2004 FORD F650 charging

Engine starting (with parking brake applied)
Air chime sounds (if
equipped with air
compressor):The low air pressure warning chime should
sound immediately after the engine starts but
before the compressor has built up some
pressure. The low air pressure warning chime
should stop when the air pressure reaches 483
kPa (70 psi) (or more). Let the air pressure
build to governed cut-out pressure, which
should occur between 793–896 kPa (115–130
psi).
Accelerator:Depress the accelerator and verify that it
operates smoothly without any binding or
irregular feel. Remove your foot from the
pedal and make sure the engine returns to idle
speed immediately.
Ammeter/Voltmeter:Check the gauge to see if the alternator is
charging.
Steering linkage
free play:Check for excessive free play in the steering
linkages. The steering wheel should have less
than 5 cm (2 inches) of free play at rim of
steering wheel.
Hydraulic brake
check:Pump the brake pedal three times, then apply
firm pressure to the pedal and hold it for five
seconds. The pedal should not move; if it does,
there may be a leak or another problem. Do
not drive the vehicle until the problem is
fixed.
Parking brake:Check that the parking brake will hold the
vehicle by gently trying to pull forward with
the parking brake applied.
2004 F650/750(f67)
Supplement
USA English(fus)
Vehicle inspection guide
11

Charging system:Illuminates when
the battery is not charging properly.
Wait to start:Indicates the air
intake heater is in operation and
special starting procedures are
required. Refer to theDriving
chapter.
If equipped with an air intake heater, DO NOT use ether or any
other starting fluids. The use of starting fluids (ether) in an
engine equipped with an air intake heater could result in damage
and/or personal injury.
Water in fuel (if equipped):
During refueling it is possible for
water-contaminated diesel fuel to be
pumped into your fuel tank. Your
vehicle fuel system is equipped with
a fuel filter/water separator to remove water from the fuel. The indicator
light illuminates when the fuel filter/water separator has a significant
quantity of water, or when the ignition key is switched to the START
position. If the light illuminates when the engine is running, stop the
vehicle as soon as safely possible, shut off the engine and drain the filter
bowl. Allowing water to stay in the system could result in extensive
damage to, or failure of, the fuel injection system.
To drain the fuel filter/water separator (refer toMaintenance and
Specificationschapter for procedure), rotate the valve at the bottom of
the filter assembly allowing water to drain from the system. Close the
valve upon completion.
Do not drain water separator while engine is running. Fuel may
ignite if separator is drained while engine is running or vehicle is
moving.
WAIT
TO
START
WATER
IN
FUEL
2004 F650/750(f67)
Supplement
USA English(fus)
Instrumentation
23

The parking brake controls the spring brakes on the tractor. When the
knob is pulled out it causes the trailer supply valve to pop out, applying
both the tractor and trailer parking brakes. The trailer brakes may be
independently released by pushing only the trailer air supply valve in.
Initial charge
With the air system completely discharged, both knobs (1 and 2) will be
out. When the air pressure reaches 483 kPa (70 psi) the trailer air
supply (1–red knob) may be pushed in and should stay in charging the
trailer air system and releasing the trailer brakes.
The parking brake (2–yellow knob) can now be pushed in and supply air
to the tractor spring brakes, releasing them.
12 12
12
2004 F650/750(f67)
Supplement
USA English(fus)
Driving
107

3. Remove the jumper cable from the positive (+) terminal of the booster
vehicle’s battery.
4. Remove the jumper cable from the positive (+) terminal of the
disabled vehicle’s battery.
After the disabled vehicle has been started and the jumper cables
removed, allow it to idle for several minutes so the engine computer can
relearnits idle conditions.
WRECKER TOWING INSTRUCTIONS
Before moving the towed vehicle, check for adequate road clearance of
vehicle components. It is recommended the towed vehicle be unloaded
prior to being towed to reduce any abnormal load to the vehicle
components resulting from the towing procedures. Before towing, be
sure to fully release the parking brake. The spring-actuated type parking
brake can be reset by recharging the air system with at least 441 kPa (64
psi) of air. If the brake system will not retain air pressure, then the
spring brakes must be released manually. Refer toParking brakein the
Drivingchapter
Note:For towing, make sure the vehicle is securely connected to the
tow vehicle and the tow vehicle parking brakes are applied before
releasing the disabled vehicle’s spring brakes.
+–+–
+–+–
2004 F650/750(f67)
Supplement
USA English(fus)
Roadside emergencies
146

