2004 HONDA PILOT oil temperature

Your vehicle’s exhaust contains
carbon monoxide gas. You should
have no problem with carbon
monoxide entering the vehicle in
normal driving if you maintain your
vehicle properly.High levels of carbon monoxide can
collect rapidly in enclosed areas,
such as a garage. Do not run the
engine with the garage door closed.
Even with the door open, run the
engine only long enough to move the
vehicle out of the garage.
Have the exhaust system inspected
f or leaks whenever:
The vehicle is raised f or an oil
change.
You notice a change in the sound
of the exhaust.
The vehicle was in an accident
that may have damaged the under-
side. With the tailgate open, air flow can
pull exhaust gas into your vehicle’s
interior and create a hazardous
condition. If you must drive with the
tailgate open, open all the windows
and set the heating and cooling
system/climate control system as
shown below.
If you must sit in your parked vehicle,
even in an unconf ined area, with the
engine running, adjust the heating
and cooling system/climate control
system as f ollows:
Select the Fresh Air mode.
Select the mode.
Turn the f an on high speed.
Set the temperature control to a
comfortable setting.
1.
2.
3.
4.
Carbon Monoxide Hazard
Driver and Passenger Saf ety42
Carbon monoxide gas is toxic.
Breathing it can cause
unconsciousness and even kill
you.
Avoid any enclosed areas or
activities that expose you to
carbon monoxide.

Î
ÎCONT INUEDThe U.S. instrument panel is shown. Dif f erences f or the Canadian models are noted in the text.
Instrument Panel
Inst rument s and Cont rols47
SIDE AIRBAG
CUTOFF INDICATOR
MALFUNCTION INDICATOR
LAMP
LOW OIL PRESSURE
INDICATOR
CHARGING SYSTEM
INDICATOR
DOOR AND TAILGATE
OPEN MONITOR
SUPPLEMENTAL RESTRAINT
SYSTEM INDICATOR
VTM- 4INDICATOR
IMMOBILIZER SYSTEM
INDICATORHIGH BEAM
INDICATOR
A/T TEMPERATURE
INDICATOR MAINTENANCE
REQUIRED
INDICATOR
CRUISE CONTROL
INDICATOR
BRAKE LAMP INDICATOR
ANTI-LOCK BRAKE SYSTEM
INDICATOR LOW FUEL
INDICATOR
OUTSIDE
TEMPERATURE
DISPLAY
PARKING BRAKE
AND BRAKE SYSTEM
INDICATOR
SEAT BELT REMINDER INDICATOR
(P.49)
(P.48) (P.48)
(P.48)
(P.48)(P.50)
(P.48)
(P.52) (P.
48)
(P.50)
(P. 51)
(P.51)
(P. 55)
(P. 53)
(P.49)
(P.52)
(P.51)
(P.49)

µ
ÌÌ
ÎÎÎ
ÌÎ
Follow the Severe Maintenance
Schedule if you drive your vehicle
MAINLY under one or more of the
f ollowing conditions:
Driving in extremely hot [over 90°F
(32°C)] conditions.
Extensive idling or long periods of
stop and go driving, such as a taxi or
a commercial delivery vehicle.
T railer towing, driving with a roof
rack, or driving in mountainous
conditions. Follow the
Maintenance Schedule f or Severe
Conditions. Driving on muddy, dusty, or de-iced
roads.
Drivinglessthan5miles(8km)per
trip or, in f reezing temperatures,
driving less than 10 miles (16 km) per
trip.
Maint enance
Canadian Owners
165
7.5
12 Check oil and coolant at each fuel stop
Check inflation and condition once a month
Every 3,750 miles (6,000 km) or every 6 months, whichever comes first
Every 7,500 miles (12,000 km)
Every 7,500 miles (12,000 km) or every 6 months, whichever comes first
( (O
O r
re
ev
ve
er
ry
y 1
1y
ye
ea
ar
r,
, w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
(
( O
O r
re
ev
ve
er
ry
y 2
2y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
Every 15,000 miles (24,000 km) (Use normal schedule
except in dusty condition)
(
(O
O t
th
h e
er
rw
w i
is
se e a
ad
d j
ju
u s
stt o
o n
nl
ly
y i
if
f n
n o
oi
is
sy y )
)
(
( O
O r
re
ev
ve
er
ry
y 7
7y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
miles x 1,000
km x 1,000
( (O
O r
re
ev
ve
er
ry
y 2
2y
ye
ea
ar
rs
s, , w
w h
hi
ic
ch h e
ev
ve
er
r c
coo m
m e
es
s f
fi
ir
r s
st t)
)
15
24 30
4845
7260
9675
120 90
144 105
168120
192 150
240
Service the items listed at the indicated distance (or time, if given).
135
216
Check engine oil and coolant
Check tires
Replace engine oil filter
Rotate tires (follow pattern on page 190)
Check front and rear brake wear
Inspect the following items: Tie-rod ends, steering gearbox, and boots
Suspension components
Driveshaft boots
Check parking brake adjustment
Lubricate all hinges, locks and latches
Inspect the following items: Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Lights and controls/vehicle underbody
Inspect drive belts
Replace dust and pollen filter
Replace air cleaner element
Replace spark plugs
Inspect valve clearance
Replace automatic transmission fluid
Replace VTM-4 rear differential fluid
Inspect idle speed
Replace timing belt and inspect water
pump
Replace engine coolant
Replace brake fluid Every 3 years (independent of mileage)
120,000 miles (192,000 km) or 10 years, then every
60,000 miles (96,000 km) or 5 years
Exhaust system , Fuel lines and connections
1
2, 3
,4
Maintenance Severe for Severe Conditions

