2004 HONDA ELEMENT belt

To avoid loss of control or rollover,
be sure to f ollow all precautions and
recommendations.Be sure to store cargo properly
and do not exceed your Honda
cargo load limits (see pages and ).
Wherever you drive, make sure
you and your passengers always
wear seat belts.
Keep your speed low, and never
go faster than the conditions allow.
It’s up to you to continually assess
the situation and drive within the
limits.
Your vehicle has been designed
primarily f or use on pavement. But
its higher ground clearance allows
you to occasionally travel on unpaved
roads, to campgrounds, picnic sites,
and similar locations. It is not
designed f or trail-blazing, mountain
climbing, or other challenging of f -
road activities.
If you decide to drive on unpaved
roads, you will f ind that it requires
somewhat dif f erent driving skills.
Your vehicle will also handle
somewhat dif f erently than it does on
pavement. So be sure to read this
owner’s manual, pay special attention
to the precautions and tips in this
section, and get acquainted with
your vehicle before you leave the
pavement.
118 136
Driving
General Inf ormation
Important Saf ety Precautions
Of f -Highway Driving Guidelines
143
Improperly operating this
vehicle on or off-pavement can
cause an accident or rollover in
which you and your passengers
could be seriously injured orkilled.
Follow all instructions and
guidelines in the owner’smanual.
Keep your speed low and
don’t drive faster than
conditions permit.
—
—y

y
(+
y
y

This section explains the importance
of keeping your vehicle well
maintained and why you should
f ollow basic maintenance saf ety
precautions.
If you have the skills and tools to per-
f orm more complex maintenance
tasks on your Honda, you may want
to purchase the Service Manual. See
page f or inf ormation on how to
obtain a copy, or see your Honda
dealer.
This section also includes
Maintenance Schedules f or normal
driving and severe driving conditions,
a Maintenance Record, and instruc-
tions f or simple maintenance tasks
you may want to take care of
yourself .
......................
Maintenance Saf ety . 148
.................
Maintenance Schedule . 149
....................
Maintenance Record . 154
..............................
Fluid Locations . 156
........................
Adding Engine Oil . 157
.........
Changing the Oil and Filter . 158
..............................
Engine Coolant . 160
....................
Windshield Washers . 161
.......................
Transmission Fluid . 162
................
Brake and Clutch Fluid . 164
....................
Power Steering Fluid . 165
............
Cleaning the Body Panels . 165
.............................................
Lights . 166
.......................................
Seat Belts . 170
..................
Dust and Pollen Filter . 170
.................................
Wiper Blades . 171
...............................................
Tires . 172
...................
Checking the Battery . 177
.............................
Vehicle Storage . 178
217
Maintenance
Maint enance147
—
—y

y
(+
y
y

ÎÌ Ì
Ì
Î
Follow the Normal Maintenance
Schedule if the severe driving
conditions specif ied in the Severe
Conditions Maintenance Schedule on
the next page do not apply.
NOT E: If you only OCCASIONALLY
drive under a ‘‘severe’’ condition, you
should f ollow the Normal Conditions
Maintenance Schedule.
Maint enance
152
miles x 1,000
km x 1,000
Service the items listed at the indicated distance (or time, if given).
Every 3 years (independent of mileage)
((OOrreevveerryy66yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))
((OOtthheerrwwiisseeaaddjjuussttoonnllyyiiffnnooiissyy))
Every 10,000 miles (16,000 km)((OOrreevveerryy11yyeeaarr,,wwhhiicchheevveerrccoommeessffiirrsstt))
Check inflation and condition once a monthCheck oil and coolant at each fuel stop
10 16
2032304840645080 609670
112 80
128
((OOrreevveerryy22yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))
Replace at 120,000 miles (192,000 km) or 6 years, then every 90,000 miles (144,000 km) or 5 years.
((OOrreevveerryy11yyeeaarr,,wwhhiicchheevveerrccoommeessffiirrsstt))
((OOrreevveerryy55yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))Every 160,000 miles (256,000 km)
At 120,000 miles (192,000 km) or 10 years, then
every 60,000 miles (96,000 km) or 5 years 150 240
140224
130208
120192
110176
100160
90
144
Check engine oil and coolant
Check tires
Replace engine oil
Rotate tires (follow pattern on page 175 )
Replace engine oil filter
Check front and rear brakes
Check parking brake adjustment
Inspect the following items: Tie-rod ends, steering gearbox, and boots
Suspension components
Driveshaft boots
Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system
Fuel lines and connections
Inspect drive belts
Replace dust and pollen filter
Replace air cleaner element
Replace spark plugs
Inspect valve clearance
Replace automatic transmission fluid
Replace manual transmission fluid
Replace rear differential fluid
Inspect idle speed
Replace engine coolant
Replace brake fluid
See information on maintenance and emissions warranty, last column, page .
1:
: 150
1Maintenance Schedule for Normal Conditions
—
—y
y
(+
y
y

