2004 HONDA INSIGHT headlights

Open the hood.
To change the headlight bulb on
the driver’s side, remove the
engine coolant reservoir tank by
pulling it out of its holder.
Your vehicle has halogen headlight
bulbs, one on each side. When
replacing a bulb, handle it by its steel
base and protect the glass from
contactwithyourskinorhard
objects. If you touch the glass, clean
it with denatured alcohol and a clean
cloth.
Theheadlightswereproperlyaimed
when your vehicle was new. If you
regularly carry heavy items in the
cargo area, readjustment may be
required. Adjustments should be
perf ormed by a Honda dealer or
other qualif ied mechanic.
1.
Lights
Maint enance
Replacing a Headlight Bulb
Headlight A iming
144
NOTICE:
HOLDER
Halogen headlight bulbs get
very hot when lit. Oil, perspiration, or a
scratch on the glass can cause the bulb
to overheat and shatter.

CONT INUED
Remove the socket from the
headlight assembly by turning it
one-quarter turn counterclockwise.
Pull the bulb straight out of its
socket.
Install the new bulb into the
socket.
Unclip the end of the hold-down
wire f rom its slot. Pivot it out of
the way, and remove the bulb.
Insert the new bulb into the hole,
making sure the tabs are in their
slots. Pivot the hold-down wire
back in place, and clip the end into
the slot.
Install the rubber seal over the
back of the headlight assembly.
Make sure it is right side up; it is
marked ‘‘TOP’’.
Push the electrical connector onto
the tabs of the new bulb. Make
sure it locks in place.
Turn on the headlights to test the
new bulb.
(Driver’s side)
Reinstall the engine coolant
reserve tank.
Remove the electrical connector
f rom the bulb by squeezing the
connector on both sides to unlock
the tab. Pull the connector straight
off.
Remove the rubber weather seal
by pulling on the tab. 4.
5.
6.
7.
8.
1.
2.
3.
2.
3.
Lights
Maint enance
Replacing a Front Parking L ight
Bulb
145
BULB
CONNECTOR WEATHER SEAL
HOLD-DOWN WIRE

CONT INUED
Diagnosing why the engine won’t
start f alls into two areas, depending
on what you hear when you turn the
key to START (III):You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run. When you turn the ignition switch to
START (III), you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Check these things:
Check the transmission interlock.
If you have a manual transmission,
the clutch pedal must be pushed
all the way to the f loor or the
starter will not operate. With an
automatic transmission, it must be
in Park or Neutral.
Are you using a properly coded
key? An improperly coded key will
cause the immobilizer system
indicator in the instrument panel
to blink rapidly (see page ). Turn the ignition switch to ON (II).
Turn on the headlights, and check
their brightness. If the headlights
are very dim or don’t light at all,
the battery is discharged. See
on page .
Turn the ignition switch to START
(III). If the headlights do not dim,
check the condition of the f uses. If
the f uses are OK, there is
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem (see
on page ).
58 173
181
If theEngineWon’tStart
T aking Care of t he Unexpect ed
Nothing Happens or the Starter
Motor Operates Very Slowly Jump Starting
Emergency T owing
171

If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is
discharged or the connections are
corroded. Check the condition of the
battery and terminal connections
(see page ). You can then try
jump starting the vehicle from a
booster battery (see page ).In this case, the starter motor’s
speed sounds normal, or even f aster
than normal, when you turn the
ignition switch to START (III), but
the engine does not run.
Are you using the proper starting
procedure? Ref er to on page . If youfindnothingwrong,youwill
need a qualif ied technician to f ind
the problem. See
on page .
Do you have f uel? Check the f uel
gauge; the low f uel indicator may
not be working.
There may be an electrical
problem, such as no power to the
f uel pump. Check all the f uses
(see page ).
160
173 107
184 181
If theEngineWon’tStart
T aking Care of t he Unexpect ed
T he Starter Operates Normally
Starting the
Engine Emergency
Towing
172

The interior f use is underneath the
dashboard on the driver’s side.
Remove the storage pocket by
swinging the lid down, pushing up,
and pulling it straight out of its
hinges. The vehicle’s f uses are located in
two f use boxes.The under-hood f use box is in the
engine compartment. To open it,
pushthetabsasshown.If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pages
and , or the diagram on the
f use box lid, which f use or f uses
control that device. Check those
f uses f irst, but check all the f uses
bef ore deciding that a blown f use is
the cause. Replace any blown f uses,
and check if the device works.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box.
1.
2. 186 187
CONT INUED
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed183
INTERIOR
TABUNDER-HOOD

µµµ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
T echnical Inf ormation
Specif ications
193
Air Conditioning
Lights
12 Volt Battery Alignment
Tires
Fuses
HFC-134a (R-134a)
17.6 19.4 oz (500 550 g) SP-10
12 V 60/55 W (HB2) 0.00 in (0.0 mm)
0.12 in (3.0 mm)
0°1°
2°
P165/65R14 78S
T115/70D14 88M
12 V 21 W
12 V 5 W
12 V 12 V
21/5 W
21 W
12 V 18 W
12 V
12 V 5W
5W
12 V
12 V
5W
3.4 W
12V 27Ah/5HR 30 Ah/5 HR
12 V
Refrigerant type
Charge quantity
Lubricant type
Headlights (HI/LO)
Front turn signal lights
Front parking lights
Side marker lights
Rear turn signal lights
Brake/Taillights
Back-up lights
Trunk light
License plate light
Interior light
Capacity
Toe-in
Camber
Caster
Size
Pressure
Interior
Under-hood
See page
187or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 188or the fuse box
cover.
Front
Rear
Front
Rear
Front
Front/Rear
Spare
Front
Rear
Spare
38 psi (260 kPa)
35 psi (240 kPa)
60 psi (420 kPa)
U.S. model M/T
CVT

