2004 CHEVROLET TRACKER automatic transmission fluid

Every 30,000 Miles (50 000 km):Engine Accessory
Drive Belt Inspection (or every 30 months, whichever
occurs ®rst). Cooling System Service (or every
30 months, whichever occurs ®rst). Fuel Tank, Cap and
Lines Inspection. Engine Air Cleaner Filter Replacement.
Passenger Compartment Air Filter Replacement (If
Equipped). Ignition Coil Plug Cap Inspection (or every
30 months, whichever occurs ®rst). Manual Transmission
Fluid Change. Transfer Case Fluid Change. Differential
Fluid Change. Fuel Filter Replacement (or every
30 months, whichever occurs ®rst).
Every 45,000 Miles (75 000 km):Automatic
Transmission Fluid Hose Inspection (or every
45 months, whichever occurs ®rst).
Every 60,000 Miles (100 000 km):Fuel Tank Cap
Gasket Replacement. Emission System Hoses
Inspection. Spark Plug Replacement. Brake Fluid
Service.
Every 100,000 Miles (166 000 km):Automatic
Transmission Service (normal conditions).
Every 120,000 Miles (200 000 km):Evaporative
Emissions Canister and Air Suction Filter Replacement
(or every 120 months, whichever occurs ®rst).
These intervals only summarize maintenance services.
Be sure to follow the complete scheduled maintenance
on the following pages.
Short Trip/City Scheduled
Maintenance
The services shown in this schedule up to 100,000 miles
(166 000 km) should be repeated after 100,000 miles
(166 000 km) at the same intervals for the life of
this vehicle. The service shown at 120,000 miles
(200 000 km) should be repeated at the same interval
after 120,000 miles (200 000 km) for the life of this
vehicle.
See
Part B: Owner Checks and Services on page 6-24andPart C: Periodic Maintenance Inspections on
page 6-28.
Footnotes
²The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle's useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
+A good time to check your brakes is during tire
rotation. See Brake System Inspection on page 6-29.
6-7

At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield. Also see
Cleaning the Outside of Your Vehicle on page 5-89.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. See
Part D: Recommended Fluids and
Lubricants on page 6-30.
Fluid Level Check
Check the transfer case, axle differential(s) and
automatic or manual transmission ¯uid levels and add
as needed. See
Rear Axle on page 5-48,Four-Wheel
Drive on page 5-49, andAutomatic Transmission
Fluid on page 5-20orManual Transmission Fluid on
page 5-23. Check for leaks. A ¯uid loss in these systems
could indicate a problem. Have the system inspected
and repaired at once.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
speci®ed in Part D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, glove box door, console door and folding
seat hardware. Part D tells you what to use. More
frequent lubrication may be required when exposed to a
corrosive environment.
6-25

Part D: Recommended Fluids and
Lubricants
Fluids and lubricants identi®ed below by name, part
number or speci®cation may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certi®ed for Gasoline Engines
starburst symbol. To determine
the proper viscosity for your
vehicle's engine, see
Engine Oil
on page 5-13.
Engine Coolant50/50 mixture of clean, drinkable
water (preferably distilled)
and good quality Ethylene
Glycol Base Coolant
(GM Part No. U.S. 12378560, in
Canada 993089, or equivalent)
and conforming to GM
Speci®cation 1825M or approved
recycled coolant conforming to
GM Speci®cation 1825M. See
Engine Coolant on page 5-25.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco Supreme 11
žBrake Fluid
or equivalent DOT-3 brake ¯uid.
Windshield
Washer SolventGM Optikleen
žWasher Solvent.
Hydraulic Clutch
SystemHydraulic Clutch Fluid
(GM Part No. U.S. 12345347, in
Canada 10953517) or equivalent
DOT-3 brake ¯uid.
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of
NLGI #2, Category LB or GC-LB.
Power Steering
SystemDEXRON
ž-III Automatic
Transmission Fluid.
Manual
Transmission (All)
and Transfer Case
(Four-Wheel-Drive)Synchromesh Transmission Fluid
(GM Part No. U.S. 12345349, in
Canada 10953465).
Automatic
TransmissionDEXRON
ž-III Automatic
Transmission Fluid.
6-30

A
About Driving Your Vehicle................................. 0-2
Accessory Power Outlets.................................3-18
Adding Washer Fluid.......................................5-38
Additional Program Information........................... 7-8
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-93
Adjusting the Speakers (Balance/Fade)..............3-42
After Off-Road Driving.....................................4-30
Air Bag
Readiness Light..........................................3-29
Air Bag System, Supplemental Restraint
System (SRS).............................................1-52
Air Cleaner/Filter, Engine.................................5-18
Airbag Sensing and Diagnostic Module (SDM)...... 7-9
AM ...............................................................3-45
Antenna, Fixed Mast.......................................3-45
Anti-lock Brake System (ABS)............................ 4-8
Anti-Lock Brake System Warning Light...............3-31
Appearance Care............................................5-85
Care of Safety Belts....................................5-88
Chemical Paint Spotting...............................5-91
Cleaning the Inside of Your Vehicle................5-86
Cleaning the Outside of Your Vehicle..............5-89
Finish Damage............................................5-91
Sheet Metal Damage...................................5-91Appearance Care (cont.)
Underbody Maintenance...............................5-91
Vehicle Care/Appearance Materials................5-92
Weatherstrips..............................................5-88
Approaching a Hill..........................................4-20
Ashtrays........................................................3-19
Audio System(s).............................................3-39
Care of Your CD Player...............................3-45
Care of Your CDs........................................3-45
Fixed Mast Antenna.....................................3-45
Radio with CD............................................3-40
Setting the Time..........................................3-39
Understanding Radio Reception.....................3-45
Automatic Headlamp System............................3-15
Automatic Transmission...................................2-14
Fluid..........................................................5-20
Operation...................................................2-16
Automatic Transmission Shift Lock Control
System Check.............................................6-26
B
Backing Up....................................................4-61
Battery..........................................................5-42
Battery Replacement......................................... 2-5
Before Leaving on a Long Trip.........................4-36
Before You Go Off-Roading..............................4-16
Body Lubrication Service..................................6-25
1

