2004 CHRYSLER PT CRUISER spare tire

WARNING!
Connecting trailer brakes to your vehicle's hydraulic
brake lines can overload your brake system and
cause it to fail. You might not have brakes when you
need them and could have an accident.
²Do not attempt to tow a trailer while using a compact
spare tire.
²Whenever you pull a trailer, regardless of the trailer
size, stop lights and turn signals on the trailer are
recommended for motoring safety.
²The automatic transaxle fluid and filter should be
changed if you REGULARLY tow a trailer for more
than 45 minutes of continuous operation. See Schedule
ªBº in section 8 of this manual for transaxle fluid
change intervals.NOTE:Check the automatic transaxle fluid level before
towing.
NOTE:For vehicles equipped with Autostick. By using
the Autostick modes, and selecting a specific gear range,
frequent shifting can be avoided. The highest gear range
should be selected that allows for adequate performance.
For example, choose ª4º if the desired speed can be
maintained. Choose ª3º or ª2º if needed to maintain the
desired speed.
NOTE:Extended driving at high RPM should be
avoided to prevent excess heat generation. A reduction in
vehicle speed may be required to avoid extended driving
at high RPM. Return to a higher gear range or vehicle
speed when road conditions and RPM level allows.
STARTING AND OPERATING 225
5

WHAT TO DO IN EMERGENCIES
CONTENTS
mHazard Warning Flasher..................228
mIf Your Engine Overheats.................228
mJacking And Tire Changing................230
NJack Location........................231
NSpare Tire Stowage....................231
NPreparations For Jacking................232
NJacking Instructions....................233
mJump-Starting Procedures Due To A Low
Battery..............................235mDriving On Slippery Surfaces..............238
NAcceleration.........................238
NTraction............................238
mFreeing A Stuck Vehicle..................239
mTowing A Disabled Vehicle................240
NWith Ignition Key.....................240
NWithout The Ignition Key...............241
6

Jack Location
The jack and jack-handle are stowed behind the right rear
side trim panel in the cargo area.
Do not attempt to raise this vehicle using a bumper jack.
Spare Tire Stowage
The compact spare tire is stowed under the rear of the
vehicle by means of a hook/basket mechanism. To re-
move or stow the compact spare, use the jack handle to
rotate the ªspare tire driveº nut. The nut is located under
the rear scuff plate at the right rear of the cargo area, just
inside the liftgate opening.
WHAT TO DO IN EMERGENCIES 231
6

Spare Tire Removal
Lift up the cover and fit the jack-handle over the drive
nut. Rotate the nut to the left until you can remove the
swivel hook from the stowage basket. Swing the basket
down to remove the compact spare tire.
CAUTION!
The hook is designed for use with the jack handle
only. Use of an air wrench or other power tools is not
recommended and can damage the winch.
Preparations For Jacking
Park the vehicle on a firm level surface, avoid ice or
slippery areas,set the parking brakeand place the gear
selector in PARK (automatic transaxle) or REVERSE
(manual transaxle). Turn OFF the ignition.
WARNING!
Do not attempt to change a tire on the side of the
vehicle close to moving traffic. Pull far enough off
the road to avoid the danger of being hit when
operating the jack or changing the wheel.
²Turn on the Hazard Warning Flasher.
²Block both the front and rear
of the wheel diagonally oppo-
site the jacking position. For
example, if changing the right
front tire, block the left rear
wheel.
²Passengers should not remain in the vehicle while the
vehicle is being jacked.
232 WHAT TO DO IN EMERGENCIES

Do not raise the vehicle until you are sure the jack is
securely engaged.
4. Raise the vehicle by turning the jack screw to the right,
using the swivel wrench. Raise the vehicle only until the
tire just clears the surface and enough clearance is
obtained to install the spare tire. Minimum tire lift
provides maximum stability.
WARNING!
Raising the vehicle higher than necessary can make
the vehicle less stable. It could slip off the jack and
hurt someone near it. Raise the vehicle only enough
to remove the tire.
5. Remove the wheel nuts and pull the wheel and wheel
covers where applicable off the hub. Install the spare
wheel and wheel nuts with the cone shaped end of thenuts toward the wheel. Lightly tighten the nuts. To avoid
the risk of forcing the vehicle off the jack, do not tighten
the nuts fully until the vehicle has been lowered.
WARNING!
To avoid possible personal injury, handle the wheel
covers with care to avoid contact with any sharp
edges.
NOTE:The wheel cover is held on the wheel by the
wheel nuts. When reinstalling original wheel, properly
align the wheel cover to the valve stem, place the wheel
cover onto the wheel, then install the wheel nuts.
6. Lower the vehicle by turning the jack screw to the left.
7. Finish tightening the nuts. Push down on the wrench
while tightening the wheel nuts. Alternate nuts until each
nut has been tightened twice. Correct wheel nut torque is
234 WHAT TO DO IN EMERGENCIES

