2004 DODGE RAM 1500 GAS automatic transmission fluid

Automatic Transmission Fluid and Filter Change
To obtain best performance and long life for automatic
transmissions, the manufacturer recommends that they
be given regular maintenance service by an Authorized
Dodge Dealer or Service Center.
It is important that proper lubricant is used in the
transmission. Refer to Recommended Fluids, Lubricants
and Genuine Parts for correct fluid type.
The fluid and filter(s) should be changed as specified in
the Maintenance Schedule (Section 8).
NOTE:If the transmission is disassembled for any
reason, the fluid and filter(s) should be changed.
Special Additives
The manufacturer strongly recommends against the ad-
dition of any additives to the transmission. Exception to
this policy is the use of special dyes to aid in detectingfluid leaks. The use of transmission sealers should be
avoided, since they may adversely affect seals.
Front Wheel Bearings
Front wheel bearings for all Dodge Ram Trucks are
sealed-for-life. They do not require greasing or seal
replacement. In some instances, these bearings will
ªpurgeº excess grease and the bearing will look slightly
wet. This is normal. Periodic inspection for excess play is
recommended.
Rear Wheel Bearings Ð Manufacturer's Axles
These bearings are normally considered permanently
lubricated. Cleaning and repacking is required only
when axle shafts are removed or in case of extreme water
or dust contamination.
MAINTAINING YOUR VEHICLE 355
7

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MopartATF+4, Automatic Transmission Fluid
Transfer Case MopartATF+4, Automatic Transmission Fluid
Manual Transmission Fluid NV 3500 MopartªManual Transmission Fluidº P/N 4874464.
Manual Transmission Fluid NV 4500 75W-85 Synthetic, API grade GL4, MopartP/N 4874459.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P.
1500 Model Front Axle (4X4) GL-5 SAE 75W-90
1500 Model Rear Axle MopartSynthetic Gear Lubricant SAE 75W-140 (MS-8985). Limited-Slip
Rear Axles on 1500 Models Require the addition of 118 ml (4 oz.) Mopart
limited slip additive.
2500/3500 Model Front and Rear
AxleSynthetic, GL-5 SAE, 75W-90. Limited-Slip 10.5/11.5 inch Rear AxlesDO
NOT REQUIREa limited slip additive.
Brake Master Cylinder MopartDOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not
available, then DOT 4 is acceptable. Use only recommended brake fluids.
Power Steering Reservoir MopartATF+4, Automatic Transmission Fluid
382 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant bottle, brake master
cylinder, and transmission and add as needed.
²Check all lights and all other electrical items for correct
operation.
At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the CV joints (if equipped) and front suspen-
sion components.
²Check the automatic transmission fluid level.
²Check the manual transmission fluid level.
²Check the coolant level, hoses, and clamps.
Tire Rotation
²Rotate the tires at 6,000 miles (10 000 km).
386 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................259,295
Air Cleaner, Engine...................334,357
Air Conditioner Maintenance............327,338
Air Conditioning Refrigerant.......327,328,338,339
Air Conditioning System.............187,327,338
Air Conditioning System, Zone Control........ 191
Air Pressure, Tires....................244,251
Airbag..............................45,50
Airbag Light.........................70,144
Airbag On/Off Switch..................... 50
Airbag, Side............................ 53
Alarm..............................29,147
Alignment and Balance................... 250
Alterations/Modifications, Vehicle............. 7
Antifreeze (Engine Coolant)..............346,379
Anti-Lock Brake System................... 231
Anti-Lock Warning Light...............148,232
Anti-Theft System.....................29,147
Appearance Care........................ 361Ashtray............................... 127
Automatic Transmission
Adding Fluid......................... 353
Fluid and Filter Changes................. 355
Fluid Level Check...................... 352
Fluid Type........................354,382
Shift Indicator........................ 147
Shifting............................. 208
Special Additives...................... 355
Axle Fluid.......................272,350,382
Axle Lubrication.....................272,350
Ball Joints............................. 340
Battery............................... 337
Emergency Starting..................... 312
Bearings.............................. 355
Belts, Drive............................ 333
Belts, Seat.............................. 34
Body Mechanism Lubrication............... 341
414 INDEX

Exhaust System.......................69,343
Exterior Lighting........................ 101
Filters
Air Cleaner........................334,357
Engine Fuel.......................... 334
Engine Oil........................333,381
Engine Oil Disposal.................... 332
Flashers
Turn Signal.......................... 103
Flat Tire Stowage.....................301,311
Flexible Fuel Vehicles
Cruising Range........................ 265
Engine Oil........................... 264
Fuel Requirements..................262,263
Maintenance.......................... 265
Replacement Parts..................... 265
Starting............................. 265
Flooded Engine Starting................... 206Fluid, Brake........................... 382
Fluid Capacities......................... 379
Fluid Level Checks
Automatic Transmission................. 352
Power Steering........................ 339
Fog Lights..........................102,378
Fold Flat Load Floor..................... 130
Four Wheel Drive....................... 216
Four-Way Hazard Flasher.................. 294
Freeing A Stuck Vehicle................... 316
Front Axle............................. 350
Front Wheel Bearings..................... 355
Fuel................................. 256
Adding............................. 259
Filter............................... 334
Gauge.............................. 150
Octane Rating......................256,381
Requirements......................256,379
Tank Capacity........................ 379
418 INDEX

Lumbar Support......................... 94
Maintenance........................... 327
Maintenance Free Battery.................. 337
Maintenance Procedures................... 327
Maintenance Schedule.................... 384
Schedule9A9......................... 397
Schedule9B9.......................... 387
Malfunction Indicator Light................ 325
Manual, Service......................... 410
Manual Transmission..................213,351
Fluid Level Check...................... 351
Lubricant Selection..................352,382
Shift Speeds.......................214,216
Mirrors................................ 75
Automatic Dimming..................... 76
Electric Powered....................... 77
Outside.............................. 76
Rearview............................. 75Trailer Towing......................79,278
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................327,409
Multi-Function Control Lever............... 103
Noise Control
Maintenance.......................... 356
Tampering Prohibited................356,357
Noise Emission Warranty.................. 358
Occupant Restraints....................... 33
Octane Rating, Gasoline................... 256
Odometer..........................148,150
Trip .............................148,150
Off-Pavement Driving.................... 291
Off-Road Driving........................ 291
Oil, Engine.........................329,381
Capacity............................ 379
Change Interval....................... 330
422 INDEX

Inflation Pressures..................... 244
Jacking............................. 302
Load Capacity.....................239,240
Radial.............................. 247
Replacement......................... 249
Rotation..........................253,386
Safety...........................234,243
Sizes............................... 236
Snow Tires........................... 253
Spare Tire........................... 301
Spinning............................ 248
Tread Wear Indicators................... 249
Wheel Mounting....................... 302
Wheel Nut Torque..................... 307
Tongue Weight/Trailer Weight.............. 276
Torque Converter Clutch.................. 212
Tow Hooks, Emergency................... 316
Towing
Disabled Vehicle....................... 317Guide.............................. 277
Recreational.......................... 284
Trailering............................ 272
Weight.............................. 277
Traction.............................. 292
Trailer Towing.......................... 270
Hitches............................. 274
Mirrors...........................79,278
Tips ................................ 278
Trailer and Tongue Weight................ 276
Trailer Towing Guide..................... 277
Trailer Weight.......................... 277
Transfer Case........................... 351
Fluid............................... 382
Transmission
Automatic........................208,352
Fluid............................... 382
Maintenance.......................351,352
Manual........................205,213,351
INDEX 427
10