2004 FORD F650 warning

When operating a loaded vehicle, the driver must keep all
adjustable axles on the ground at all times, supporting their
share of the vehicle’s load. Failure to do so can overload other axles,
tires, wheels, springs, steering components, brakes and frames,
resulting in early component failure, loss of vehicle control, possible
property damage and personal injury.
FIFTH WHEEL OPERATION
Failure to follow the fifth wheel manufacturer’s instructions for
hooking and unhooking as well as sliding the fifth wheel could
result in an accident, personal injury or death.
When the tractor and trailer are parked unattended, the trailer
brake hand control should never be used to apply the brake,
since air may leak from the system, allowing vehicle movement,
resulting in possible property damage, personal injury or death.
Hook-up
1. Fifth wheel jaws must be fully opened.
2. Tilt the fifth wheel back to prevent body damage when the tractor is
backed under a trailer.
3. Block the trailer wheels and be sure the trailer spring brakes are
adjusted and applied. Never chase a trailer.
4. Make sure the brake hoses and light cords are clear of the fifth wheel.
5. Back the tractor squarely under the trailer, engaging the fifth wheel
jaws on the kingpin. Always back-up slowly, making sure the trailer is
neither too high nor too low. Avoid backing under the trailer from an
angle.
6. Connect the service and emergency brake hoses and trailer light
connector. Refer toTractor-trailer connectionin this chapter, adhering
to the warning and using the three-point stance while connecting and
disconnecting the trailer.
7. Inspect the jaws of the fifth wheel to be sure they have fully closed on
the trailer kingpin and the trailer plate is resting securely on the fifth
wheel.
8. Be sure the coupler release lever is in the locked position.
2004 F650/750(f67)
Supplement
USA English(fus)
Driving
114

Fuse/Relay
LocationFuse Amp
RatingFuse Description
11 30A Wiper motor, Washer pump relay
12 10A Stop lamp switch (Hydraulic brake vehicles)
13 20A Cluster, Radio
14 10A Interior lamp relay
15 10A Interior lamp relay
16 15A Headlamp high beam, High beam indicator
17—Not used
18 5A Headlamp switch interior lighting
19 15A Engine control (all engines), Accelerator
pedal (6.0L Power Stroke engine)
20 15A Starting system
21 10A DRL resistor
22 15A Speed control feed (6.0L Power Stroke
engine), Air solenoid, Fuel transfer pump
23 10A Hazard flasher (Run)
24 15A ABS, Air dryer, Vacuum pump, Fuel heater
relay
25 10A Function selector switch
26 10A RH headlamp low beam
27—Not used
28 10A LH headlamp low beam
29 10A Cluster warning lamps, Gauges GEM,
Hydraulic brake ABS
30—Not used
31 15A Allison transmission or ABS event
Relay 1 1/2 ISO Interior lamp relay
Relay 2 1/2 ISO Not used
Relay 3 Full ISO Horn relay
Relay 4 Full ISO One-touch window down relay
Relay 5 Full ISO Not used
2004 F650/750(f67)
Supplement
USA English(fus)
Roadside emergencies
142

Fuel filter/water separator
Do not drain water separator while engine is running. Fuel may
ignite if separator is drained while engine is running or vehicle is
moving.
The fuel filter/water separator removes any contaminated particles
and/or water from the fuel before the fuel enters the engine.
The fuel filter/water separator should be drained as recommended in the
general maintenance information section.
Draining the fuel filter/water separator - Caterpillar engine
1. With the engine off, open the
drain valve located at the bottom of
the fuel filter/water separator by
turning it counterclockwise.
2. Drain the filter until clear fuel is visible.
3. Turn the drain valve clockwise to close the valve. Do not overtighten
the drain valve as this could cause damage to the fuel filter/water
separator.
Draining the fuel filter/water separator–6.0L Power Stroke engine
The vehicle is equipped with a module located on the frame-rail under
the driver-side floorboard near the transmission.
Water should be drained from the
module assembly whenever the
warning light comes on or every
8,000 km (5,000 miles). The WATER
IN FUEL light will come on when approximately 100 cc (0.2 pints) of
water accumulates in the module.
2004 F650/750(f67)
Supplement
USA English(fus)
Maintenance and specifications
187