CONT INUED
.....
Accessories and Modif ications . 99
..................................
Accessories .99
............................
Modif ications .100
ACCESSORY (Ignition Key .......................................
Position) .59
...............
Accessory Power Socket . 69
....................
Additives, Engine Oil . 134
...............................
Airbag (SRS) .9, 19
................
Air Conditioning System . 72
.....................................
Usage .73, 76
.........................
Air Outlets (Vents) .74
.......................
Air Pressure, Tires .154
.........................
Normal Driving .155
.........................
Alcohol in Gasoline .92
......................................
Antif reeze .137
Anti-thef t Steering Column ..............................................
Lock .59
..................................
Audio System .78
........................
Auto Idle Stop .109, 116
..............
Automatic Transmission . 111
..........................
Capacity, Fluid .192
...............
Checking Fluid Level . 140
.......................................
Shif ting .112 Shif t Lever Position
...............................
Indicators .111
................
Shif t Lever Positions . 112
....................
Shif t Lock Release . 115
............................
Capacities Chart .192
.............
Carbon Monoxide Hazard . 36
....................
Cargo, How to Carry .102
.............................
Carrying Cargo .101
..............
CAUTION, Explanation of . ii
...........................................
CD Care .85
.............
CD Player Error Message . 86
.........
CD Changer Error Message . 87
.........................................
CD player .83
........................
Certif ication Label .190
Battery
Charging System ...........................
Indicator .42, 178
............................
Jump Starting .173
..............................
Maintenance .160
............................
Specif ications .193
................................
Bef ore Driving .91
....................................
Belts,Seat .8,17
.............................
Beverage Holder .69
..................................
Booster Seats .33
Brakes ................
Break-in, New Linings . 92
...........................................
Fluid .142
....................
Bulb Replacement .147
.........................................
Parking .67
.................
System Indicator . 43,180
........................
Wear Indicators .119
.............................
Braking System .119
...................
Break-in, New Vehicle . 92 ..
Brightness Control, Instruments . 55
........................
Brights, Headlights .54
Bulb Replacement ..........................
Back-up Lights .147
...............................
Brake Light .147
................
Front Parking Lights . 145
........
Front Side Marker Lights . 146
.................................
Headlights .144
............................
Specif ications .193
....................
Turn Signal Lights . 146
..............................
Bulbs, Halogen .144
Index
A
B
C
I

Î
.................................
Chains, Tires .159
....................
Charge/Assist Gauge .51
Changing Oil ........................................
How to .134
......................................
When to .127
....................
Changing a Flat Tire .165
...
Charging System Indicator . 42,178
............
Checklist, Bef ore Driving . 106
.....................................
Child Saf ety .23
..................................
Booster Seats .33
.......................................
Child Seats .28
.........
Important Saf ety Reminders . 26
..............................................
Inf ants .24
................................
Large Children .32
..........................
Risks with Airbags .24
.................................
Small Children .27
.............................................
Tethers .31
.............
Where Should a Child Sit? . 23
Child Seats ..........
Tether Anchorage Points . 31
.................................................
Clock .89
...................................
Clutch Fluid .143
........................
CO in the Exhaust .197
............
Cold Weather, Starting in . 107
......................
Compact Spare Tire .164
...............
Consumer Inf ormation . 202.............
Controls, Instruments and . 39
Coolant ........................................
Adding .137
......................................
Checking .96
.........................
Proper Solution .137
...................
Temperature Gauge . 47
Crankcase Emissions Control ........................................
System .197
.....................................
Cup Holders .69
.....................
Current Fuel Mileage .48
.............
Customer Service Of f ice . 202
................................
Economy, Fuel .97
..................................
Emergencies .163
.............
Battery, Jump Starting . 173
...........
Brake System Indicator . 180
................
Changing a Flat Tire . 165
.....
Charging System Indicator . 178
..................
Checking the Fuses . 184
.............
Hazard Warning Button . 55
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 40
................
Daytime Running Lights . 54
Daytime Running Lights .......................................
Indicator .44
.................................
Dead Battery .173
............
Def ects, Reporting Saf ety . 204
..........................
Def og and Def rost .75
................
Def ogger, Rear Window . 56
................
Def rosting the Windows . 75
....................................
Dimensions .192
...............
Dimming the Headlights . 54Dipstick
....................................
Engine Oil .95
..........................
Directional Signals .54
........
Disc Brake Wear Indicators . 119
.....................
Disposal of Used Oil .136
..................
Display Change Button . 47
Doors ..............
Locking and Unlocking . 60
..........
DOT Tire Quality Grading . 194
Downshif ting, 5-speed Manual
.............................
Transmission .108
...........
Driver and Passenger Safety . 5
...........................................
Driving .105
......................................
Economy .97
..................
Dust and Pollen Filter . 150
Index
D
E
II