Î ÎÌ
µ
ÌÌÎ
Î
Follow the Severe Maintenance
Schedule if you drive your vehicle
MAINLY under one or more of the
f ollowing conditions:Driving less than 5 miles (8 km) per
trip or, in f reezing temperatures,
driving less than 10 miles (16 km)
per trip.
Driving in extremely hot [over 90°F
(32°C)] conditions.
Driving on muddy, dusty, or de-iced
roads.
T railer towing, driving with a roof
rack, or driving in mountainous
conditions.
Follow the
Maintenance Schedule f or Severe
Conditions. Extensive idling or long periods of
stop and go driving, such as a taxi or
a commercial delivery vehicle.
Maint enance
For Canadian Owners
153
miles x 1,000
km x 1,000
Every 3 years (independent of mileage)
((OOrreevveerryy33yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))
((OOtthheerrwwiisseeaaddjjuussttoonnllyyiiffnnooiissyy))
((OOrreevveerryy22yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))
10 16508070
112
Check oil and coolant at each fuel stop 150240
Service the items listed at the indicated distance (or time, if given).
Every 10,000 miles (16,000 km)
Check inflation and condition once a month
Every 5,000 miles (8,000 km) or every 6 months, whichever comes first
((OOrreevveerryy11yyeeaarr,,wwhhiicchheevveerrccoommeessffiirrsstt))
((OOrreevveerryy11yyeeaarr,,wwhhiicchheevveerrccoommeessffiirrsstt))
40 64
2032 609680
128
3048
Every 160,000 miles (256,000 km)
At 120,000 miles (192,000 km) or 10 years, then
every 60,000 miles (96,000 km) or 5 years
((OOrreevveerryy44yyeeaarrss,,wwhhiicchheevveerrccoommeessffiirrsstt))
Replace at 60,000 miles (96,000 km) or 3
years, then every 30,000 miles (48,000
km) or 2 years.
90
144 100 160 140224
130208
120192
110176
See dust and pollen filter on page for
replacement information under special
driving conditions.
Every 15,000 miles (24,000 km)
(Use normal schedule except in dusty condition)
See information on maintenance and
emissions warranty, last column, page.
Check engine oil and coolant
Check tires
Replace engine oil
Rotate tires (follow pattern on page 175 )
Replace engine oil filter
Check front and rear brakes
Lubricate all hinges, locks and latches
Inspect the following items:
Tie rod ends, steering gearbox, and boots
Suspension components, Driveshaft boots
Check parking brake adjustment
Inspect the following items: Brake hoses and lines (including ABS)
All fluid levels and condition of fluids
Exhaust system , Fuel lines and connections
Lights and controls/vehicle underbody
Inspect drive belts
Replace dust and pollen filter
Replace air cleaner element
Replace spark plugs
Inspect valve clearance
Replace automatic transmission fluid
Replace manual transmission fluid
Replace rear differential fluid
Inspect idle speed
Replace engine coolant
Replace brake fluid 1: 2:
: 150 170
1
2
Maintenance Schedule for Severe Conditions
—
—y


