2004 HONDA INSIGHT fuse

This section covers the more
common problems that motorists
experience with their vehicles. It
gives you inf ormation about how to
safely evaluate the problem and what
to do to correct it. If the problem has
stranded you on the side of the road,
you may be able to get going again.
If not, you will also f ind instructions
on getting your vehicle towed.......................
Compact Spare Tire .164
....................
Changing a Flat Tire .165
.............
If the Engine Won’t Start . 171
................................
Jump Starting .173
..............
If the Engine Overheats . 175
.........
Low Oil Pressure Indicator . 177
..........
Charging System Indicator . 178
.......
Malf unction Indicator Lamp . 178
...............
Brake System Indicator . 180
......................
Emergency Towing .181
......
If Your Vehicle Gets Stuck . 182
..............................................
Fuses .183
..............................
Fuse Locations .186
Taking Care of the Unexpected
T aking Care of t he Unexpect ed163

The interior f use is underneath the
dashboard on the driver’s side.
Remove the storage pocket by
swinging the lid down, pushing up,
and pulling it straight out of its
hinges. The vehicle’s f uses are located in
two f use boxes.The under-hood f use box is in the
engine compartment. To open it,
pushthetabsasshown.If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pages
and , or the diagram on the
f use box lid, which f use or f uses
control that device. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
the cause. Replace any blown f uses,
and check if the device works.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box.
1.
2. 186 187
CONT INUED
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed183
INTERIOR
TABUNDER-HOOD

Check each of the large f uses in
the under-hood f use box by
looking through the top at the wire
inside. Remove the screws with a
phillips-head screwdriver.Check the smaller f uses in the
under-hood f use box and all the
fuses in the interior fuse box by
pulling out each f use with the f use
puller provided in the under-hood
fuse box.Look f or a burned wire inside the
f use. If it is burned, replace it with
one of the spare f uses of the same
rating or lower.
3.
4.5.
Fuses
T aking Care of t he Unexpect ed184
FUSE
BLOWN FUSE PULLER
BLOWN

If you cannot drive the vehicle
without f ixing the problem, and you
do not have a spare fuse, take a fuse
of the same rating or a lower rating
f rom one of the other circuits with
the f use puller provided in the under-
hood f use box. Make sure you can
do without that circuit temporarily
(such as the accessory power socket
or radio).
If you replace the blown f use with a
spare f use that has a lower rating, it
might blow out again. This does not
indicate anything wrong. Replace the
f use with one of the correct rating as
soon as you can.If the replacement fuse of the
same rating blows in a short time,
there is probably a serious
electrical problem in your vehicle.
Leave the blown fuse in that
circuit, and have your vehicle
checked by a qualif ied mechanic.If the radio f use is removed, the
audio system will disable itself . The
nexttimeyouturnontheradioyou
will see ‘‘COdE’’ in the f requency
display. Use the Preset buttons to
enter the f ive-digit code (see page
).
6. 88
Fuses
T aking Care of t he Unexpect ed185
NOTICE:
Replacing a f use with one
that has a higher rating greatly
increases the chances of damaging the
electrical system. If you do not have a
replacement f use with the proper rating
f or the circuit, install one with a lower
rating.

µµ
Î Î
Î
No. Amps. Circuits Protected
No.No.
Amps. Amps.
Circuits Protected Circuits Protected
1
2
3
4
5
6
7
8
9
10 10 A
15 A
20 A
7.5 A
7.5 A
7.5 A 15 A
20 A
7.5 A 20 A SRS
Fuel Pump, SRS
Front Wiper
FI-ECU
Turn Light
Meter
IG Coil
Power Window, Passenger
Starter Signal
Power Window, Driver 11
12
13
14
15
16
17
18
19 20
21
22
23
24
25
26
27
7.5 A 10 A
20 A
10 A
7.5 A
7.5 A
7.5 A
7.5 A 10 A
10 A
20 A
7.5 A
7.5 A
10 A
7.5 A
ACC Radio
ACC Socket
Not used
LAF Heater
Small Light
Air Conditioning, R/C
Mirror
Daytime Running Light
Back Up Light
Interior Light Radio
Daytime Running Light
Door Lock
Tailgate Lock
IMA
Not used
Rear Wiper
Back Light
: Canadian model only
Fuse Locations
T aking Care of t he Unexpect ed186
INTERIOR FUSE BOX

