2004 BMW M3 fuel

BMW Maintenance Programs -
2004 M3
Maintenance Programs are a benefit designed
to help reduce the cost of scheduled and
unscheduled maintenance.
2004 M3 vehicles purchased from any
Authorized BMW center in the United States or
Puerto Rico are covered by Full Maintenance
for 48 months or 50,000 miles, whichever
occurs first. Coverage begins on the date of
first retail sale or the date the vehicle is first
placed in service as a demonstrator or
company vehicle, whichever is earlier.
Any authorized BMW center in the United
States or Puerto Rico will perform the sched-
uled or additional maintenance services on
your vehicle at no expense to you. The
maintenance schedule intervals are based on
normal driving conditions and operation.
Should you request more frequent mainte-
nance service, the cost of these services
will not be covered by the Maintenance
Program.
Coverage
Full Maintenance covers all factory recom-
mended maintenance, as determined by the
service interval indicator. Additional items that
need replacement due to normal wear and
tear, and that are not covered by the original
New Vehicle Limited Warranty - such as brake
pads, brake rotors, and wiper blade inserts -
are included, provided wear and tear
exceeds BMW specifications. Any adjust-
ments required due to normal operating
conditions are also included. See pages 5-8
of this statement for additional information.
Maintenance Intervals
Time intervals should be followed using the
maintenance interval as indicated by the BMW
Service Indicator lights on the check control
panel in the dashboard.This BMW Service and Warranty Information
Statement should be presented to your BMW
center when maintenance is required. Your
BMW center will stamp this book documenting
the services or maintenance performed.
Exclusions from coverage
– Items reimbursable under your New Vehicle
Limited Warranty.
– Gasoline and gasoline additive.
– Windshield washer additive (except when
in conjunction with scheduled mainte-
nance).
– Tires, wheel alignment, tire balance and
rotation.
– Wear and tear of soft trim items, such as:
seats, carpets, moldings, headliner, door
panels and all chrome trim.
– Damage detected when performing the rust
perforation inspection.
– Damage which results from negligence,
improper operation of the vehicle, wear and
tear or deterioration due to driving habits or
conditions, improper repair, environmental
influences, flood, accident or fire damage,
road salt corrosion, alteration, installation of
non-BMW accessories, or use of improper,
poor quality or contaminated fuel.
– Altered or unreadable Vehicle Identification
Number (VIN) or odometer irregularities or
vehicles where the true mileage cannot be
determined.
– Maintenance or repair after the vehicle is
deemed a total loss.
– Maintenance or repairs performed by other
than an Authorized BMW center within the
United States or Puerto Rico.
– Vehicles used in competitive events.
– Oil changes performed outside the
recommended maintenance intervals as
indicated by the Service Interval Indicator.
1

3 The performance of certain subsequent
maintenance elements, as required by the
BMW New Vehicle Limited Warranty, will be
specified at intervals computed by the BMW
service interval indicator as follows:
– Oil Service: Engine oil changed with the
engine at operating temperature. Note:
change oil at least once a year. Your BMW is
factory-equipped with a newly-developed
synthetic engine oil. At the time of the
printing of this booklet the only approved
engine oils are:
Castrol TWS Motorsport SAE 10W-60
Synthetic, or Castrol Formula RS 10W-60
Synthetic (BMW part number 07 51 0 009
420). BMW is evaluating various synthetic
oils for inclusion in our list of recommended
motor oils.
For the most current list of synthetic oils,
please contact your BMW center, or call
BMW of North America at 1-800-831-1117.
You can also obtain this information from
our website, www.bmwusa.com/.
It is recommended to check engine oil level
whenever fuel is added to the vehicle.
If you need to add oil between oil changes
and are unable to obtain BMW High
Performance Synthetic Oil, Mobil 1 or
another special oil on the list, use a
synthetic oil with an API rating of SJ or
higher.
– Inspection I: Major vehicle maintenance
as specified in the following pages under
Inspection I.
– Inspection II: Additional major vehicle
maintenance as specified in the following
pages under Inspection II.
The following maintenance elements must
be performed at the mileage/time stated
(time intervals begin from the vehicle’s
production date):
– Brake Fluid Service: Change brake fluid
every two years.– Oxygen Sensor Service: The oxygen sensor
deteriorates strictly on a mileage basis and
must therefore be replaced every 100,000
miles to maximize vehicle fuel economy
and minimize exhaust pollution. The
replacement of the oxygen sensor is
required under the terms of the appli-
cable BMW emission system warranties.
– Spark Plug Service: Replace spark plugs
every Inspection II). Your BMW is equipped
with platinum-tipped spark plugs. These
allow a longer service life than conven-
tional spark plugs.
The engine coolant has a lifetime rating and
does not need to be changed.
For your convenience, you may also wish to
have your BMW center perform any necessary
operations to fulfill any state inspection
requirements in your area concurrent with the
maintenance elements specified above during
other repairs.
Make sure that confirmation of maintenance
work is always entered in this Service and
Warranty Information Statement. You may need
this for any warranty claims that become
necessary, and later on as evidence that your
car has been given the correct and regular
maintenance that justifies its resale or trade-in
value.
BMW has applied the most modern techno-
logical advances not only to the design and
production of your vehicle, but also to
computing of the optimum maintenance
interval for your type of operations and
driving style. Your BMW center has made a
substantial investment in unique BMW
special service tools to enable his BMW
factory trained service technicians to perform
quality repairs on your BMW in minimal time.
He/she looks forward to serving your every
service need and to help maximize your
satisfaction with your BMW, its longevity, and
resale value.