100 ft. lbs (135 N´m). If you doubt that you have
tightened the nuts correctly, have them checked with a
torque wrench by your dealer or at a service station.
8. Remove the wheel blocks and lower the jack until it is
free. Stow the lug wrench, and jack in their designated
location. Secure all parts using the means provided.
WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could endanger the occupants of the ve-
hicle. Always stow the jack parts and the spare tire in
the places provided.
9. Place the deflated (flat) tire in the cargo area,have the
tire repaired or replaced as soon as possible.
WARNING!
A loose tire thrown forward in a collision or hard
stop could injure the occupants in the vehicle. Have
the deflated (flat) tire repaired or replaced immedi-
ately.
10. Check the tire pressure as soon as possible. Correct
pressure as required.
JUMP-STARTING PROCEDURES DUE TO A LOW
BATTERY
WARNING!
Take care to avoid the radiator cooling fan whenever
the hood is raised. It can start anytime the ignition
switch is on. You can be hurt by the fan.
WHAT TO DO IN EMERGENCIES 235
6

CD Changer........................146,152
CD Player..................144,148,150,154,157
CD Player Maintenance................... 166
Cellular Phone........................70,166
Center High Mounted Stop Light............ 289
Central Door Locks....................... 20
Chains, Tire............................ 214
Changing A Flat Tire..................... 230
Chart, Tire Sizing........................ 199
Child Restraint.......................... 50
Child Restraint Tether Anchors............... 55
Child Restraint with Automatic Belts........... 54
Child Safety Locks........................ 21
Child Seat.............................. 56
Clean Air Gasoline....................... 217
Climate Control......................... 166
Clock................................ 136
Coin Holder........................... 112
Compact Disc Maintenance................. 166Compact Disc Player..................138,144
Compact Spare Tire...................... 210
Compass.............................. 105
Compass Calibration..................... 107
Compass Variance....................... 106
Console............................... 112
Console, Overhead....................... 104
Contract, Service........................ 318
Cool Down, Turbo....................... 182
Coolant............................290,291
Coolant Pressure Cap..................... 267
Cooling System......................... 265
Adding Coolant (Antifreeze).............. 267
Coolant Level......................266,268
Disposal of Used Coolant................ 266
Drain, Flush, and Refill.................. 266
Inspection........................... 268
Points to Remember.................... 268
Pressure Cap......................... 267
328 INDEX

Side Airbag............................. 47
Side Window Demisters................... 173
Slippery Surfaces, Driving On............... 238
Snow Tires............................ 214
Spare Tire............................. 231
Spark Plugs............................ 256
Speed Control.......................101,133
Speedometer........................... 130
Speedometer and Odometer................ 126
Starting............................... 180
Automatic Transmission................. 180
Engine Fails to Start.................... 181
Manual Transmission................... 180
Starting Procedures...................... 180
Steering
Power...........................196,261
Tilt Column.......................... 100
Wheel Lock........................... 17
Storage............................ 114,285Storage Bin............................ 114
Stuck, Freeing.......................... 239
Sulfur in Gasoline....................... 218
Sun Roof.............................. 108
Sun Visor Extension....................... 70
Supplemental Restraint System - Airbag........ 41
Synthetic Engine Oil...................... 255
System, Navigation...................... 161
Tachometer............................ 131
Temperature Gauge, Engine Coolant.......130,229
Tether Anchor, Child Restraint............... 55
Theft Alarm............................ 26
Theft System............................ 26
Tilt Steering Column..................... 100
Tire and Loading Information Placard......... 202
Tire Identification Number (TIN)............. 201
Tire Markings.......................... 197
Tire Safety Information.................... 197
338 INDEX