µ
µ
No.
No. Circuits Protected
Circuits Protected Amps.
Amps.
11
12
13
14
15
16
17
18
19
20
1
2
3
4
5
6
7
8
9
10 Cooling Fan
Heater Motor
Rear Defroster
ABS F/S
Power Steering
Back Up, ACC
Power Window
IMA ECU
Condenser Fan
Spare Fuse
IG1 Main
Battery
ABS Motor
Hazard
IMA
Horn Stop
Fuel Pump
Lef t Headlight
Not used
Right Headlight 30 A
40 A
30 A
20 A
40 A
30 A
40 A
7.5 A 20 A
50 A
80 A
30 A
10 A
15 A
10 A
15 A
15 A
15 A
Fuse Locations
T aking Care of t he Unexpect ed187
UNDER-HOOD FUSE BOX

µµµ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
T echnical Inf ormation
Specif ications
193
Air Conditioning
Lights
12 Volt Battery Alignment
Tires
Fuses
HFC-134a (R-134a)
17.6 19.4 oz (500 550 g) SP-10
12 V 60/55 W (HB2) 0.00 in (0.0 mm)
0.12 in (3.0 mm)
0°1°
2°
P165/65R14 78S
T115/70D14 88M
12 V 21 W
12 V 5 W
12 V 12 V
21/5 W
21 W
12 V 18 W
12 V
12 V 5W
5W
12 V
12 V
5W
3.4 W
12V 27Ah/5HR 30 Ah/5 HR
12 V
Refrigerant type
Charge quantity
Lubricant type
Headlights (HI/LO)
Front turn signal lights
Front parking lights
Side marker lights
Rear turn signal lights
Brake/Taillights
Back-up lights
Trunk light
License plate light
Interior light
Capacity
Toe-in
Camber
Caster
Size
Pressure
Interior
Under-hood
See page
187or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 188or the fuse box
cover.
Front
Rear
Front
Rear
Front
Front/Rear
Spare
Front
Rear
Spare
38 psi (260 kPa)
35 psi (240 kPa)
60 psi (420 kPa)
U.S. model M/T
CVT

Î
.................................
Chains, Tires .159
....................
Charge/Assist Gauge .51
Changing Oil ........................................
How to .134
......................................
When to .127
....................
Changing a Flat Tire .165
...
Charging System Indicator . 42,178
............
Checklist, Bef ore Driving . 106
.....................................
Child Saf ety .23
..................................
Booster Seats .33
.......................................
Child Seats .28
.........
Important Saf ety Reminders . 26
..............................................
Inf ants .24
................................
Large Children .32
..........................
Risks with Airbags .24
.................................
Small Children .27
.............................................
Tethers .31
.............
Where Should a Child Sit? . 23
Child Seats ..........
Tether Anchorage Points . 31
.................................................
Clock .89
...................................
Clutch Fluid .143
........................
CO in the Exhaust .197
............
Cold Weather, Starting in . 107
......................
Compact Spare Tire .164
...............
Consumer Inf ormation . 202.............
Controls, Instruments and . 39
Coolant ........................................
Adding .137
......................................
Checking .96
.........................
Proper Solution .137
...................
Temperature Gauge . 47
Crankcase Emissions Control ........................................
System .197
.....................................
Cup Holders .69
.....................
Current Fuel Mileage .48
.............
Customer Service Of f ice . 202
................................
Economy, Fuel .97
..................................
Emergencies .163
.............
Battery, Jump Starting . 173
...........
Brake System Indicator . 180
................
Changing a Flat Tire . 165
.....
Charging System Indicator . 178
..................
Checking the Fuses . 184
.............
Hazard Warning Button . 55
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 40
................
Daytime Running Lights . 54
Daytime Running Lights .......................................
Indicator .44
.................................
Dead Battery .173
............
Def ects, Reporting Saf ety . 204
..........................
Def og and Def rost .75
................
Def ogger, Rear Window . 56
................
Def rosting the Windows . 75
....................................
Dimensions .192
...............
Dimming the Headlights . 54Dipstick
....................................
Engine Oil .95
..........................
Directional Signals .54
........
Disc Brake Wear Indicators . 119
.....................
Disposal of Used Oil .136
..................
Display Change Button . 47
Doors ..............
Locking and Unlocking . 60
..........
DOT Tire Quality Grading . 194
Downshif ting, 5-speed Manual
.............................
Transmission .108
...........
Driver and Passenger Safety . 5
...........................................
Driving .105
......................................
Economy .97
..................
Dust and Pollen Filter . 150
Index
D
E
II