2004 DODGE STRATUS SEDAN engine overheat

Cooling System Ð Drain, Flush and Refill
At the intervals shown on the Maintenance Schedules,
the system should be drained, flushed and refilled. The
first change should not be required until 5 years or
100,000 miles (160,000 km), whichever comes first. The
coolant should be flushed and changed every two years
or 36,000 miles (57,600 km) thereafter.
If the solution is dirty and contains a considerable
amount of sediment, clean and flush with a reliable
cooling system cleaner. Follow with a thorough rinsing to
remove all deposits and chemicals. Used automotive
antifreeze is a recyclable commodity. Discard or recycle
as facilities exist in your area.
Selection Of Coolant
Use only the manufacturer's recommended coolant, refer
to Recommended Fluids, Lubricants and Genuine Parts
for correct coolant type.
CAUTION!
Failure to use the proper antifreeze could cause
radiator plugging and engine overheating. Do not
mix antifreeze brands or use plain water alone or
alcohol base antifreeze products. Do not use addi-
tional rust inhibitors or antirust products, as they
may not be compatible with the radiator coolant and
may plug the radiator or heater core.
Adding Coolant
When adding coolant, a solution of 50% ethylene glycol
antifreeze coolant in distilled water should be used. Use
higher concentrations (not to exceed 60%) if temperatures
below -32ÉF (-35ÉC) are anticipated.
Please note that it is the owner's responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
206 MAINTAINING YOUR VEHICLE

Coolant Pressure Cap
The cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant reserve tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
The warning words ªDO NOT OPEN HOTº on the
cooling system pressure cap are a safety precaution.
Never add coolant when the engine is overheated.
Do not loosen or remove the cap to cool an over-
heated engine. Heat causes pressure to build up in
the cooling system. To prevent scalding or injury, do
not remove the pressure cap while the system is hot
or under pressure.
CAUTION!
Be sure to use only the cooling system pressure cap
specified for your vehicle. Use of any other pressure
cap may result in decreased engine cooling system
performance and/or damage to your vehicle.
Disposal Of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. Do not store ethylene glycol based engine
coolant in open containers or allow it to remain in
puddles on the ground. Prevent ingestion by animals or
children. If ingested by a child, contact a physician
immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine off and cold, the coolant level should be between
the ªMINº and ªMAXº marks on the side of the coolant
bottle. Some darkening of the coolant bottle will occur
MAINTAINING YOUR VEHICLE 207
7

Electronic Speed Control.................. 67
Emergency, In Case of
Jacking............................. 174
Emergency Trunk Release................. 24
Emission Control System Maintenance....190,232
Engine............................187,188
Block Heater......................... 132
Break-In Recommendations............... 48
Checking Oil Level.................... 192
Compartment.....................187,188
Cooling............................ 205
Oil .............................192,227
Oil Change Interval................... 193
Oil Selection......................... 194
Oil Synthetic......................... 195
Overheating......................... 172
Partial Zero Emissions Vehicle for 2.4 Liter . . 232
Timing Belt.......................... 198
Engine Oil Viscosity..................194,227
Engine Oil Viscosity Chart................ 194
Entry System, Illuminated................. 15
Exhaust Gas Caution.................... 204
Exhaust System........................ 204Exterior Light Service.................... 222
Filters
Air Cleaner.......................... 196
Automatic Transaxle................... 213
Engine Fuel......................... 196
Engine Oil.......................... 195
Flashers
Hazard Warning...................... 172
Flexible Fuel Vehicles
Cruising Range....................... 168
Engine Oil.......................... 194
Maintenance......................... 169
Replacement Parts.................... 169
Starting............................ 168
Fluid Capacities........................ 227
Fluid Leaks............................ 50
Fluid Level Checks
Automatic Transaxle................... 212
Capacities........................... 227
Fog Light Service....................... 225
Fog Lights..........................64,225
Freeing A Stuck Vehicle.................. 183
INDEX 265
10

Filter.............................. 195
Identification Logo.................167,194
Materials Added to.................... 195
Pressure Gauge....................... 89
Quality..........................167,194
Recommendation..................... 194
Synthetic........................... 195
Onboard Diagnostic System............189,190
Opener, Garage Door..................... 70
Overheating, Engine..................... 172
Owner's Manual....................... 256
Paint Care............................ 214
Paint Damage......................... 214
Panic Alarm........................... 21
Parking Brake......................... 139
Parking On Hill........................ 139
Partial Zero Emissions Vehicle for 2.4 Liter.... 232
Passing Light........................... 64
Pets.................................. 48
Placard, Tire and Loading Information....... 147
Power
Brakes............................. 140Door Locks.......................... 15
Outlet.............................. 77
Seats............................... 58
Steering............................ 142
Steering, Checking.................... 200
Sunroof............................. 75
Windows.........................25,142
Pregnant Women and Seat Belts............. 32
Programmable Electronic Features.........71,74
Programming Transmitters............21,71,74
Radial Ply Tires........................ 153
Radiator Cap.......................... 207
Radio...........................95,104,109
Radio Broadcast Signals................... 94
Radio Operation..................104,109,117
Radio Remote Controls................... 117
Rear Window Defroster.................. 123
Recommended Fluids, Lubricants and Genuine
Parts............................... 228
Reformulated Gasoline................... 160
Refrigerant............................ 200
Reminder, Lights On..................... 64
INDEX 269
10