Oil is a major contributor to your
engine’s perf ormance and longevity.
Always use a premium-grade 5W-20
detergent oil displaying the API
Certif ication Seal. This seal indicates
the oil is energy conserving, and that
it meets the American Petroleum
Institute’s latest requirements.Honda Motor Oil is the pref erred
5W-20 lubricant f or your vehicle. It is
highly recommended that you use
Honda Motor Oil in your vehicle f or
optimum engine protection. Make
sure the API Certif ication Seal says
‘‘For Gasoline Engines’’.
The oil viscosity or weight is
provided on the container’s label.
5W-20 oil is f ormulated f or year-
round protection of your Honda to
improve cold weather starting and
f uel economy.
Unscrew and remove the engine oil
fill cap on top of the valve cover.
Pour in the oil slowly and caref ully so
you do not spill. Clean up any spills
immediately. Spilled oil could
damage components in the engine
compartment. Install the engine oil
f ill cap and tighten it securely. Wait a
f ew minutes and recheck the oil level.
Do not f ill above the upper mark; you
could damage the engine. Recommended Engine Oil
A dding Engine Oil
Maint enance171
API CERTIFICATION SEAL
Ambient Temperature
ENGINE OIL FILL CAP

Run the engine until it reaches
normal operating temperature,
then shut it off.
Open the hood and remove the
engine oil f ill cap. Remove the oil
drain bolt and washer f rom the
bottom of the engine. Drain the oil
into an appropriate container.
Always change the oil and f ilter
according to the recommendations in
the maintenance schedule. The oil
and f ilter collect contaminants that
can damage your engine if they are
not removed regularly.
You may use a synthetic motor oil if
it meets the same requirements
given f or a conventional motor oil: it
displays the API Certif ication Seal
and it is the proper weight. You must
f ollow the oil and f ilter change
intervals given on the maintenance
schedule.
Your Honda does not require any oil
additives. Additives may adversely
af f ect your engine’s or transmission’s
perf ormance and durability. Changing the oil and f ilter requires
special tools and access f rom
underneath the vehicle. The vehicle
should be raised on a service station-
type hydraulic lif t f or this service.
Unless you have the knowledge and
proper equipment, you should have
this maintenance done by a skilled
mechanic.
1.
2.
Changing the Oil and Filter
Synthetic Oil
Engine Oil A dditives
A dding Engine Oil, Changing the Oil and Filter
Maint enance172
DRAIN BOLT
WASHER

µµ
To thoroughly f lush the
transmission, the technician
should drain and ref ill it with
Honda ATF-Z1 (Automatic
Transmission Fluid), then drive
the vehicle f or a short distance.
Do this three times. Then drain
and ref ill the transmission a f inal
time.
Insert the dipstick all the way back
into the transmission.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to add f luid,
contact your Honda dealer. Put a new washer on the f iller bolt,
then reinstall the f iller bolt and
tighten it securely. Tightening
torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
The timing belt should be replaced
at the intervals shown in the
maintenance schedule. Replace the
belt at 60,000 miles (100,000 km) if
you regularly drive your vehicle in
one or more of these conditions:
In very high temperatures
(over 110°F, 43°C).
In very low temperatures
(under 20°F, 29°C).
Frequently tow a trailer.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add
VTM-4 Dif f erential Fluid until it
starts to run out of the hole.
6.
Maint enance
Timing Belt
Dif f erential Oil
A utomatic T ransmission Fluid, Dif f erential Oil, T iming Belt
177
FILLER BOLT
CORRECT LEVEL
33 lbf·ft (45 N·m , 4.6 kgf·m)