OWNER MAINTENANCE
You can do much of the maintenance your vehicle requires yourself, if
you have the time and a reasonable amount of mechanical ability. If you
prefer to have this work done professionally, your authorized dealer
stands ready to help you.
All mechanical components and attachments are important in that they
could affect the performance of vital components and systems. If
replacement becomes necessary, they must be replaced with parts having
the same part number or with equivalent parts. Torque values of the
attaching parts must be used as specified during any reassembly
procedure to assure proper retention.
EMISSIONS CONTROL SYSTEM
To assure the emissions control systems operate effectively, you should
have the services listed in the maintenance schedule performed at the
specified time and km/mileage intervals. You should avoid running out of
fuel or turning off the ignition while the vehicle is in motion, especially
at high speeds.
Because of high engine compartment and exhaust system
temperatures resulting from emissions equipment, do not park,
idle or operate your vehicle in dry grass or other dry ground cover
where the possibility of ground fire exists.
Do not make unauthorized modifications to the engine or vehicle.
Modifications causing increased amounts of unburned fuel to reach the
exhaust system can significantly increase the temperature of the engine
compartment and/or the exhaust system.
Avoid driving your vehicle if it does not operate properly. If the engine
diesels (more than five seconds of engine run-on after shut-off), misfires,
surges, stalls or backfires, see your dealer. Be alert for fluid leakage,
odor, smoke, loss of oil pressure, or charge indicator or over temperature
warning.
Do NOT use diesel fuel blended with waste oil in engines equipped with
a catalytic converter-muffler. Waste lube oil blending in fuel will plug the
catalytic converter-muffler, resulting in a significant loss of engine power.
2004 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
223

Maintenance Operation Frequency - Observation
Inspect the automatic slack
adjuster functionInsufficient power shown in loaded
practice stop
Check the operation of the
brakes, the clutch, and the
steering (*a,b)Vehicle handling qualities not up to
par
Inspect the vehicle for missing,
damaged, or mislocated noise
shieldsExcessive noise emanates from under
the cab or engine compartment
Check the engine performance
and the engine governorExcessive engine noise
Inspect the fan, the fan shroud,
and the fan clutchEngine overheats, fans runs at high
speed constantly, excessive fan noise,
or fan wobble due to worn bearings
Check for operation of ABS
warning lampAt each engine start up
Inspect the entire exhaust
system (including inlet pipe,
muffler, outlet pipe and all
exhaust clamps and fasteners)
for holes, leakage, breakage,
looseness and corrosive
damageExcessive noise or the smell of fumes
is experienced
Inspect the engine air
induction system (including the
air ducts, the air cleaner, and
the air cleaner element) for
loose fitting, damaged or
missing componentsExcessive noise emanates from the
engine compartment
Inspect the tires and check the
air pressure (*c)Poor steering, wandering or excessive
tire wear
Balance the wheels and the
tiresVibration or abnormal tire wear
indicates imbalance
Check the front end alignment
(*c)Poor steering, wandering or excessive
tire wear
2004 F650/750(f67)
Supplement
USA English(fus)
General maintenance information
232

A
Air conditioning ..........................43
manual heating and air
conditioning system .................43
Air suspension ...........................112
Anti-lock brake system
(see Brakes) ..............................110
Audio system
(see Radio) ................28, 30, 33, 37
Automatic transmission ............115
fluid, adding ............................181
fluid, checking ........................181
fluid, refill capacities ..............218
fluid, specification ..................207
Auxiliary power point .................52
Axle ............................127, 160, 198
lubricant specifications ..........207
refill capacities ........................217
B
Battery .......................................176
charging system warning
light ............................................20
jumping a disabled battery ....143
voltage gauge ............................24
BeltMinder ...................................73
Brakes ......................91–92, 97, 160
adjustment ..............................163
anti-lock ...........................110–111
anti-lock brake system (ABS)
warning light .....................20, 111
brake warning light ..................20
fluid, checking and
adding ..............................163, 175
fluid, specifications .................207
parking ................93–94, 100, 164
Bulbs ............................................47C
Cassette tape player ...................37
Catalytic converter
(see Emission control) .............183
CD-single premium .........28, 30, 33
Cell phone use ............................52
Child safety restraints ................78
child safety belts ......................78
Child safety seats ........................81
attaching with tether straps ....85
in front seat ..............................83
in rear seat ................................83
tether anchorage hardware .....85
Child safety seats - booster
seats .............................................79
Cleaning your vehicle
chrome and aluminum parts..155
engine compartment ..............155
exterior ....................................157
instrument panel ....................156
interior .....................................156
interior trim ............................156
plastic parts ............................156
washing ....................................154
waxing .....................................154
wheels ......................................155
Climate control (see Air
conditioning or Heating) ......42–43
Clutch ................................119, 180
adjusting ..................................180
fluid ..........................................180
operation while driving ..........119
specifications ..........................207
Controls
power seat .................................66
Coolant ......................................170
checking and adding ..............170
2004 F650/750(f67)
Supplement
USA English(fus)
Index
258

