2004 FORD F250 light

Information on“T”type tires
T145/80D16 is an example of a tire
size.
Note:The temporary tire size for
your vehicle may be different from
this example.
1.T:Indicates a type of tire,
designated by the Tire and Rim
Association (T&RA), that is
intended for temporary service on
cars, SUVs, minivans and light
trucks.
2.145:Indicates the nominal width
of the tire in millimeters from
sidewall edge to sidewall edge. In
general, the larger the number, the
wider the tire.
3.80:Indicates the aspect ratio
which gives the tire’s ratio of height to width. Numbers of 70 or lower
indicate a short sidewall.
4.D:Indicates a“diagonal”type tire.
R:Indicates a“radial”type tire.
5.16:Indicates the wheel or rim diameter in inches. If you change your
wheel size, you will have to purchase new tires to match the new wheel
diameter.
Location of the tire label
You will find a tire label containing tire inflation pressure by tire size and
other important information located on the B-Pillar or the edge of the
driver’s door.
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
274

2. Remove the cap from the valve on one tire, then firmly press the tire
gauge onto the valve and measure the pressure.
3. Add enough air to reach the recommended air pressure
Note:If you overfill the tire, release air by pushing on the metal stem in
the center of the valve. Then recheck the pressure with your tire gauge.
4. Replace the valve cap.
5. Repeat this procedure for each tire, including the spare.
Note:Some spare tires require higher inflation pressure than the other
tires. Check the tire label on the B pillar or the edge of the driver’s door
for the recommended spare tire pressure.
6. Visually inspect the tires to make sure there are no nails or other
objects embedded that could poke a hole in the tire and cause an air
leak.
7. Check the sidewalls to make sure there are no gouges, cuts or bulges.
Tire inflation information
All tires with Steel Carcass Plies (if equipped):
This type of tire utilizes steel cords in the sidewalls. As such, they
cannot be treated like normal light truck tires. Tire service, including
adjusting tire pressure, must be performed by personnel trained,
supervised and equipped according to Federal Occupational Safety and
Health Administration (OSHA) regulations. For example, during any
procedure involving tire inflation, the technician or individual must
utilize a remote inflation device, and ensure that all persons are clear of
the trajectory area.
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
276

GENUINE FORD ACCESSORIES FOR YOUR VEHICLE
A wide selection of Genuine Ford Accessories are available for your
vehicle through your local authorized Ford or Ford of Canada dealer.
These quality accessories have been specifically engineered to fulfill your
automotive needs; they are custom designed to complement the style
and aerodynamic appearance of your vehicle. In addition, each accessory
is made from high quality materials and meets or exceeds Ford’s rigorous
engineering and safety specifications. Ford Motor Company will repair or
replace any properly dealer-installed Genuine Ford Accessory found to
be defective in factory-supplied materials or workmanship during the
warranty period, as well as any component damaged by the defective
accessory. The accessory will be warranted for whichever provides you
the greatest benefit:
•12 months or 12,000 miles (20,000 km) (whichever occurs first), or
•the remainder of your new vehicle limited warranty.
This means that Genuine Ford Accessories purchased along with your
new vehicle and installed by the dealer are covered for the full length of
your New Vehicle’s Limited Warranty—3 years or 36,000 miles (60,000
km) (whichever occurs first). Contact your dealer for details and a copy
of the warranty.
Not all accessories are available for all models.
The following is a list of several Genuine Ford Accessory products for
your vehicle. Not all accessories are available for all models. For a
complete listing of the accessories that are available for your vehicle,
please contact your dealer or visit our online store at:
www.fordaccessoriesstore.com.
Exterior style
Bug shields
Deflectors
Exterior trim
Fender flares
Front end covers
Grille inserts
Headlamps, taillamps, fog lights and Daytime Running Lamps (DRLs)
Running boards
Sliding rear windows - manual and power
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Accessories
Accessories
302