Î
................................
Cancel Button .117
............................
Capacities Chart .218
.............
Carbon Monoxide Hazard . 42
........................
Cargo, .131
Cassette Player ..............................................
Care .95
.....................................
Operation .98
..............
CAUTION, Explanation of . ii
...........................................
CD Care .95
.....................................
CD Changer .94
.........
CD Changer Error Message . 97
.........................................
CD Player .93
.............
CD Player Error Message . 96
........................
Certif ication Label .216
...................................
Chains, .192
....................
Changing a Flat Tire .197
Change Oil ........................................
How to .172
.............................
When to .164, 165
...
Charging System Indicator . 48,206
............
Checklist, Bef ore Driving . 136
..................
Childproof Door Locks . 65
.....................................
Child Saf ety .25
..............................
Booster Seats .39 ...................................
Child Seats .30
.....
Important Saf ety Reminders . 25
..........................................
Inf ants .29
..........................
Larger Children .38
.........................................
LATCH .33
......................
Risks with Airbags .26
.............................
Small Children .30
.........................................
Tethers .37
.........
Where Should a Child Sit? . 26
Child Seats .........................................
LATCH .33
...........................
Lower Anchors .33
..........
Tether Anchorage Points . 37
.................
Climate Control System . 86
.........................
Clock, Setting the .103
..............................................
Clock .103
.....................
Code, Audio System .102
........................
CO in the Exhaust .223
............
Cold Weather, Starting in . 137
.......................
Compact Spare .196
...................
Console Compartment . 77
...............
Consumer Inf ormation . 230
.............
Controls, Instruments and . 45
Coolant ........................................
Adding .174
....................................
Checking .127 .........................
Proper Solution .174
...................
Temperature Gauge . 55
Crankcase Emissions Control ........................................
System .223
................
Cruise Control Indicator . 51
............
Cruise Control Operation . 116
.....................................
Cup Holders .77
....
Customer Service Inf ormation . 230
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 46
................
Daytime Running Lights . 59
Daytime Running Lights .......................................
Indicator .51
.................................
Dead Battery .202
............
Def ects, Reporting Saf ety . 232
................
Def ogger, Rear Window . 60
..........
Def rosting the Windows . 83,85
....................................
Dimensions .218
...............
Dimming the Headlights . 58
Dipstick ..........
Automatic Transmission . 176
..................................
Engine Oil .127
..........................
Directional Signals .58
how to carry
tires tire
Index
C
D
II

.....................................
Fan, Interior .82
Features, Comfort and ................................
Convenience .81
....................
Filling the Fuel Tank . 125
Filters ...............................................
Oil .172
.............
Flashers, Hazard Warning . 59
...................
Flat Tire, Changing a . 197
Fluids ..........
Automatic Transmission . 176
..........................................
Brake .178
..........................
Power Steering .179
..................
Windshield Washer . 175
FM Stereo Radio .....................................
Reception .91
...................
Folding the Third Seat . 71
..........................
Four-way Flashers .59
............................
Front Airbags .10, 19
Front Seat ................................
Adjusting .68, 69
.........................................
Heaters .67
.....................................
Airbags .9, 19
........
Disc Brake Wear Indicators . 145
.....................
Disposal of Used Oil .173
Doors ..............
Locking and Unlocking . 65
....................
Lockout Prevention . 65
......................
Power Door Locks .65
..........
DOT Tire Quality Grading . 220
...........
Driver and Passenger Safety . 5
...........................................
Driving .135
....................................
Economy .128
...................................
DVD Player .104
........
DVD Player Error Message . 112
..............................
Economy, Fuel .128
Emergencies ............................
Jump Starting .202
.......................................
Towing .208
..............
Hazard Warning .59
............
Emergencies on the Road . 195
.............
Battery, Jump Starting . 202
...........
Brake System Indicator . 208
................
Changing a Flat Tire . 197
.....
Charging System Indicator . 206
..................
Checking the Fuses . 210 .....
Low Oil Pressure Indicator . 206
...
Malf unction Indicator Lamp . 207
..................
Overheated Engine . 204
...........................
Emergency Brake .75
......................
Emergency Flashers .59
......................
Emergency Towing .208
.......................
Emissions Controls .223
.............
Emissions Testing, State . 226
Engine ....
Coolant Temperature Gauge . 55
.............................. 137
Malf unction Indicator ................................
Lamp .48, 207
........
Oil Pressure Indicator . 48,206
..............
Oil, What Kind to Use . 171
...............................
Overheating .204
............................
Specif ications .219
............................
Speed Limiter .140
.......................................
Starting .137
.
Evaporative Emissions Controls . 223
...............................
Exhaust Fumes .42
Exhaust Gas Recirculation ........................................
System .224
Expectant Mothers, Use of Seat ........................................
Belts by .15
CONT INUED
Button If it won’t start
Index
E F
III