2004 BMW X5 3.0I ignition

Maintenance System
The BMW Maintenance System has been
devised with the following objectives: to maximize
vehicle safety, reliability, and resale value by
minimizing breakdowns resulting from wear, and
minimizing cost and inconvenience by computing
maintenance intervals based upon the specific
manner in which each individual vehicle is driven.
Maintenance intervals on motor vehicles
have conventionally been specified based
upon accumulated mileage. However, the
type of driving conditions has a major
influence on routine maintenance require-
ments; distance traveled is only one of the
significant factors. A vehicle driven for
50,000 miles of short trips in the city with
numerous cold starts, prolonged periods of
idling, stop-and-go driving, and high engine
speeds during acceleration requires more
frequent maintenance intervals than a
vehicle driven for 50,000 miles for long
distances at low engine speeds primarily at
operating temperature.
The advanced technologies at BMW have led to
the development of the unique BMW Service
Interval Indicator System which computes the
actual optimum maintenance requirements based
not only upon the accumulated mileage, but
taking into account important factors such as
engine coolant temperatures, high or low engine
speeds, short or long trip driving, and number of
vehicle starts. The maintenance interval may
therefore be maximized with considerable
savings to owners of vehicles subjected to light
duty.
(Typical Display) 32 88 02 30The Service Indicator consists of five green,
one yellow and one red Iight-emitting-diodes
(LEDs) and the inscriptions “OIL SERVICE”
and “INSPECTION”.
Whenever the ignition is switched on, up to
five green LEDs will light up, depending on
the amount of use the vehicle has had since
the last maintenance service and your driving
style. As the number of illuminated green LEDs
decreases, this is an indication that the next
service is almost due and helps you to make
the necessary arrangements on a timely basis.
The green LEDs disappear when the engine
is started.
Notification that maintenance is required is
indicated with the illumination of the yellow
LED and accompanying inscription. These will
remain illuminated with the ignition on.
If the maintenance interval has been exceeded,
the red LED will light up in addition to the
yellow one to remind you of the urgent need for
servicing. In the interests of road safety and
reliability, you should avoid driving your BMW
when the red LED signal is showing, and have
the essential maintenance work performed without
delay.
After each maintenance is performed the
service indicator is reset in order to compute
the next service interval.
The green LEDs which then light up with the
ignition show you the interval before the next
maintenance is due.
If the service indicator displays an illogical
reading, for instance the green and red LEDs
at the same time, or if there is no display,
consult an authorized BMW SAV center.
If the speedometer, tachometer or coolant
temperature gauge should develop a fault, the
service indicator will probably cease to
operate correctly as well, since it depends on
correct speed, distance and temperature
readings. The fault must be located and
rectified by an authorized BMW SAV center.
2

13 The maintenance schedule as shown
is required for the proper functioning
of the emission control systems for
optimum vehicle performance and fuel
economy.
Abbreviations:
I - Inspect
R - Replace part(s) and/or fluid listed
Basic Engine
Engine oil....................................................
Engine oil filter..........................................
Fuel System
Air filter.......................................................
Ignition System
Spark plugs...............................................
Emission Control Components
Oxygen sensor..........................................
Emission Control Maintenance Schedule: X5 3.0i, 4.4i
Oxygen Sensor Service: The oxygen sensor deteriorates strictly on a mileage basis and must
therefore be replaced to maximize vehicle fuel economy and minimize exhaust pollution.
The mileage interval varies according to individual driving conditions and is determined by the
service interval indicator.
Oil Service
Inspection I
Oil Service
Inspection II
RRR R
RRR R
R
Replace at intervals of
100,000 miles
Replace at intervals of
100,000 milesX5
Continue sequence of
Oil Services and
Inspections per Service
Interval Indicator.

