2004 DODGE GRAND CARAVAN wiper

If it is necessary to use the accessories while being towed
(wipers, defrosters, etc.), the key must be in the ON
position, not the ACCESSORY position. Make certain the
transmission remains in NEUTRAL.
Without The Ignition Key
Special care must be taken when the vehicle is towed
with the ignition in the LOCK position. The only ap-
proved method of towing with out the ignition key is
with a flat bed truck. Proper towing equipment is neces-
sary to prevent damage to the vehicle. TOWING THIS VEHICLE BEHIND ANOTHER
VEHICLE (Flat towing with all four wheels on the
ground)
Flat towing of vehicles equipped with an automatic
transmission, is only permitted within the limitations
described in this section.
TOWING THIS VEHICLE BEHIND ANOTHER
VEHICLE WITH A TOW DOLLEY
The manufacture does not recommend that you tow an
All-Wheel Drive (AWD) or front wheel drive vehicle on a
tow dolley. Vehicle damage may occur. WHAT TO DO IN EMERGENCIES 293
6

N Front Suspension Ball Joints ..............314
N Steering Shaft Seal ....................314
N Steering Linkage ......................315
N Drive Shaft Universal Joints ..............315
N Body Lubrication .....................315
N Windshield Wiper Blades ................316
N Windshield And Rear Window Washers .....316
N Exhaust System ......................317
N Cooling System .......................318
N Hoses And Vacuum/Vapor Harnesses .......322
N Brakes .............................323
N Master Cylinder Ð ABS Brakes Brake Fluid
Level Check .........................324 N Fuel System Hoses ....................326
N Automatic Transmission ................326
N All Wheel Drive (AWD) .................329
N Front And Rear Wheel Bearings ...........330
N Appearance Care And Protection From
Corrosion ...........................330
N Cleaning The Instrument Panel And
Underseat Cup Holders .................334
m Integrated Power Module (IPM) ............336
m Vehicle Storage ........................337
m Replacement Light Bulbs .................338
m Bulb Replacement ......................339
N Headlights ..........................339296 MAINTAINING YOUR VEHICLE

Windshield Wiper Blades
The rubber edges of the wiper blades and the windshield
should be cleaned periodically with a sponge or soft cloth
and a mild nonabrasive cleaner. This will remove accu-
mulations of salt or road film.
Operation of the wipers on dry glass for long periods
may cause deterioration of the wiper blades. Always use
washer fluid when using the wipers to remove salt or dirt
from a dry windshield.
Avoid using the wiper blades to remove frost or ice from
the windshield. Keep the blade rubber out of contact with
petroleum products such as engine oil, gasoline, etc.
Windshield and Rear Window Washers
The fluid reservoir for the windshield washers and the
rear window washer is shared. It is located in the engine
compartment and should be checked for fluid level at
regular intervals. Fill the reservoir with windshield washer solvent (not radiator antifreeze) and operate the
system for a few seconds to flush out the residual water.
The washer fluid reservoir will hold a full gallon of fluid
when the Low Washer Fluid Light illuminates.316 MAINTAINING YOUR VEHICLE

defrosters or windshields equipped with a windshield
wiper de-icer. Do not use scrapers or other sharp instru-
ments which may scratch the elements.
When cleaning the rear view mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft tissue. Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage will also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning The Instrument Panel and Underseat
Cup Holders
Removal
Remove the ash receiver from the convenience tray if
there is a smoker's package in your vehicle. With your
index finger, locate the stop tab located at the rear of the
convenience tray.334 MAINTAINING YOUR VEHICLE

High Beam/Low Beam Select Switch ........ 103
Lights On Reminder .................... 101
Replacing ............................ 339
Time Delay .......................... 101
Heated Seats ............................ 82
Heater ............................... 199
Heater, Engine Block ..................... 230
Homelink Transmitter ..................... 119
Hood Release ........................... 96
Hoses ............................. 322,326
Ignition
Key ................................. 12
Illuminated Entry ........................ 16
Immobilizer ............................ 13
Indicator, Traction Control ................. 156
Infant Restraint .......................... 59
Information Center .................... 1 15,159
Information Center, Vehicle .............. 1 15,159 Inside Rearview Mirror .................... 77
Instrument Cluster ................. 149,150,151
Instrument Panel and Controls .............. 148
Instrument Panel Lens Cleaning ............. 334
Integrated Child Seat ...................... 58
Integrated Power Module .................. 336
Interior Appearance Care .................. 333
Interior Fuses .......................... 336
Interior Lights ......................... 98,99
Intermittent Wipers ................. 104,219,220
Introduction ............................. 4
Jack Location ........................... 283
Jack Operation ....................... 282,285
Jump Starting .......................... 288
Key, Programming ........................ 15
Key, Replacement ........................ 15
Key, Sentry ............................. 13388 INDEX

Rear Window Features .................... 219
Rear Wiper/Washer ................ 219,220,221
Rearview Mirrors ........................ 77
Reclining Front Seats ...................... 83
Recommended Fluids, Lubricants and Genuine
Parts ............................... 344
Remote Keyless Entry ..................... 20
Remote Sound System Controls .............. 195
Removable Floor Console .................. 132
Replacement Tires .................... 257,259
Reporting Safety Defects ................... 376
Restraint, Head .......................... 82
Restraints, Child ....................... 58,64
Restraints, Infant ......................... 59
Rocking Vehicle When Stuck ................ 291
Roof Rack ............................. 139
Rotation, Tires .......................... 265
Safety Checks Inside Vehicle ................. 71 Safety Checks Outside Vehicle ............... 72
Safety, Exhaust Gas ....................... 36
Safety Information, Tire ................... 242
Safety Tips ............................. 71
Schedule, Maintenance .................... 348
Seat Belt Maintenance .................... 334
Seat Belts .............................. 38
Adjustable Shoulder Belt .................. 44
Adjustable Upper Shoulder Anchorage ........ 44
And Pregnant Women ................... 48
Center Lap Belt ........................ 47
Child Restraint ......................... 58
Extender ............................. 48
Front Seat ............................ 39
Pretensioners .......................... 47
Rear Seat ............................. 39
Untwisting Procedure .................... 45
Seats ................................. 80
Adjustment ........................... 80 INDEX 393
10

Vehicle Information Center ................. 115
Vehicle Loading ...................... 272,274
Vehicle Modifications/Alterations .............. 7
Vehicle Storage ....................... 217,337
Vehicle Theft Alarm ....................... 26
Video Entertainment System ................ 187
Warning Flasher, Hazard .................. 280
Warnings and Cautions ..................... 6
Warranty Information ..................... 375
Washer, Adding Fluid .................. 221,316
Washer, Rear ........................ 219,221
Washing Vehicle ......................... 331
Wheel Alignment and Balance ............... 258
Wheel and Wheel Trim .................... 332 Wheel Bearings ......................... 330
Wind Buffeting ....................... 38,127
Window Fogging ........................ 218
Windows .............................. 36
Power ............................... 37
Rear Vent ............................ 36
Windshield Washers ................... 103,316
Windshield Wiper Blades .................. 316
Windshield Wipers ....................... 103
Wiper Blade Replacement .................. 316
Wiper, Rear ............................ 220
Wipers, Intermittent ...................... 104
Zone Control ........................... 200 INDEX 397
10