2004 DODGE CARAVAN warning light

²The trailer tongue load must be considered as part of
the combined weight of occupants and cargo, and
should never exceed the weight referenced on the Tire
and Loading Information placard. Refer to the Tire±
Safety Information Section in this manual.
²The ªDº range can be selected when towing. However,
if frequent shifting occurs while in this range, the ª3º
range must be selected.
NOTE:Using the ª3º range while operating the vehicle
under heavy operating conditions will improve perfor-
mance and extend transaxle life by reducing excessive
shifting and heat build up.
WARNING!
Connecting trailer brakes to your vehicle's hydraulic
brake lines can overload your brake system and
cause it to fail. You might not have brakes when you
need them and could have an accident.
²Do not attempt to tow a trailer while using a compact
spare tire.
²Whenever you pull a trailer, regardless of the trailer
size, stop lights and turn signals on the trailer are
recommended for motoring safety.
²The automatic transaxle fluid and filter should be
changed if you REGULARLY tow a trailer for more
than 45 minutes of continuous operation. See Schedule
ªBº in section 8 of this manual for transaxle fluid
change intervals.
NOTE:Check the automatic transaxle fluid level before
towing. Fluid discoloration, or a burnt odor, shows the
need for a transmission fluid and filter change.
276 STARTING AND OPERATING

properly engaged in the described location.Do not raise
the vehicle until you are sure the jack is securely
engaged.
5. Raise the vehicle by turning the jack screw to the right,
using the swivel wrench. Raise the vehicle only until the
tire just clears the surface and enough clearance is
obtained to install the spare tire. Minimum tire lift
provides maximum stability.
WARNING!
Raising the vehicle higher than necessary can make
the vehicle less stable. It could slip off the jack and
hurt someone near it. Raise the vehicle only enough
to remove the tire.
6. Remove the wheel lug nuts, for vehicles with wheel
covers, remove the cover from the wheel by hand. Do not
pry the wheel cover off. Then pull the wheel off the hub.7. Install the spare wheel, for vehicles with wheel covers,
align the notch in the wheel cover with the valve stem on
the wheel. Install the cover on the wheel by hand only
and install the wheel lug nuts with the cone shaped end
of the nut toward the wheel. Lightly tighten the nuts. To
avoid the risk of forcing the vehicle off the jack, do not
tighten the lug nuts fully until the vehicle has been
lowered.
NOTE:Do not install the wheel cover on the compact
spare.
Do not use a hammer or force to install the wheel covers.
8. Lower the vehicle by turning the jack screw to the left.
9. Finish tightening the lug nuts. Push down on the
wrench while tightening for increased leverage. Alternate
nuts until each nut has been tightened twice. Correct
wheel nut tightness is 130 N´m (95 ft. lbs). If in doubt
286 WHAT TO DO IN EMERGENCIES

Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:Often, fluid such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to facilitate the assembly of hoses to couplings.
Therefore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping of
hot fluid when systems are under pressure (during
vehicle operation), should be noted before hose is re-
placed based on leakage.
NOTE:Inspection of brake hoses should be performed
whenever the brake system is serviced and every engine
oil change. Inspect hydraulic brake hoses for surface
cracking, scuffing, or worn spots. If there is any evidence
of cracking, scuffing, or worn spots, the hose should bereplaced immediately! Eventual deterioration of the hose
can take place resulting in a possibility of a burst failure.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Master Cylinder Ð ABS Brakes Brake Fluid Level
Check
The fluid level in the master cylinder should be checked
when performing underhood services, or immediately if
the brake system warning light indicates system failure.
Clean the top of the master cylinder area before removing
the cap. Add fluid to bring the level up to the top of the
ªFULLº mark on the side of the master cylinder reservoir.
324 MAINTAINING YOUR VEHICLE

Adding Fuel........................... 270
Adding Washer Fluid..................221,316
Additives, Fuel......................... 268
Adjustable Pedals....................... 106
Air Conditioner Maintenance............... 312
Air Conditioning.....................199,203
Air Conditioning Controls................. 199
Air Conditioning Filter.................219,313
Air Conditioning, Operating Tips............ 218
Air Conditioning, Rear Zone.............206,214
Air Conditioning Refrigerant............... 312
Air Conditioning System..........199,203,208,312
Air Conditioning System, Zone Control........ 200
Air Pressure, Tires....................... 252
Airbag................................ 48
Airbag Deployment....................... 55
Airbag Light.....................52,57,72,152
Airbag Maintenance....................... 57
Airbag, Side............................ 54Alarm Light........................... 154
Alarm System........................... 26
Alignment and Balance................... 258
All Wheel Drive...................235,259,329
Alterations/Modifications, Vehicle............. 7
Antifreeze Disposal...................... 321
Antifreeze (Engine Coolant)..............319,320
Anti-Lock Brake System................... 237
Anti-Lock Warning Light.................. 153
Anti-Theft Security Alarm.................. 26
Appearance Care........................ 330
Ashtray............................... 130
Auto Down Power Windows................ 37
Automatic Dimming Mirror................. 77
Automatic Door Locks..................... 19
Automatic Headlights.................... 100
Automatic Temperature Control............. 208
Automatic Transaxle...................231,326
Adding Fluid......................... 345
382 INDEX