Unscheduled Maintenance
Only use fuels advertised to have adequate
detergency and low alcohol content. Use of
fuels with insufficient detergent and/or excess
alcohol can cause driveability problems that
necessitate cleaning intake valves and fuel
injection valves, and, when applicable,
adjusting the engine idle. We suggest having
this work performed by your authorized BMW
center, perhaps while regular maintenance is
performed. Your BMW center can also recom-
mend a gasoline additive that will provide
sufficient detergency. While this recommended
unscheduled maintenance is not required in
order to maintain the emission warranty,
cleaning of intake valves or, when applicable,
fuel injection valves, or adjustment of engine
idle, necessitated by use of inappropriate fuel,
is not covered by warranty because no defect
in material or workmanship or component
failure is involved.
Special Note
Maintenance items and schedules stated
herein reflect the combined recommendations
for all model 2004 BMWs, and are subject to
change. The most current maintenance
recommendations are available from your
authorized BMW center.
Quality Certification I
For a detailed list of items inspected, refer to
the Quality Certification I form provided to
the Owner at time of delivery. A copy of the
form is on file at the selling BMW center.
Quality Certification I
Performed by (selling BMW center/Stamp with Code)
FREE OF CHARGE
Date Mileage
Authorized
Signature of Service Manager
4
1200 Mile Service 1200 Mile Service1200 Mile Service 1200 Mile Service
1200 Mile Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
1200 Mile Service
The engine incorporated in your BMW M3 is a
race-bred engine design which includes
increased power output and maximum engine
speeds compared to conventional BMW 3
Series engines. The increased power output
also affects other major drivetrain components
such as the transmission and the rear axle
differential. The 1200 Mile Service requires
changing the oil in the engine and both the
transmission and the differential.

Inspection I
Only those items of inspection work which apply to your vehicle will be performed. This list is
subject to amendment.
Undercarriage
6M3
Change oil and oil filter while engine is at normal operating temperature. 
Use only Castrol TWS Motorspor t SAE 10W-60 Synthetic, or Castrol Formula
RS 10W-60 Synthetic oil, BMW p/n 07 51 0 009 420.
Check transmission for leaks. 
Check rear axle for leaks. 
Half-shafts: Check for leaks at flexible boots. 
Visually check fuel tank, lines and connections for leaks. 
Check condition, position, and mounting of exhaust system. Examine for leaks. 
Check power steering system for leaks. Check power steering fluid level; 
add fluid if necessary.
Check steering for absence of play, condition of suspension track rods, 
front axle joints, steering linkage and joint disc.
Check overall thickness of rear disc brake pads using special tool.rear
If replacement is necessary: Examine brake disc surfaces. Clean brake pad
contact points in calipers. Grease wheel centering hubs. Check thickness
of parking brake linings only when replacing rear brake pads.
Remove and install front disc brake pads, check overall thickness. Examine
disc surfaces. Clean brake pad contact points in calipers. Grease wheel
centering hubs.
Check brake system connections and lines for leaks, damage 
and incorrect positioning.
Check parking brake actuation. Adjust if necessary. 
Check all tire pressures (including spare). Correct if necessary. 
Check condition of tires (outer surface [left/right]), tread wear and pattern;
in case of uneven tread wear, readjust wheel alignment if requested
(invoice separately).
Inspect entire body according to terms of rust performation limited warranty. 
(Must be performed at least every two years).
Engine Compartment
Read out diagnostic system. 
Check valve settings. Adjust if needed. 
Check engine cooling system/heater hose connections for leaks. 
Check coolant level and antifreeze protection level. Add coolant if required.
Check windshield washer fluid level and antifreeze protection. 
Fill up and/or correct if required.
Check air conditioner for operation. 
Replace microfilter. (Note: reduce replacement interval in dusty 
operating conditions.)
Reset service interval indicator.