A
Accessory delay ..........................58
Air bag supplemental restraint
system ................................105–106
and child safety seats ............107
description ..............................106
disposal ....................................109
driver air bag ..........................108
indicator light .........................109
operation .................................108
passenger air bag ...................108
passenger deactivation
switch ......................................110
Air cleaner filter ...............267, 283
Ambulance packages ....................8
Antifreeze
(see Engine coolant) ................244
Anti-lock brake system
(see Brakes) ..............................130
Audio system
(see Radio) ..........20, 22, 25, 28, 32
Automatic transmission ............133
driving an automatic
overdrive .........................134, 137
fluid, adding ............................262
fluid, checking ........................262
fluid, refill capacities ..............284
fluid, specification ..................291
Auxiliary power point .................57
Axle
lubricant specifications ..287, 291
refill capacities ........................284
traction lok ..............................132
B
Battery .......................................242
acid, treating emergencies .....242jumping a disabled battery ....212
maintenance-free ....................242
replacement, specifications ...283
servicing ..................................242
BeltMinder .................................101
Brakes ........................................130
anti-lock ...................................130
anti-lock brake system (ABS)
warning light ...........................130
fluid, checking and adding ....260
fluid, refill capacities ..............284
fluid, specifications .........287, 291
lubricant specifications ..287, 291
parking ....................................131
shift interlock ..........................133
Break-in period .............................6
Bulbs ............................................45
C
Calculating load ........................164
Capacities for refilling fluids ....284
Cell phone use ............................69
Certification Label ....................298
Child safety restraints ..............114
child safety belts ....................114
Child safety seats ......................117
attaching with tether straps ..121
in front seat ............................118
in rear seat ..............................118
Cleaning your vehicle
engine compartment ..............230
instrument panel ....................232
interior .....................................232
interior trim ............................232
plastic parts ............................231
safety belts ..............................232
washing ....................................229
waxing .....................................229
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
Index
305

filter, specifications ........241, 283
recommendations ...................241
refill capacities ........................284
specifications ..................287, 291
Exhaust fumes ..........................129
F
Fail safe cooling ........................248
Fluid capacities .........................284
Foglamps .....................................42
Four-Wheel Drive vehicles .......144
description ..............................149
driving off road .......................151
electronic shift ................145, 149
indicator light .........................146
lever operated shift ................146
manual locking hubs ..............144
preparing to drive your
vehicle .....................................132
Fuel ............................................250
calculating fuel economy .......254
cap ...........................................252
capacity ...................................284
choosing the right fuel ...........252
comparisons with EPA fuel
economy estimates .................257
detergent in fuel .....................254
filling your vehicle with
fuel ...........................250, 252, 254
filter, specifications ........254, 283
fuel pump shut-off switch .....193
improving fuel economy ........254
octane rating ...................253, 291
quality ......................................253
running out of fuel .................254
safety information relating to
automotive fuels .....................250
Fuel pump shut-off switch .......193
Fuses ..................................194–195G
Garage door opener ....................55
Garage Door Opener
(see Homelink wireless control
system) ........................................64
Gas cap (see Fuel cap) ............252
Gas mileage
(see Fuel economy) .................254
Gauges .........................................16
transmission fluid
temperature gauge ...................20
GAWR (Gross Axle Weight
Rating)
calculating ...............................164
GVWR (Gross Vehicle Weight
Rating)
calculating ...............................164
H
Hazard flashers .........................193
Head restraints ...........................85
Headlamps ...................................41
aiming ........................................43
autolamp system .......................41
daytime running lights .............42
flash to pass ..............................43
high beam .................................43
replacing bulbs ...................46–47
turning on and off ....................41
Heating
heating and air conditioning
system .................................38–39
Homelink wireless control
system ..........................................64
Hood ..........................................237
I
Ignition ...............................125, 291
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
307