Filter............................... 328
Fluid and Filter Changes................. 328
Fluid Level Check...................... 327
Interlock System....................... 232
Reset Mode.......................... 233
Selection Of Lubricant................326,345
Shifting............................. 233
Special Additives...................... 329
Ball Joints............................. 314
Battery............................... 311
Gas Caution.......................... 311
Jump Starting......................... 288
Keyless Transmitter Replacement............ 25
Saving Feature........................ 101
Bearings.............................. 330
Belts, Drive............................ 307
Body Mechanism Lubrication............... 315
B-Pillar Location........................ 247Brake, Parking.......................... 235
Brake System........................237,323
Anti-Lock........................... 237
Fluid Check.......................324,345
Hoses.............................. 323
Warning Light........................ 151
Brake/Transmission Interlock............... 232
Break-In Recommendations, New Vehicle........ 70
Bulb Replacement....................... 339
Bulbs, Light............................ 338
Calibration, Compass..................... 112
Capacities, Fluid........................ 343
Caps, Filler
Fuel................................ 270
Radiator............................ 320
Car Washes............................ 331
Carbon Monoxide Warning................. 269
Cargo ................................ 135
INDEX 383
10

Air Cleaner Filter...................... 308
Block Heater......................... 230
Break-In Recommendations................ 70
Checking Oil Level..................... 303
Compartment......................298,299
Coolant............................. 344
Cooling............................. 318
Exhaust Gas Caution..................36,269
Fails to Start.......................227,229
Fuel Requirements..................... 266
Oil ..............................303,344
Oil Change Interval.................... 305
Oil Selection.......................... 305
Oil Synthetic......................... 307
Overheating.......................... 281
Temperature Gauge..................... 154
Exhaust Gas Caution..............36,71,269,317
Exhaust System......................... 317
Exterior Folding Mirrors................... 78Filters
Air Cleaner.......................... 308
Air Conditioning....................219,313
Automatic Transaxle.................... 328
Engine Fuel.......................... 309
Engine Oil........................307,344
Engine Oil Disposal.................... 307
Flashers
Hazard Warning....................... 280
Turn Signal..................158,159,340,342
Fluid Capacities......................... 343
Fluid Leaks............................. 72
Fluid Level Checks
Automatic Transaxle.................... 327
Brake............................... 345
Power Steering.....................314,345
Fog Light Service........................ 341
Fog Lights..........................102,341
Freeing A Stuck Vehicle................... 291
386 INDEX

Fuel................................. 266
Adding............................. 270
Additives............................ 268
Clean Air............................ 266
Filler Cap............................ 270
Filter............................... 309
Gasoline............................ 266
Gauge.............................. 151
Hoses.............................. 326
Light............................... 151
Octane Rating......................266,344
Requirements......................... 266
Tank Capacity........................ 343
Fueling............................... 270
Fuses................................ 336
Garage Door Opener..................... 119
GasCap .............................. 270
Gasoline.............................. 266Gasoline, Clean Air...................... 266
Gasoline, Reformulated................... 267
Gauges
Coolant Temperature.................... 154
Fuel................................ 151
Speedometer......................... 151
Tachometer.......................... 153
Gearshift.............................. 233
General Information..................16,25,263
Glass Cleaning.......................... 333
Grocery Bag Retainer...................... 91
Gross Axle Weight Rating.................. 273
Gross Vehicle Weight Rating................ 273
Hazard Warning Flasher................... 280
Head Phones........................... 192
Head Restraints.......................... 82
Headlights............................. 99
Bulb Replacement...................... 339
INDEX 387
10

Key-In Reminder......................... 13
Keyless Entry System...................... 20
Keys................................. 12
Knee Bolster..........................52,54
Lap/Shoulder Belts....................... 39
LATCH (Lower Anchors and Tether for CHildren) . 62
Latches
Hood............................... 96
Lead Free Gasoline...................... 266
Liftgate................................ 33
Lights...............................72,98
Airbag........................52,57,72,152
Alarm.............................. 154
Anti-Lock........................... 153
Automatic Headlights................... 100
Back-Up............................. 342
Battery Saver......................... 101
Brake Warning........................ 151Bulb Replacement...................338,339
Center Mounted Stop................... 343
Cruise.............................. 157
Dimmer Switch, Headlight................ 99
Door Ajar........................... 151
Engine Temperature Warning.............. 154
Fog .............................102,341
Hazard Warning Flasher................. 280
Headlight Switch....................... 99
Headlights........................... 339
Headlights On Reminder................. 101
High Beam Indicator.................158,159
High Beam/Low Beam Select............. 103
Illuminated Entry....................... 16
Interior............................98,99
License............................. 343
Liftgate Ajar.......................... 151
Lights On Reminder.................... 101
Low Fuel............................ 151
INDEX 389
10