2004 FORD ESCAPE battery

If the battery has been disconnected or a new battery has been installed,
the clock and the preset radio stations must be reset once the battery is
reconnected.
•Always dispose of automotive
batteries in a responsible manner.
Follow your local authorized
standards for disposal. Call your
local authorized recycling center
to find out more about recycling
automotive batteries.
ENGINE COOLANT
Checking engine coolant
The concentration and level of engine coolant should be checked at the
mileage intervals listed in the scheduled maintenance guide. The coolant
concentration should be maintained at 50/50 coolant and distilled water,
which equates to a freeze point of -36° C (-34° F). Coolant concentration
testing is possible with a hydrometer or antifreeze tester (such as the
Rotunda Battery and Antifreeze Tester, 014–R1060). The level of coolant
should be maintained at the “cold full” of “cold fill range” level in the
coolant reservoir. If the level falls below, add coolant per the instructions
in theAdding engine coolantsection.
Your vehicle was factory-filled with a 50/50 engine coolant and water
concentration. If the concentration of coolant falls below 40% or above
60%, the engine parts could become damaged or not work properly.A
50–50 mixture of coolant and water provides the following:
•Freeze protection down to -36° C (-34° F).
•Boiling protection up to 129° C (265° F).
•Protection against rust and other forms of corrosion.
•Enables calibrated gauges to work properly.
LEAD
RETURN
RECYCLE
2004 Escape(204)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
196

Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If your
indicator is on, refer to the
description in theWarning lights and chimessection of the
Instrument Clusterchapter. Your vehicle may not pass the I/M test with
the
indicator on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a “not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
CHECKING AND ADDING POWER STEERING FLUID
Check the power steering fluid.
Refer to the scheduled maintenance
guide for the service interval
schedules. If adding fluid is
necessary, use only MERCONAT F.
1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
2004 Escape(204)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
210

MOTORCRAFT PART NUMBERS
Component 2.0L DOHC I4
Zetec engine3.0L DOHC V6 Duratec
engine
Air filter element
1FA-1683 FA-1683
Fuel filter FG-800-A FG-800-A
Battery BXT-96R BXT-40R
Oil filter FL-400S FL-820-S
PCV valve EV-272 EV-243
Spark plugs
2AZFS-32FE3AGSF-32W
1Failure to use the correct air filter element may result in severe engine
damage. The customer warranty may be voided for any damage to the
engine if the correct air filter element is not used.
2Refer to Vehicle Emissions Control Information (VECI) decal for spark
plug gap information.
3If a spark plug is to be removed for inspection, it must be reinstalled in
the same cylinder. If a spark plug needs to be replaced, use only spark
plugs with the service part number suffix letter as shown on the engine
decal.
REFILL CAPACITIES
Fluid Ford Part Name Application Capacity
Brake fluid (and
clutch fluid if
equipped)Motorcraft High
Performance DOT
3 Motor Vehicle
Brake FluidAll Fill to line on
reservoir
Engine oil
(including filter
change)
6
Motorcraft SAE
5W-20 Premium
Synthetic Blend
Motor Oil (US)
Motorcraft SAE
5W-20 Super
Premium Motor
Oil (Canada)2.0L I4 Zetec
engine4.25L (4.5
quarts)
3.0L V6
Duratec engine5.2L (5.5
quarts)
2004 Escape(204)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
220

A
Air bag supplemental restraint
system ............................96–97, 100
and child safety seats ..............98
description ........................97, 100
disposal ....................................103
driver air bag ....................99, 101
indicator light .................100, 102
operation ...........................99, 101
passenger air bag .............99, 101
side air bag ..............................100
Air cleaner filter ...............214, 220
All Wheel Drive (AWD),
driving off road .........................130
Ambulance packages ....................7
Antifreeze
(see Engine coolant) ................196
Anti-lock brake system
(see Brakes) ..............................119
Anti-theft system ........................73
arming the system ....................73
disarming a triggered system ..74
Audio system
Single CD ..................................15
Audio system
(see Radio) ................15, 18, 22, 26
Automatic transaxle
fluid, adding ............................211
fluid, checking ........................211
Automatic transmission
driving an automatic
overdrive .................................124
fluid, refill capacities ..............220
fluid, specification ..................225
Auxiliary power point .................49Axle
lubricant specifications ..223, 225
refill capacities ........................220
B
Battery .......................................194
acid, treating emergencies .....194
jumping a disabled battery ....164
maintenance-free ....................194
replacement, specifications ...220
servicing ..................................194
BeltMinder ...................................92
Brakes ........................................119
anti-lock ...................................119
anti-lock brake system (ABS)
warning light ...........................119
fluid, checking and adding ....211
fluid, refill capacities ..............220
fluid, specifications .........223, 225
lubricant specifications ..223, 225
parking ....................................120
shift interlock ..........................121
Bulbs ............................................39
C
Calculating load ........................143
Capacities for refilling fluids ....220
Cargo area shade ........................55
Cassette tape player .............15, 22
CD-single premium ...............18, 26
Cell phone use ............................54
Certification Label ....................227
Changing a tire .........................158
Child safety restraints ..............104
child safety belts ....................104
2004 Escape(204)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
Index
231