 96
........................
Certif ication Label .216
...................................
Chains, .192
....................
Changing a Flat Tire .197
Change Oil ........................................
How to .172
.............................
When to .164, 165
...
Charging System Indicator . 48,206
............
Checklist, Bef ore Driving . 136
..................
Childproof Door Locks . 65
.....................................
Child Saf ety .25
..............................
Booster Seats .39 ...................................
Child Seats .30
.....
Important Saf ety Reminders . 25
..........................................
Inf ants .29
..........................
Larger Children .38
.........................................
LATCH .33
......................
Risks with Airbags .26
.............................
Small Children .30
.........................................
Tethers .37
.........
Where Should a Child Sit? . 26
Child Seats .........................................
LATCH .33
...........................
Lower Anchors .33
..........
Tether Anchorage Points . 37
.................
Climate Control System . 86
.........................
Clock, Setting the .103
..............................................
Clock .103
.....................
Code, Audio System .102
........................
CO in the Exhaust .223
............
Cold Weather, Starting in . 137
.......................
Compact Spare .196
...................
Console Compartment . 77
...............
Consumer Inf ormation . 230
.............
Controls, Instruments and . 45
Coolant ........................................
Adding .174
....................................
Checking .127 .........................
Proper Solution .174
...................
Temperature Gauge . 55
Crankcase Emissions Control ........................................
System .223
................
Cruise Control Indicator . 51
............
Cruise Control Operation . 116
.....................................
Cup Holders .77
....
Customer Service Inf ormation . 230
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 46
................
Daytime Running Lights . 59
Daytime Running Lights .......................................
Indicator .51
.................................
Dead Battery .202
............
Def ects, Reporting Saf ety . 232
................
Def ogger, Rear Window . 60
..........
Def rosting the Windows . 83,85
....................................
Dimensions .218
...............
Dimming the Headlights . 58
Dipstick ..........
Automatic Transmission . 176
..................................
Engine Oil .127
..........................
Directional Signals .58
how to carry
tires tire
Index
C
D
II

.................................................
Fuel .124
......................
Fill Door and Cap .125
...........................................
Gauge .54
................
Octane Requirement . 124
........................
Reserve Indicator .51
........................
Tank, Filling the .125
.....................
Fuses, Checking the .210
...............
Gas Mileage, Improving . 128
.........................................
Gasoline .124
...............
Fuel Reserve Indicator . 51
...........................................
Gauge .54
................
Octane Requirement . 124
........................
Tank, Filling the .125
................
Gas Station Procedures . 125
Gauges ...
Engine Coolant Temperature . 55
...............................................
Fuel .54
GAWR (Gross Axle Weight .......................................
Rating) .148
GCWR (Gross Combined Weight .......................................
Rating) .148
............
Gearshif t Lever Positions . 139
........................................
Glove Box .78 GVWR (Gross Vehicle Weight
.......................................
Rating) .148
.............
Halogen Headlight Bulbs . 180
.................
Hazard Warning Button . 59
........................................
Headlights .58
........................................
Aiming .180
..............
Automatic Lighting Off . 58
............
Daytime Running Lights . 59
..................
High Beam Indicator . 51
...........
High Beams, Turning on . 58
............
Low Beams, Turning on . 58
.........................
Reminder Chime .58
........
Replacing Halogen Bulbs . 180
...................................
Turning on .58
...................................
Headphones .113
..............................
Head Restraints .72
.................................
Heated Mirror .74
.....................................
Heater, Seat .67
.......................
Heating and Cooling .82
.............
High Altitude, Starting at . 137
.................
High-Low Beam Switch . 58
..............
High-mount Brake Light . 182HomeLink Universal
................................
Transceiver .118
.......................
Hood, Opening the .126
..................................................
Horn .56
...
Identif ication Number, Vehicle . 216
Ignition ..............................................
Keys .62
...........................................
Switch .64
............
Timing Control System . 224
........................
Immobilizer System .62
.........
Important Safety Precautions . 6
Indicators .......................
A/T Temperature .52
...............
ABS (Anti-lock Brake) . 49
Brake (Parking and Brake ....................................
System) .49
.................................
Brake Lamp .50
........................
Charging System .48
.............................
Cruise Control .51
DRL (Daytime Running ......................................
Lights) .51
...................................
High Beam .51
........
Key (Immobilizer System) . 49
Index
G H
I
IV