The maintenance schedule as shown
is required for the proper functioning
of the emission control systems for
optimum vehicle performance and fuel
economy.
Abbreviations:
I - Inspect
R - Replace part(s) and/or fluid listed
Basic Engine
Engine oil....................................................
Engine oil filter..........................................
Fuel System
Air filter.......................................................
Ignition System
Spark plugs...............................................
Emission Control Components
Oxygen sensor..........................................
Emission Control Maintenance Schedule M3
Oxygen Sensor Service: The oxygen sensor deteriorates strictly on a mileage basis and must
therefore be replaced to maximize vehicle fuel economy and minimize exhaust pollution.
The mileage interval varies according to individual driving conditions and is determined by the
service interval indicator.
13
Oil Service
Inspection I
Oil Service
Inspection II
RRR R
RRR R
R
R
Replace at intervals of
100,000 milesM3

24 From the information you provide, the BMW
Roadside Assistance service representative
will determine the type of help required.
Dispatch Service
A service provider will be dispatched to the
site of your disabled vehicle.
On-Site Assistance
On-site service for vehicle disablements such
as flat tires, dead batteries, and out of fuel
conditions is provided up to a maximum of
$100.00 per incident by BMW Roadside
Assistance.
The cost for parts and fuel, when used on-site,
are the responsibility of the owner/driver. The
New Vehicle Limited Warranty does not cover
any of the above on-site services.
Lock-Out
For security purposes, the driver will need to
prove ownership by presenting proper docu-
mentation, i.e., a valid drivers license, registra-
tion, etc. Lock-out service will be provided up to
a maximum of $100.00 per incident.
Towing Service
In the event of a mechanical breakdown
normally covered under the New Vehicle Limited
Warranty, your vehicle will be transported (at no
cost) to the nearest authorized BMW center. Your
vehicle is also covered in the event of an
accident or collision.
If a breakdown occurs after normal business
hours, your vehicle will be transported to a
secure location and transported to the
nearest authorized BMW center on the next
business day.If you request that the vehicle be taken to a
location other than the nearest authorized
BMW center, any additional expense will be
your responsibility.
However, you may request (at no cost) to be
taken to a different BMW center as long as it is
within 50 additional miles of the "nearest"
BMW center.
Towing requests for vehicles disabled
because of casualty, fire, act of God, or
violation of law (federal, state or local) are
accepted at the expense of the owner/driver.
If it is necessary for you to have your vehicle
towed through your own arrangements, you
must contact BMW Roadside Assistance for
prior authorization and instructions on claim
procedures. All claims must be submitted
within sixty (60) days of the disablement or
occurrence, accompanied by the original
receipts. Claims received after that time period
may not be honored and are subject to the full
discretion of BMW Roadside Assistance. If
BMW Roadside Assistance is not contacted for
"prior" authorization, the maximum coverage
for towing situations is $100.00.
Sign-and-Drive
In most instances, services provided under the
BMW Roadside Assistance Program do not
require immediate payment.
Usually, you will be able to sign a receipt, so the
provider of the service can be reimbursed
directly by BMW Roadside Assistance.
Parts, materials and fuel should be paid by you
directly to the provider of the services.
Trip Interruption Benefits
Trip interruption benefits are provided for
mechanical breakdowns as follows:
– Breakdowns that are warranty related, and;
– Must occur in excess of 100 miles from the
driver’s residence, and;
Services