y
(+
y
y

Dirt build-up in the loops of the seat
belt anchors can cause the belts to
retract slowly. Wipe the insides of
the loops with a clean cloth
dampened in mild soap and warm
water or isopropyl alcohol.
Reinstall the socket into the light
assembly by turning it clockwise
until it locks.
Testthelightstomakesurethe
new bulb is working.
When reinstalling the taillight
assembly, f irst place the two pins
in the holes in place. Tighten the
two mounting bolts.
If your seat belts get dirty, use a sof t
brush with a mixture of mild soap
and warm water to clean them. Do
not use bleach, dye, or cleaning
solvents. Let the belts air-dry bef ore
you use the vehicle. This f ilter removes the dust and
pollenthatisbroughtinfromthe
outside through the heating and
cooling system/climate control
system.
Have your Honda dealer replace this
f ilter every 30,000 miles (48,000 km)
under normal conditions. It should
be replaced every 15,000 miles
(24,000 km) if you drive primarily in
urban areas that have high
concentrations of soot in the air, or if
the f low f rom the climate control
system becomes less than usual.
5. 6. 7.
Seat Belts
Dust and Pollen Filter
Lights, Seat Belts, Dust and Pollen Filter
Maint enance170
LOOP
—
—y

y
(+
y
y

µµ
µ
µ µ
µ µ
µ µ
Your new Honda is covered by these
warranties:
this warranty gives up
to 100 percent credit toward a
replacement battery. provides prorated
coverage f or a replacement battery
purchased f rom a Honda dealer.
covers your new vehicle, except f or
the battery, emissions control
systems and accessories, against
def ects in materials and
workmanship.
these two
warranties cover your vehicle’s emis-
sions control systems. Time, mileage,
and coverage are conditional. Please
read the warranty manual for exact
inf ormation. a seat
belt that f ails to f unction properly is
coveredfortheusefullifeof the
vehicle.
all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit.
genuine Honda Accessories are
covered under this warranty. Time
and mileage limits depend on the
type of accessory and other f actors.
Please read your warranty manual
f or details.
covers all genuine
Honda replacement parts against
def ects in materials and
workmanship. provides
coverageforaslongasthepur-
chaser of the muf f ler owns the
vehicle.
Restrictions and exclusions apply to
all these warranties. Please read the
2004 Honda Warranty Inf ormation
booklet that came with your vehicle
f or precise inf ormation on warranty
coverages. Your Honda’s original
tires are covered by their
manuf acturer. Tire warranty inf or-
mation is in a separate booklet.
Please ref er to the 2004 Warranty
Manual that came with your vehicle.
U.S. Owners
Canadian Owners
Original Equipment Bat t ery L imit edWarranty Replacement Bat t ery L imit ed
Warranty
New Vehicle L imit ed Warrant y
Emissions Cont rol Syst ems Def ect sWarrant y and EmissionsPerf ormance Warranty Seat Belt Limited Warranty
Rust Perf orat ion L imit ed Warrant y
Accessory Limited Warranty
Replacement Part s L imit edWarranty Replacement Muf f ler L if et ime
Limited Warranty
Warranty Coverages
Warrant y and Cust omer Relat ions215
—
—y

