2004 Alfa Romeo 156 oil level

CAR MAINTENANCE
260
Do not add oil with dif-
ferent characteristics than
those of the oil already in
the system.
The oil level should never exceed the
MAXmark on the dipstick on the COLD
side, if the level is checked cold and on the
HOTside if the level is checked with the
gearbox/differential unit hot.
fig. 14
A0B0163m
The level should be between the MINand
MAXmarks of the sector identified by the
word COLD(+40°C).
WARNINGAfter long journeys with the
gearbox/differential unit very hot, the oil
level should be between the MINand
MAXmarks of the sector identified by the
word HOT(+80°C).
Q-SYSTEM AUTOMATIC
GEARBOX OIL LEVEL
(fig. 14)
The oil should be checked with the engine
idling and at operating temperature, the
gearshift lever at position Pand the car on
level ground.
To check the level, proceed as follows:
– remove the dipstick (A);
– clean it with a clean lint free cloth;
– insert the dipstick in its housing pushing
well down to the bottom;
– remove it to check.
If the oil level is near or below the MIN
mark, add TUTELA GI/2oil through the
dipstick housing.
When the engine is very
hot, take care when work-
ing inside the engine compartment
to avoid burns. Remember that
when the engine is hot, the fan may
cut in: danger of injury.
WARNING
Used gearbox oil contain
pollutants. Contact Alfa
Romeo Authorized Services to
have the oil changed as these are
equipped to dispose of the waste
oil respecting the environment and
laws.
WARNING

CAR MAINTENANCE
262
WARNINGContact Alfa Romeo Autho-
rized Services for maintenance and repair
operations. If the level of the oil in the reservoir falls
below the specified level, top up only with
one of the products listed in the table
“Fluids and lubricants” in the “Technical
specifications” chapter as follows:
– Start the engine and allow the oil in the
reservoir to settle.
– When the engine is running turn the
steering wheel lock to lock a few minutes.
– Top up to the MAXlevel notch and
then replace the cover.Oil consumption is very
low, if topping up again is
needed shortly afterwards,
have the system checked for pos-
sible leaks by Alfa Romeo Autho-
rized Services.fig. 19 fig. 18
A0B0158m
A0B0158m
POWER STEERING OIL LEVEL Fig. 17: T.SPARK versions
Fig. 18: 2.0 JTS versions
Fig. 19: 2.5 V6 24V and JTD versions
Check that the oil level in the reservoir is
at the MAX level.
This operation must be carried out with the
car on level ground and when the engine
is stationary and cold.
Check that the level reaches the MAXref-
erence notch on the reservoir or coincides
with the upper notch (maximum level) on
the dipstick integral with the reservoir cap.fig. 17
A0B0159m
Power steering fluid is
highly inflammable. Do not
let it come into contact with hot en-
gine parts.
WARNING