33 J), Warranty Claims, Environmental Protection
Agency, Ariel Rios Building, 1200 Pennsylva-
nia Avenue, N.W., Washington, D.C. 20460.
The following systems are covered by the
Federal Emission Performance Warranty for
a period of two years or 24,000 miles,
whichever occurs first. The specific systems
may vary according to model, therefore, all
of the systems listed may not be used on
your SAV. For assistance in determining
which systems and specific components
within these systems apply to your SAV,
please contact your authorized BMW SAV
center.
AIR INDUCTION SYSTEM
FUEL METERING SYSTEM
IGNITION SYSTEM
POSITIVE CRANKCASE VENTILATION
SYSTEM (PCV)
FUEL EVAPORATIVE CONTROL SYSTEM
EXHAUST SYSTEM
ENGINE EMISSION CONTROL SYSTEM
SENSORS/DEVICES
ON BOARD DIAGNOSTIC SYSTEM (OBD)
RELATED PARTS ASSOCIATED WITH THE
ABOVE SYSTEMS
The following components and/or system
are/is covered under the Federal Emission
Warranty for a period of 8 years or 80,000
miles, whichever occurs first.
CATALYTIC CONVERTER
ENGINE CONTROL MODULE (INCLUDING
ON-BOARD DIAGNOSTIC SYSTEM)
For assistance in determining coverage of
the specific components of the on-board
diagnostic system, please contact your
authorized BMW SAV center.

The California Air Resources Board and BMW
of North America (BMW NA) are pleased to
explain the emission control system warranty
on your 2004 SAV. In California, new motor
vehicles must be designed, built and equipped
to meet the State’s stringent anti-smog
standards. BMW NA must warrant the
emission control system on your SAV for the
periods of time listed below provided there has
been no abuse, neglect or improper mainte-
nance of your SAV.
Your emission control system may include
parts such as the fuel injection system, the
ignition system, catalytic converter, and engine
computer. Also included may be hoses, belts,
connectors and other emission-related
assemblies.
Where a warrantable condition exists, BMW
NA will repair your SAV at no cost to you
including diagnosis, parts and labor.
Manufacturer’s Warranty Coverage:
– For 3 years or 50,000 miles whichever
occurs first:
1. If your SAV fails a Smog Check inspection,
all necessary repairs and adjustments will
be made by BMW NA to ensure that your
SAV passes the inspection. This is your
emission control system PERFORMANCE
WARRANTY.
2. If any emission-related part on your SAV is
defective, the part will be repaired or replaced
by BMW NA. This is your short-term emission
control system DEFECTS WARRANTY.
– For 7 years or 70,000 miles whichever
occurs first:
If an emission-related part listed in this
Warranty Section specially noted with cover-
age for 7 years or 70,000 miles is defective,the part will be repaired or replaced by BMW
NA. This is your long-term emission control
system DEFECTS WARRANTY.
Owner’s Warranty Responsibilities:
– As the SAV owner, you are responsible for
the performance of the required mainte-
nance listed in your Owner’s Manual. BMW
NA recommends that you retain all receipts
covering maintenance on your SAV, but
BMW NA cannot deny warranty solely for
the lack of receipts or for your failure to
ensure the performance of all scheduled
maintenance.
– You are responsible for presenting your
SAV to an authorized BMW SAV center as
soon as a problem exists. The warranty
repairs should be completed in a reason-
able amount of time, not to exceed 30 days.
– As the SAV owner, you should also be
aware that BMW NA may deny your
warranty coverage if your SAV or part has
failed due to abuse, neglect, improper
maintenance or unapproved modifications.
If you have any questions regarding your
warranty rights and responsibilities, you
should contact:
BMW of North America
Customer Relations Department
PO. Box 1227
Westwood, N.J. 07675-1227
Telephone: 1-800-831-1117
Website: www.bmwusa.com
or the
California Air Resources Board
9528 Telstar Avenue
P.O. Box 8001
El Monte, CA 91734-8001
*The California Emissions Control System
Limited Warranty applies to all 2004 U.S.
specification BMW SAVs sold, leased, and/or
registered in California, Maine, Massachusetts
or Vermont.
California Emission Control
Warranty Statement*
Your Warranty Rights and
Obligations
34