2004 DODGE SPRINTER jack points

192 WHAT TO DO IN EMERGENCIESSpare Wheel Location for Chassis
1. Loosen thumb nuts by hand and remove.
2. Use wrench to loosen fixing nut to the thread end.
3. Lift spare wheel holder.
4. Turn hooks to the side and lower spare wheel
holder. Remove the spare wheel.
JA CK
WARNING!
To avoid the risk of serious or fatal injuries or vehicle
damage, please bear the following points in mind:
 The jack is intended only for raising the vehicle
briefly, for instance, when changing a wheel. If it is
not designed to enable work to be carried out
underneath the vehicle.
Do not crawl under the jacked-up vehicle. For work
under the vehicle, stands must be used.
 The jack must be placed on a firm, flat surface only.
 Do not change wheels on uphill or downhill
gradients under any circumstances.
 Make sure that no persons are present in the vehicle
when jacking up the vehicle.
 Do not start the engine while the vehicle is raised.
 Make sure that the distance between the underside
of the tires and the ground does not exceed 1.2 in (30
mm). Otherwise the vehicle may tip over.
Freightliner-all.book Pag e 192 Monday, December 1, 2003 2:54 PM

WHAT TO DO IN EMERGENCIES 197
6
Centering wheels with wheel bolts
 If dual assemblies are used, before placement the
inner wheel should be inspected to ensure that all
ball bearing rings are in proper position.
 Install the wheel and snug the wheel bolts.
 Slightly tighten wheel bolts.
 Slowly open jack release valve to lower vehicle until
tire is resting on ground.
 Tighten the wheel bolts in a crosswise pattern to the
specified torque with a torque wrench.
Tightening torque for 8,550 lbs (3,880 kgs)
(vehicle type 2500 C/HC/SHC):
Steel wheel – 177 lbf.ft ±7 lbf.ft (240 N.m ±10 N.m)
Light alloy wheel – 138 lbf.ft ±14 lbf.ft
(190 N.m ±20 N.m)
WARNING!
Incorrect mounting bolts or improperly tightened
mounting bolts can cause the wheel to come off.
To avoid the risk of serious or fatal injuries or ve-
hicle damage, please bear the following points in
mind:• Always replace wheel bolts that are damaged or
rusted.• Never apply oil or grease to wheel bolts• If a wheel hub thread is damaged, you must not
drive the vehicle. Consult a qualified specialist
workshop.
WARNING!
Do not tighten the wheel bolts and wheel nuts
completely while the vehicle is still jacked up.
The vehicle could tip.
Freightliner-all.book Pag e 197 Monday, December 1, 2003 2:54 PM

INDEX 267
10
Interior Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Cargo Area . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Driver and Rear-Seat Passenger/Cargo Area . . . 63
Interior Sensor Protection . . . . . . . . . . . . . . . . . . . . 63
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Intervals, Maintenance . . . . . . . . . . . . . . . . . . . . . . . . 249
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Intrument Cluster
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94JJack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 192
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198LLamps
Acceleration Skid Control . . . . . . . . . . . . . . . . . . . 155
Acceleration Skid Control Warning Lamp . 137, 157
Additional Brake Lamp . . . . . . . . . . . . . . . . . . . . . 240
Anti-Lock Brake System (ABS) Indicator Lamp. 152
Battery Charge Indicator Lamp . . . . . . . . . . . . . . . 95
Brake Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148Brake System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . 98
Electronic Brake Force Distribution . . . . . . . . . . . 148
Engine Control Unit Indicator Lamp . . . . . . . . . . . 99
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . 97
Exit Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243
Indicator Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
License Plate Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 240
Reading Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242
Reserve Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 94
Seat Belt Warning Lamp . . . . . . . . . . . . . . . . . . . . . 38
Side-Marker Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 241
SRS Malfunction Indicator Lamp . . . . . . . . . . . . . . 40
Taillamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Water in Fuel Indicator Lamp . . . . . . . . . . . . . . . . . 96
Lifting Points . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Lighter, Cigar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Lighting, Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Loading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144Freightliner-all.book Pag e 267 Monday, December 1, 2003 2:54 PM