H
Hazard flashers .........................137
Headlamps ...................................45
aiming ........................................46
daytime running lights .............45
flash to pass ..............................45
high beam .................................45
warning chime ..........................20
Heating ..................................42–43
heater only system ...................42
manual heating and air
conditioning system .................43
Hood ..........................................165
I
Ignition
chime .........................................20
Infant seats (see Safety seats) ..81
Instrument panel
cleaning ...................................156
lighting up panel and
interior .......................................46
J
Jump-starting your vehicle ......143
K
Keys
key in ignition chime ...............20
L
Lamps
bulb replacement
specifications chart ..................47
cargo lamps ...............................46
daytime running light ...............45headlamps .................................45
headlamps, flash to pass ..........45
high beams ................................45
instrument panel, dimming .....46
interior lamps ...........................47
replacing bulbs ...................47–49
Lane change indicator
(see Turn signal) ........................46
Lights, warning and indicator ....20
air suspension ...........................20
anti-lock brakes (ABS) ....20, 111
brake ..........................................20
charging system ........................20
safety belt .................................20
service engine soon ..................20
traction control off ...................20
turn signal indicator .................20
Lubricant specifications ...........207
M
Maintenance and Care ..............226
Manual transmission .................121
lubricant specifications ..........207
Mirrors .........................................54
fold away ...................................56
heated ........................................55
side view mirrors (power) .......54
O
Odometer .....................................24
P
Paint chips, repairing ...............155
Parking brake ................93–94, 100
warning light .............................20
Power door locks ........................62
Power mirrors .............................54
2004 F650/750(f67)
Supplement
USA English(fus)
Index
260

Power point .................................52
Power steering ..........................178
fluid, checking and adding ....179
fluid, refill capacity ................218
fluid, specifications .................207
Power Windows ...........................53
R
Radio ..........................28, 30, 33, 37
Relays ........................................141
Remote entry system
locking/unlocking doors ...........62
Roadside assistance ..................136
S
Safety belts (see Safety
restraints) ..............................68–70
Safety defects, reporting ..........153
Safety restraints ....................68–70
belt minder ...............................73
cleaning the safety belts ..........77
extension assembly ..................77
for adults .............................69–70
for children ...............................78
lap belt ......................................72
warning light and
chime .............................20, 72–73
Safety seats for children ............81
Seat belts
(see Safety restraints) ...............68
Seats ............................................63
child safety seats ......................81
heated ........................................67
Servicing your vehicle ..............226
Special notice ................................5Specification chart,
lubricants ...................................207
Speed control ..............................56
Speedometer ...............................24
Starting your vehicle ..................86
jump starting ..........................143
preparing to start your
vehicle .......................................86
Steering .....................................178
Steering wheel
controls ................................51, 56
tilting .........................................51
Suspension ........................112, 195
T
Tachometer .................................24
Temperature control
(see Climate control) ...........42–43
Tires
checking the pressure ............205
Towing
wrecker ....................................146
Traction control
off light ......................................20
Transmission .....................115, 121
automatic operation ...............115
fluid, checking and adding
(automatic) .............................181
fluid, checking and adding
(manual) .................................181
fluid, refill capacities ..............218
lubricant specifications ..........207
manual operation ....................121
Turn signal ..................................46
2004 F650/750(f67)
Supplement
USA English(fus)
Index
261