y
(+
yy

CONT INUED
BatteryCharging System ...........................
Indicator . 54, 192
............................
Jump Starting . 188
..............................
Maintenance . 177
............................
Specif ications . 205
..............................
Bef ore Driving . 109
....................................
Belts,Seat .8,19
...........................
Beverage Holders . 87
...................................
Body Panels . 165
..................................
Booster Seats . 45
Brakes
...........
Anti-lock System (ABS) . 133
.............
Break-in, New Linings . 110
....................
Bulb Replacement . 166 ...........................................
Fluid . 164
.........................................
Parking . 83
.................
System Indicator . 54, 194
........................
Wear Indicators . 133
.............................
Braking System . 132
.................
Break-in, New Vehicle . 110
..
Brightness Control, Instruments . 63
........................
Brights, Headlights . 62
Bulb Replacement
..........................
Back-up Lights . 169
..............................
Brake Lights . 169
................
Front Parking Lights . 167
........
Front Side Marker Lights . 168
.................................
Headlights . 166
............................
Specif ications . 205
....................
Turn Signal Lights . 167
..............................
Bulbs, Halogen . 166
............................
Capacities Chart . 204
.............
Carbon Monoxide Hazard . 48
..............................................
Cargo . 117
........................
Cargo, . 117
...
Accessories and Modif ications . 115
................................
Accessories . 115
............................
Modif ications . 116
ACCESSORY (Ignition Key .......................................
Position) . 69
..............
Accessory Power Sockets . 87
....................
Additives, Engine Oil . 157
.............................
Airbag (SRS) . 10, 22
................
Air Conditioning System . 91
............................................
Usage . 91
.........................
Air Outlets (Vents) . 92
.......................
Air Pressure, Tires . 172
.........................
Normal Driving . 173
......................................
Antif reeze . 160
Anti-lock Brakes (ABS)
...............................
Indicator . 55, 134
...................................
Operation . 133
..............
Anti-thef t, Audio System . 104
.
Anti-thef t Steering Column Lock . 69
......................
Armrests, Front Seat . 74
..................................
Audio System . 94
...
Automatic Seat Belt Tensioners . 20
.............
Automatic Speed Control . 107 ..............
Automatic Transmission . 127
..........................
Capacity, Fluid . 204
...............
Checking Fluid Level . 162
.......................................
Shif ting . 127
.
Shif t Lever Position Indicator . 127
................
Shif t Lever Positions . 127
....................
Shif t Lock Release . 130
......................
Auxiliary Input Jack . 106
how to carry
Index
A
B C
I
—
—y
y
(+
yy

CONT INUED
..............................
Economy, Fuel . 114
..................................
Emergencies . 179
............................
Jump Starting . 188
...........
Brake System Indicator . 194
................
Changing a Flat Tire . 181
.....
Charging System Indicator . 192
..................
Checking the Fuses . 196
.........
Hazard Warning Flashers . 63
.....
Low Oil Pressure Indicator . 192
...
Malf unction Indicator Lamp . 193
..................
Overheated Engine . 190
.......................................
Towing . 195
...........................
Emergency Brake . 83
......................
Emergency Flashers . 63
.......................
Emissions Controls . 209
.............
Emissions Testing, State . 212 Engine
....
Coolant Temperature Gauge . 59
......
Engine Speed Limiter . 126, 129
.............................. 186
Malf unction Indicator ................................
Lamp . 54, 193
........
Oil Pressure Indicator . 54, 192
..............
Oil, What Kind to Use . 157 ...............................
Overheating . 190
............................
Specif ications . 204
.......................................
Starting . 124
......................
Ethanol in Gasoline . 110
.
Evaporative Emissions Controls . 209
...............................
Exhaust Fumes . 48
Expectant Mothers, Use of Seat
........................................
Belts by . 17
.....................................
Fan, Interior . 90
Features, Comfort and
................................
Convenience . 89
....................
Filling the Fuel Tank . 111
Filters
.........................
Dust and Pollen . 170
...............................................
Oil . 158
5-speed Manual Transmission ...............
Checking Fluid Level . 163
................................
Shif ting the . 125
.............
Flashers, Hazard Warning . 63
...................
Flat Tire, Changing a . 181
Fluids
..........
Automatic Transmission . 162
..........................................
Brake . 164 .........................................
Clutch . 164
..............
Manual Transmission . 163
..........................
Power Steering . 165
..................
Windshield Washer . 161
FM Stereo Radio .....................................
Reception . 97
...........................
Folding Rear Seat . 77
..........................
Four-way Flashers . 63
Front Seat
......................................
Adjusting . 11
.........................................
Airbags . 22
.................................................
Fuel . 110
......................
Fill Door and Cap . 111
...........................................
Gauge . 58
................
Octane Requirement . 110
........................
Reserve Indicator . 56
........................
Tank, Filling the . 111
.....................
Fuses, Checking the . 196
...............
Gas Mileage, Improving . 114
..........................................
Gasohol . 110
If it won’t start
Index
E
F
G
III
—
—y
y
(+
yy