27
Warrantor
BMW NA warrants 2003 U.S. specification
vehicles distributed by BMW NA or sold
through the BMW NA European Delivery
Program against defects in materials or
workmanship to the first retail purchaser, and
each subsequent purchaser.
Warranty Period
The warranty period is 48 months or 50,000
miles, whichever occurs first.
Warranty Begins
This warranty begins on the date of
first retail sale, or the date the vehicle
is first placed in service as a demon-
strator or company vehicle, whichever
is earlier.
Warranty Coverage
To obtain service under this warranty, the
vehicle must be brought, upon discovery of a
defect in material or workmanship, to the
workshop of any authorized BMW center,
during normal business hours. The BMW
center will, without charge for parts or labor,
either repair or replace the defective part(s)
using new or authorized remanufactured
parts. The decision to repair or replace said
part(s) is solely the prerogative of BMW NA.
Parts for which replacements are made
become the property of BMW NA.
In all cases, a reasonable time must be
allowed for warranty repairs to be completed
after the vehicle is received by the BMW
center.
Safety Belt Warranty - Kansas
Safety belts are covered under the BMW New
Vehicle Limited Warranty for defects inmaterial or workmanship for a period of 10
years, unlimited mileage from the date of
purchase. In order to be eligible for this
coverage, the vehicle must be a new car
retailed in the State of Kansas and the repair
performed by an authorized BMW center in
Kansas.
Towing/Other Owner Benefits
A 24-hour Roadside Assistance Program is
available to every BMW owner during the
new vehicle warranty period.
Roadside assistance and other owner
benefits are available by calling:
1-800-332-4269
For additional details on towing and other
owner benefits please refer to the BMW
Roadside Assistance section of this State-
ment (page 24).
Other Items
Wheel alignment, balancing and wiper blade
inserts are covered up to 2,000 miles.
Items which are subject to wear and tear
or deterioration due to driving habits or
conditions, such as brake pads/linings,
brake discs, clutch disc, pressure plate,
filters, upholstery, trim and chrome items,
paint finish, drive belts, glass, and similar
items, are specifically limited to defects in
material or workmanship.
This warranty does not apply to the
following:
Damage which results from negligence,
improper operation of the vehicle, improper
repair, lack of or improper maintenance,
environmental influences, flood, accident or
fire damage, road salt corrosion, or use of
improper or contaminated fuel.
Maintenance services and parts when
replaced during maintenance such as spark
plugs, lubricants, fluids, engine tuneup parts,
replacement of filters, coolant, and refrigerant.
New Vehicle Limited Warranty -
2004 M3 (Valid only in the U.S.A.
and Puerto Rico)

31 parts are warranted by their manufacturer to
be equivalent to genuine BMW parts in
performance and durability. BMW NA
assumes no liability under this warranty with
respect to parts other than genuine BMW
parts.
However, the use of non-BMW replacement
parts or non-EPA certified parts does not
invalidate the warranty on other compo-
nents, unless non-BMW parts or non-EPA
certified parts cause damage to warranted
parts.
What is not covered
This warranty does not cover malfunctions
caused by any of the following: accident,
flood, misuse, improper adjustment, modifi-
cation, alteration, tampering, disconnection,
improper or inadequate maintenance, use of
leaded fuel or fuels containing more than
10% ethanol, or other oxygenates with more
than 2.8% oxygen by weight (i.e., more than
15% MTBE or more than 3% methanol plus
an equivalent amount of co-solvent).
The replacement of maintenance parts, such
as spark plugs, filters and similar items used
in required maintenance services, the repair
or replacement of maintenance parts
beyond the first required inspection/mainte-
nance, or if the part has been replaced
earlier for reasons other than it being
defective.
The car or any part of the car unless a failure
causes the car to fail to conform to appli-
cable emission regulations.
Any car on which the odometer has been
replaced or altered and the true mileage
cannot be determined.
The car, if the vehicle identification number
is altered or cannot be read, or if the car has
been declared a total loss or sold for
salvage purposes.General
These warranties give you specific legal
rights, and you may also have other rights
which vary from state to state.
THE DURATION OF ANY IMPLIED WAR-
RANTIES, INCLUDING THE IMPLIED
WARRANTY OF MERCHANTABILITY, IS
LIMITED TO THE DURATION OF THE
EXPRESS WARRANTIES HEREIN.
BMW NA HEREBY EXCLUDES INCIDEN-
TAL AND CONSEQUENTIAL DAMAGES,
INCLUDING LOSS OF TIME, INCONVE-
NIENCE, OR LOSS OF USE OF THE
VEHICLE, FOR ANY BREACH OF ANY
EXPRESS OR IMPLIED WARRANTY,
INCLUDING THE IMPLIED WARRANTY OF
MERCHANTABILITY, APPLICABLE TO THIS
PRODUCT.
Some states do not allow limitations on how
long an implied warranty lasts, or the
exclusion or limitation of incidental or
consequential damages, so the above
limitations and exclusions may not apply to
you. Additionally, if you are a California,
Massachusetts, Vermont or Maine resident
and your vehicle is registered in that state,
your vehicle is eligible for California
Emissions Warranty coverage.
These federal warranty provisions also
apply to all vehicles sold in all U.S. states
and territories regardless of whether a state
has enacted state warranty provisions that
differ from the federal provisions.