2004 DODGE DURANGO wheel

Front Suspension Ball Joints
The ball joints and seals should be inspected whenever
the vehicle is serviced for other reasons. Damaged seals
should be replaced to prevent leakage or contamination
of the grease.
Drive Shaft Constant Velocity Joints
All four wheel drive models are equipped with four
constant velocity joints. Periodic lubrication of these
joints is not required. However, the joint boot should be
inspected for external leakage or damage periodically. If
external leakage or damage is evident, the joint boot and
grease should be replaced immediately. Continued op-
eration could result in failure of the joint due to water
and dirt contamination of the grease. This would require
complete replacement of the joint assembly. Refer to the
Service Manual for the detailed replacement procedure.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors,liftgate and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism
and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MopartLock
Cylinder Lubricant directly into the lock cylinder.
304 MAINTAINING YOUR VEHICLE

Front Axle
Front Axle fluid level should be at the bottom of the filler
hole plug.
Selection of Lubricating Grease
The National Lubricating Grease Institute (NLGI) has
developed a symbol (Certification Mark) to aid the
vehicle owner in the proper selection of grease for chassis
components. This symbol, an example shown below, is
located on the grease container and identifies the appli-
cation and quality of the grease.There are two groups
identified, those for wheel
bearings (Letter ªGº) and
those for chassis (Letter
ªLº) lubrication. Perfor-
mance categories within
these groups result in dual
letter designations for
each group. The letter des-
ignations shown in the ex-
ample are the highest
quality level available and when combined as shown can
be used for chassis lubrication. Use only those greases
that have the NLGI symbol on the container along with
the proper quality level for your application.
320 MAINTAINING YOUR VEHICLE

²Avoid using abrasive compounds and power buffing
that may diminish the gloss or thin out the paint
finish.
CAUTION!
Do not use abrasive or strong cleaning materials
such as steel wool or scouring powder, which will
scratch metal and painted surfaces.
Special Care
²
If you drive on salted or dusty roads or if you drive
near the ocean, hose off the undercarriage at least once
a month.
²It is important that the drain holes in the lower edges
of the doors, rocker panels and liftgate be kept clear
and open.
²If you detect any stone chips or scratches in the paint,
touch them up immediately. The cost of such repairs is
considered the responsibility of the owner.
²If your vehicle is damaged due to an accident or
similar cause which destroys the paint and protective
coating have your vehicle repaired as soon as possible.
The cost of such repairs is considered the responsibil-
ity of the owner.
²All wheels and wheel trim, especially aluminum and
chrome plated wheels should be cleaned regularly
with mild soap and water to prevent corrosion. To
remove heavy soil, select a nonabrasive, non-acidic
cleaner. Do not use scouring pads, steel wool, a bristle
brush or metal polishes. Only Mopartcleaners are
recommended. Do not use oven cleaner. Avoid auto-
matic car washes that use acidic solutions or harsh
brushes that may damage the wheels' protective fin-
ish.
322 MAINTAINING YOUR VEHICLE

²If you carry special cargo such as chemicals, fertilizers,
de-icer salt, etc., be sure that such materials are well
packaged and sealed.
²If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
²Use Moparttouch up paint on scratches as soon as
possible. Your dealer has touch up paint to match the
color of your vehicle.
Interior Care
Use MopartFabric Cleaner to clean fabric upholstery
and carpeting.
Use MopartVinyl Cleaner to clean vinyl upholstery and
trim.
MopartTotal Clean is specifically recommended for
leather upholstery.Your leather upholstery can be best preserved by regular
cleaning with a damp soft cloth. Small particles of dirt
can act as an abrasive and damage the leather upholstery
and should be removed promptly with a damp cloth.
Stubborn soils can be removed easily with a soft cloth
and MopartTotal Clean. Care should be taken to avoid
soaking your leather upholstery with any liquid. Please
do not use polishes, oils, cleaning fluids, solvents, deter-
gents, or ammonia based cleaners to clean your leather
upholstery. Application of a leather conditioner is not
required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes.
Many are potentially flammable, and if used in
closed areas they may cause respiratory harm.
MAINTAINING YOUR VEHICLE 323
7

