2004 Citroen XSARA Xsara 2

Downloaded from www.Manualslib.com manuals search engine 456
BRAKES
BRAKE SPECIFICATIONS XSARA PICASSO
Braking system specifications
“X”braking circuit.
Front: disc brakes, ventilated. Rear:drum brakes with automatic adjustment.
Cable operated handbrake acting on the rear wheels.
Load sensitive braking compensator
(non ABS versions).
(1) Hydraulic valve block «ABS Bosch 5.3»or(1) Hydraulic valve block + ECU.(2) Load sensitive braking compensator (according to version).
B3FP09HCB3FP08ND
2
1

Downloaded from www.Manualslib.com manuals search engine 457
BRAKES
B3FP11XD
HANDBRAKE (Adjustment)
XSARA PICASSO
Adjustment.
Remove the handbrake trim (1).
Unclip the sounddeadening (2).
Raise and support the vehicle with the rear wheels
hanging free.
Check the correct routing of the brake cables under the
vehicle.
Apply and release the handbrake
4 times.
Set the handbrake to the 5th notch.
Tighten the nut
(3)until the rear brakes are applied.
Pull the handbrake lever vigorously 4 to 5 times.
Set the handbrake to the 5th notch.
Check that the rear brakes are applied.
With the handbrake released, check that the wheelscan be turned freely by hand.
Lower the vehicle.Refit the sounddeadening
(2)and the handbrake trim (1).

Downloaded from www.Manualslib.com manuals search engine 458
BRAKESBLEEDING THE BRAKESXSARA PICASSO
Tools.Bleeding equipment of type «LURO» or similar.IMPERATIVE: For bleeding the secondary circuit, use ELIT, LEXIA or PROXIA diagnostic tools.
Draining.
Drain the brake fluid reservoir as empty as possible using a syringe.
Disconnect the brake fluid warning lamp connector.Retrieve the brake fluid reservoir from its supply pipes by pulling upwards.
Finish emptying the reservoir of brake fluid.
Clean the brake fluid reservoir.
Refit the brake fluid reservoir.
Reconnect the brake fluid warning lamp connector.
Filling.Refill the reservoir with brake fluid.WARNING:Use only the recommended hydraulic fluids.
Bleeding.
NOTE:Two technicians are required.
IMPERATIVE:During bleed operations, ensure that the level of brake fluid is maintained in the
reservoir and top it up, use only new brake fluid.
Bleed each wheel cylinder, proceeding in the following order:
Rear right hand wheel.
Front left hand wheel.
Rear left hand wheel.
Front right hand wheel.

Downloaded from www.Manualslib.com manuals search engine 466
ELECTRICAL
SYSTEM
Vehicles/models Gearboxes Class Climate
1C
1.4iT
2F
3GF
1C
XSARA 1.4i Réfri M T
3F
GF
2C
1.4i Réfri + DA T
3F
GF
STARTER MOTORS
XSARA

Downloaded from www.Manualslib.com manuals search engine 467
ELECTRICAL
SYSTEM
Vehicles/models Gearboxes Class Climate
C
MT
F
1.6i 16V3GF
C
AT
F
XSARAGF
3C
MT
4F
2.0i 16V GF
3C
AT
4F
GF
STARTER MOTORS
XSARA

Downloaded from www.Manualslib.com manuals search engine 468
ELECTRICAL
SYSTEM
Vehicles/models Gearboxes Class Climate
3C
2.0i 16VT
4F
GF
4C
XSARA 1.9 D M T
5F
6GF
4C
2.0 HDiT
6F
GF
STARTER MOTORS
XSARA

Downloaded from www.Manualslib.com manuals search engine 469
ELECTRICAL
SYSTEM
Vehicles/models Gearboxes Class Climate
5C
2.0 HDi M T
6F
GF
6C
XSARA A T
6+F
GF
4C
1.4 HDi M T
5F
GF
STARTER MOTORS
XSARA

Downloaded from www.Manualslib.com manuals search engine 470
ELECTRICAL
SYSTEM
Vehicles/models Gearboxes Class Climate
1C
T
2F
3GF
1C
1.6iT
3F
XSARA PICASSOMGF
2C
T
3F
GF
C
1.8i 16V3T
F
4GF
STARTER MOTORS
XSARA PICASSO