Engine Compartment Fuse Block......................5-96
Engine Coolant Level Check.............................6-24
Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-24
Entry Lighting.................................................3-17
Environmental Concerns..................................4-17
Event Data Records (EDR)................................ 7-9
Express-Down Window....................................2-11
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-18
Finding a Station............................................3-40
Finish Care....................................................5-89
Finish Damage...............................................5-91
Five-Speed....................................................2-20
Fixed Mast Antenna........................................3-45
Flash to Pass.................................................. 3-7
Flat Tire........................................................5-72
Flat Tire, Changing.........................................5-72
Fluid
Automatic Transmission................................5-20
Manual Transmission....................................5-23
Power Steering...........................................5-37
Windshield Washer......................................5-37
Fluid Level Check...........................................6-25FM ...............................................................3-45
Folding the Seatback........................................ 1-6
Following Distance..........................................4-61
Footnotes................................................6-7, 6-17
Four-Door Models...................................1-24, 1-47
Four-Wheel Drive....................................2-22, 5-49
Four-Wheel-Drive Light....................................3-37
Front Axle......................................................5-50
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-38
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-4
System Inspection.......................................6-28
Fuses
Fuses and Circuit Breakers...........................5-94
G
Gage
Engine Coolant Temperature.........................3-32
Fuel..........................................................3-38
Speedometer..............................................3-28
Tachometer.................................................3-28
5

Mirrors
Manual Rearview Mirror................................2-31
Outside Convex Mirror.................................2-33
Outside Manual Mirrors................................2-32
Outside Power Mirrors..................................2-32
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-12
Normal Maintenance Replacement Parts...........5-100
O
Odometer......................................................3-28
Off-Road Recovery..........................................4-13
Oil
Engine.......................................................5-13
Pressure Light.............................................3-36
Older Children, Restraints................................1-29
Online Owner Center........................................ 7-3
Opening a Rear Door When the Security Lock
Is On .......................................................... 2-8
Operating Your All-Wheel-Drive Vehicle Off
Paved Roads..............................................4-16
Operation......................................................3-20
Operation Tips................................................3-23
Other Warning Devices...................................... 3-5
Outlet Adjustment............................................3-22Outside
Convex Mirror.............................................2-33
Manual Mirrors............................................2-32
Power Mirrors.............................................2-32
Overdrive Off.................................................2-19
Overdrive Off Light..........................................3-37
Overseas ± Customer Assistance........................ 7-4
Owners, Canadian............................................... ii
Owner's Information........................................7-12
P
Park (P)
Shifting Into................................................2-25
Shifting Out of............................................2-27
Parking
Brake........................................................2-24
Over Things That Burn.................................2-28
Parking Brake and Automatic Transmission
Park (P) Mechanism Check...........................6-27
Parking on Hills..............................................4-63
Parking Your Vehicle.......................................2-28
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-24
Part C - Periodic Maintenance Inspections..........6-28
Part D - Recommended Fluids and Lubricants....6-30
Part E - Maintenance Record...........................6-32
Passenger Compartment Air Filter.....................3-23
Passing.................................................4-13, 4-61
9

Tires (cont.)
Wheel Replacement.....................................5-70
When It Is Time for New Tires......................5-66
To Use the Engine Coolant Heater....................2-15
Top Strap......................................................1-39
Top Strap Anchor Location...............................1-41
Torque Lock...................................................2-26
Total Weight on Your Vehicle's Tires..................4-59
Towing
Recreational Vehicle.....................................4-47
Towing a Trailer..........................................4-57
Your Vehicle...............................................4-47
Trailer Brakes.................................................4-60
Transfer Case........................................2-22, 5-49
Transmission
Fluid, Automatic...........................................5-20
Fluid, Manual..............................................5-23
Transmission Operation, Automatic....................2-16
Transmission Operation, Manual........................2-20
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-11
Transportation Options...................................... 7-7
Traveling to Remote Areas...............................4-18
Trip Odometer................................................3-28
Turn and Lane-Change Signals.......................... 3-6
Turn Signal/Multifunction Lever........................... 3-6
Turn Signals When Towing a Trailer..................4-62U
Underbody Flushing Service.............................6-27
Understanding Radio Reception........................3-45
Uniform Tire Quality Grading............................5-68
United States ± Customer Assistance.................. 7-4
Used Replacement Wheels..............................5-71
Using Cleaner on Fabric..................................5-86
Using the Rear Door Security Lock..................... 2-8
Using the Recovery Hooks...............................4-45
V
Vehicle
Control........................................................ 4-7
Damage Warnings........................................... iv
Design......................................................... 4-3
Loading......................................................4-51
Parking Your...............................................2-28
Symbols......................................................... iv
Vehicle Data Collection and Event Data
Records....................................................... 7-9
Vehicle Identi®cation
Number (VIN).............................................5-93
Service Parts Identi®cation Label...................5-93
Vehicle Storage..............................................5-42
Ventilation Adjustment......................................3-22
Visor Vanity Mirror..........................................2-11
Visors...........................................................2-11
13