Infant seats
(see Safety seats) .....................117
Inspection/maintenance (I/M)
testing ........................................259
Instrument panel
cleaning ...................................232
cluster ........................................12
lighting up panel and
interior .......................................43
J
Jump-starting your vehicle ......212
K
Keyless entry system .................82
autolock .....................................81
Keys
positions of the ignition .........125
L
Lamps
autolamp system .......................41
bulb replacement
specifications chart ..................45
daytime running light ...............42
fog lamps ...................................42
headlamps .................................41
headlamps, flash to pass ..........43
instrument panel, dimming .....43
interior lamps .....................44–45
replacing bulbs ...................45–51
Lane change indicator
(see Turn signal) ........................44
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........130
speed control ............................63
Load limits .................................161Loading instructions .................164
Locks
autolock .....................................81
childproof ..................................76
Lubricant specifications ...287, 291
Lug nuts ....................................211
Lumbar support, seats ...............90
M
Manual transmission .................140
fluid capacities ........................284
lubricant specifications ..........291
reverse .....................................141
Message center ...........................70
english/metric button ...............70
menu button .............................70
Mirrors .........................................54
fold away ...................................60
heated ........................................59
side view mirrors (power) .......59
Moon roof ....................................55
Motorcraft parts ................254, 283
O
Octane rating ............................253
Oil (see Engine oil) ..................239
Overdrive .....................................53
P
Parking brake ............................131
Parts (see Motorcraft parts) ....283
Pedals (see Power adjustable
foot pedals) .................................61
Power adjustable foot pedals .....61
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
308

Power distribution box
(see Fuses) ...............................195
Power door locks ..................75, 81
Power point .................................57
Power steering ..........................132
fluid, checking and adding ....260
fluid, refill capacity ................284
fluid, specifications .........287, 291
Power Windows ...........................57
Preparing to drive your
vehicle ........................................132
R
Radio ....................20, 22, 25, 28, 32
Relays ........................................194
Remote entry system .................77
illuminated entry ......................80
locking/unlocking doors ...........75
Reverse sensing system ...........142
Roadside assistance ..................192
S
Safety Belt Maintenance ..........105
Safety belts
(see Safety restraints) ...92–96, 98
Safety defects, reporting ..........228
Safety restraints ....................92–98
belt minder .............................101
extension assembly ................104
for adults .............................93–96
for children .............................114
lap belt ......................................99
safety belt maintenance .........105
warning light and
chime ...............................100–101
Safety seats for children ..........117Seat belts
(see Safety restraints) ...............92
Seats ............................................85
child safety seats ....................117
cleaning ...................................233
Servicing your vehicle ..............236
Setting the clock
AM/FM stereo ...........................21
AM/FM/CD .................................25
AM/FM/In-dash 6 CD ................34
AM/FM/Tape ..............................22
AM/FM/Tape/CD .......................30
Snowplowing .........8, 188–189, 191
Spark plugs,
specifications .....................283, 291
Special notice ................................9
ambulance conversions ..............8
diesel-powered vehicles .............8
four-wheel drive vehicles .......190
utility-type vehicles ....................8
Specification chart,
lubricants ...........................287, 291
Speed control ..............................61
Starting your
vehicle ........................125–126, 128
jump starting ..........................212
Steering wheel
tilting .........................................53
T
Tailgate ..................................73–74
Tilt steering wheel ......................53
Tires ...................................268–269
alignment ................................277
care ..........................................275
changing ..................................203
checking the pressure ............275
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
309

label .........................................274
replacing ..................................281
rotating ....................................277
safety practices .......................281
sidewall information ...............270
snow tires and chains ............282
spare tire .................................200
terminology .............................269
tire grades ...............................269
treadwear ........................268, 280
Towing .......................................164
trailer towing ..........................164
wrecker ....................................217
Traction-lok rear axle ...............132
Transfer case
fluid checking .........................266
Transmission
automatic operation .........53, 133
brake-shift interlock (BSI) ....133
fluid, checking and adding
(automatic) .............................262
fluid, checking and adding
(manual) .................................265
fluid, refill capacities ..............284
lubricant specifications ..287, 291manual operation ....................140
Turn signal ..................................44
V
Vehicle dimensions ...................291
Vehicle Identification Number
(VIN) ..........................................298
Vehicle loading ..........................161
Ventilating your vehicle ...........129
W
Warning lights (see Lights) .......12
Washer fluid ..............................239
Water, Driving through .............160
Windows
power .........................................57
Windshield washer fluid and
wipers ..........................................52
checking and adding fluid .....239
replacing wiper blades .............52
Wrecker towing .........................217
2004 F250/350/450/550(f23)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
310