2. Remove one nut that attaches the headlight to the
inner fender panel. Access to the nut is possible by
removing the fender panel access door which is located
in the wheel liner.
3. Grasp the headlight and pull firmly to disengage the
headlight from the fender panel.
4. While firmly holding the headlight in your hands
disconnect all connectors by following the procedure
described in step number 5 below.5. Remove the bulb connector from the headlight making
sure to pull and release the red tab on all connectors.
Loosen the connector by pressing down on the black
and/or green release which is located below or above the
red tab. The green release is located above the red tab on
the 9008, the black release is located above the 3457AK
red tab, and the black release is located below the 194 red
tab.
6. Remove and replace the bulb.
NOTE:These are Halogen bulbs. Take care not to touch
the bulb with your fingers. Body oils from your fingers
could cause excessive heat build-up which reduces bulb
life.
328 MAINTAINING YOUR VEHICLE

Transfer Case......................... 319
Fog Lights..........................107,335
Folding Rear Seat......................91,93
Four Wheel Drive....................... 208
Operation........................... 208
Four-Way Hazard Flasher.................. 270
Freeing A Stuck Vehicle................... 221
Front Axle............................. 320
Fuel................................. 242
Adding............................. 245
Filter............................... 299
Gauge.............................. 146
Octane Rating......................242,337
Requirements......................242,335
Tank Capacity........................ 335
Fueling............................... 245
Fuses................................ 325
Garage Door Opener..................... 126GasCap .............................. 246
Gas Gauge............................ 146
Gasoline.............................. 242
Gasoline, Reformulated................... 243
Gauges
Coolant Temperature.................... 146
Fuel................................ 146
Odometer........................... 153
Speedometer......................... 148
Tachometer.......................... 149
Gear Ranges........................... 203
Glass Cleaning.......................... 324
Grease............................... 320
Gross Axle Weight Rating.................. 251
Gross Cargo Weight...................... 250
GVWR............................251,253
Hands-Free Phone........................ 74
Hazard Warning Flasher................... 270
INDEX 375
10

Turn Signal........................108,329
Warning (Instrument Cluster Description)..... 146
Washer Fluid......................... 153
Loading Vehicle......................... 250
Tires ............................... 226
Locks................................. 13
Auto Unlock.......................... 16
Automatic Door........................ 15
Child Protection........................ 17
Door................................ 13
Ignition.............................. 12
Keys................................. 9
Power Door........................... 14
Steering Wheel......................... 12
Lower Anchors and Tether for CHildren (LATCH) . 54
Lubricating Oil......................... 320
Lubrication, Body....................... 304
Lug Nuts............................. 278
Luggage Carrier......................... 139Lumbar Support......................... 88
Maintenance Free Battery.................. 300
Maintenance Procedures................... 292
Maintenance Schedule.................... 341
Schedule9A9......................... 353
Schedule9B9.......................... 343
Malfunction Indicator Light..............152,290
Manual, Service......................... 366
Manual Transmission
Lubricant Selection..................... 338
Map/Reading Lights..................... 120
Memory Seat........................... 97
Mirrors................................ 70
Automatic Dimming...................70,74
Electric Powered....................... 72
Heated.............................. 73
Memory............................. 97
Outside.............................. 71
378 INDEX

Emergency (Jump Starting)............... 280
Engine Block Heater.................... 202
Engine Fails to Start.................... 201
Starting Procedures...................... 200
Steering
Column Controls...................... 108
Column Lock.......................... 12
Power...........................220,303
Wheel, Tilt........................... 113
Steering Wheel Mounted Sound System
Controls............................. 177
Storage, Vehicle......................... 326
Stuck, Freeing.......................... 221
Sun Roof.............................. 133
Supplemental Tire Pressure Information........ 239
Synthetic Engine Oil...................... 296
Tachometer............................ 149
Taillights.............................. 329Temperature Gauge, Engine Coolant.......... 146
Tether Anchor, Child Restraint............... 54
Theft System Arming...................... 25
Theft System Disarming.................... 25
Thermostat............................ 311
Tilt Steering Column..................... 113
Tire and Loading Information Placard......226,239
Tire Identification Number (TIN)............. 225
Tire Markings.......................... 221
Tire Safety Information.................... 221
Tires ...............................64,230
Air Pressure.......................... 230
Alignment........................... 238
Chains.............................. 239
Changing............................ 272
Compact Spare........................ 234
General Information.................... 230
High Speed.......................... 233
Inflation Pressures..................... 231
INDEX 383
10