BATTERY
Your vehicle is equipped with two maintenance-free batteries which are
mounted in a covered tray and located on the left frame rail. The
covered battery tray, depending upon application, may also have one or
two steps attached.
•Covered battery tray shown.
Battery tray with steps similar.
The two rubber straps on top of
the cover must be pulled up and
moved to the side of the battery
in order to remove the lid.
•Battery tray with cover removed.
Maintenance-free batteries do not normally require adding additional
water. However, for severe usage or in high temperature climates, check
the battery electrolyte levels. Refer to the general maintenance
information section for the service interval schedules.
Keep the electrolyte level in each cell up to the“level indicator”.
Do not overfill the battery cells.
If the electrolyte level in the battery is low, you can add plain tap water
to the battery, as long as you do not use hard water (water with a high
mineral or alkali content). If possible, however, try to only fill the battery
cells with distilled water. If the battery needs water often, have the
charging system checked.
Make sure the battery cover/shield is reinstalled after the battery
has been cleaned or replaced.
2004 F650/750(f67)
Supplement
USA English(fus)
Maintenance and specifications
176

A
Air conditioning ..........................43
manual heating and air
conditioning system .................43
Air suspension ...........................112
Anti-lock brake system
(see Brakes) ..............................110
Audio system
(see Radio) ................28, 30, 33, 37
Automatic transmission ............115
fluid, adding ............................181
fluid, checking ........................181
fluid, refill capacities ..............218
fluid, specification ..................207
Auxiliary power point .................52
Axle ............................127, 160, 198
lubricant specifications ..........207
refill capacities ........................217
B
Battery .......................................176
charging system warning
light ............................................20
jumping a disabled battery ....143
voltage gauge ............................24
BeltMinder ...................................73
Brakes ......................91–92, 97, 160
adjustment ..............................163
anti-lock ...........................110–111
anti-lock brake system (ABS)
warning light .....................20, 111
brake warning light ..................20
fluid, checking and
adding ..............................163, 175
fluid, specifications .................207
parking ................93–94, 100, 164
Bulbs ............................................47C
Cassette tape player ...................37
Catalytic converter
(see Emission control) .............183
CD-single premium .........28, 30, 33
Cell phone use ............................52
Child safety restraints ................78
child safety belts ......................78
Child safety seats ........................81
attaching with tether straps ....85
in front seat ..............................83
in rear seat ................................83
tether anchorage hardware .....85
Child safety seats - booster
seats .............................................79
Cleaning your vehicle
chrome and aluminum parts..155
engine compartment ..............155
exterior ....................................157
instrument panel ....................156
interior .....................................156
interior trim ............................156
plastic parts ............................156
washing ....................................154
waxing .....................................154
wheels ......................................155
Climate control (see Air
conditioning or Heating) ......42–43
Clutch ................................119, 180
adjusting ..................................180
fluid ..........................................180
operation while driving ..........119
specifications ..........................207
Controls
power seat .................................66
Coolant ......................................170
checking and adding ..............170
2004 F650/750(f67)
Supplement
USA English(fus)
Index
258

H
Hazard flashers .........................137
Headlamps ...................................45
aiming ........................................46
daytime running lights .............45
flash to pass ..............................45
high beam .................................45
warning chime ..........................20
Heating ..................................42–43
heater only system ...................42
manual heating and air
conditioning system .................43
Hood ..........................................165
I
Ignition
chime .........................................20
Infant seats (see Safety seats) ..81
Instrument panel
cleaning ...................................156
lighting up panel and
interior .......................................46
J
Jump-starting your vehicle ......143
K
Keys
key in ignition chime ...............20
L
Lamps
bulb replacement
specifications chart ..................47
cargo lamps ...............................46
daytime running light ...............45headlamps .................................45
headlamps, flash to pass ..........45
high beams ................................45
instrument panel, dimming .....46
interior lamps ...........................47
replacing bulbs ...................47–49
Lane change indicator
(see Turn signal) ........................46
Lights, warning and indicator ....20
air suspension ...........................20
anti-lock brakes (ABS) ....20, 111
brake ..........................................20
charging system ........................20
safety belt .................................20
service engine soon ..................20
traction control off ...................20
turn signal indicator .................20
Lubricant specifications ...........207
M
Maintenance and Care ..............226
Manual transmission .................121
lubricant specifications ..........207
Mirrors .........................................54
fold away ...................................56
heated ........................................55
side view mirrors (power) .......54
O
Odometer .....................................24
P
Paint chips, repairing ...............155
Parking brake ................93–94, 100
warning light .............................20
Power door locks ........................62
Power mirrors .............................54
2004 F650/750(f67)
Supplement
USA English(fus)
Index
260