TECHNICAL SPECIFICATIONS
321
UseLubricants and greases
for transmissionsBrake fluidProtective agent for radiatorsAdditive for fuel oil
Windscreen/
rearscreen/headlampwasher fluid
(*) IMPORTANTDo not add or mix with fluids with specifications other than the specified ones.Quality features of fluids and lubricants
for correct vehicle operation
Synthetic-based engine oil, SAE 75W-80 EP grade that passes API GL5
and MIL-L-2105 D Lev specifications
SAE 75W-85 completly synthetic engine oil.
Meets API GL 4 and ZF TE ML06 (B&C) LEVEL, ALLISON C4 specifications
“ATF DEXRON II D LEV”, type oil
“ATF DEXRON III” type specific oil
“ATF DEXRON II D LEV”, SAE 10W type oil
Lithium-soap-based grease with molybdenum bisulphate.
Consistency NLGI 2
FMVSS n° 116 DOT 4, ISO 4925, SAE J1704,
CUNA NC 956-01 synthetic fluid
Protective with antifreeze action, blue color, based on inhibited monoethylene
glycol, CUNA NC 956-16
Protective with antifreeze action, red colour, based on inhibited monoethylen
glycol, with O.A.T.-based organic formula, that passes CUNA NC 956-16,
ASTM D 3306 specifications
Additive for fuel oil with protective action for Diesel engines
Mixture of spirits and surface-active agents CUNA NC 956-11Recommended fluids
and lubricants
TUTELA CAR
ZC 75 Synth
TUTELA CAR
MATRYX
TUTELA GI/2
TUTELA CAR
CS SPEED
TUTELA GI/A
TUTELA MRM 2
TUTELA CAR TOP 4
for Alfa Romeo
PARAFLU 11 (*)
or
PARAFLU UP (*)
DIESEL MIX
TUTELA
PROFESSIONAL
SC 35
Applications
Mechanical gearbox and
differential
Mechanical gearbox and
differential for high
temperatures
Automatic gearbox
Selespeed transmission
electrically-operated
electrohydraulic drive
Hydraulic power steering
C.V. joints
Hydraulic brake and
clutch control
Cooling ducts
Percentage:
50% down to –35°C
To be mixed with the fuel
oil (25 cc per 10 litres)
To be used neat
or diluted

ALPHABETICAL INDEX
327
Bulbs
– general instructions ............... 218
– replacement .......................... 217
– types of bulbs ................. 218-219Car lifting
– with arm hoist ....................... 245
– with jack .............................. 245
– with workshop hoist .............. 245
Car maintenance..................... 248
Carrying children safely ................ 35
Catalytic converter ....................... 188
Ceiling lights................................ 162
– centre rear roof lamp .............. 163
– courtesy light......................... 163
– front roof light ....................... 162
– rear roof light ........................ 163
Centre rear roof lamp.................... 163
– bulb replacement ................... 231
Changing battery of key
with remote control ................... 10
Changing bulbs
– general instructions ............... 218
– replacement .......................... 217
– types of bulbs ................. 218-219
Changing wheels.......................... 209
– general instructions ................ 207Charging the battery .............. 242-268
Checking levels ............................ 254
– brake and clutch fluid ............. 263
– engine coolant....................... 261
– engine oil ............................. 257
– power steering oil .................. 261
– Q-system automatic
gearbox oil............................ 260
– Selespeed gearbox oil ............ 259
– windscreen/rearscreen/
headlamp washing fluid .......... 264
Child safety device .............. 19-35-279
Children (carrying safely) ............. 35
– child’s seats .................... 35-38
– presetting for installing the
Isofix type child restraint system 39
Cigar lighter ............................... 164
Cleaning and maintenance
– car exterior ........................... 274
– car interior ............................ 277
– engine compartment ............. 276
– fabric seats .......................... 277
– leather seats ........................ 277
– plastic parts........................... 277
– windows ............................... 276
Climate control system.................. 108
– air vents................... 108-109-110– controls ................................ 118
Climate control system, automatic
two-zone ................................. 114
Clock .......................... 57-58-59-60-61
Clutch
– checking fluid level
and topping up ...................... 263
CO
2emissions ............................. 324
CODE card................................... 7
Compact spare wheel ................... 294
– technical data ........................ 312
Controls ...................................... 135
Correct use of the car............ 189
Courtesy light .............................. 163
– bulb replacement ................... 232
Cruise control
(constant speed adjustment) ...... 53
Current socket (boot) ................... 285
D
ashboard ................ 57-58-59-60-61
– brighting adjustment............... 63
Dashboard lighting dimming .......... 136
Demisting-defrosting
– door mirrors .................... 25-133
– rearscreen....................... 26-133
– windscreen and front
side windows ........................ 132

ALPHABETICAL INDEX
328
Diesel filter ................................. 265
Dimensions ........................... 315-316
Dipped beam headlights
– aiming for left-hand/
right-hand driving ................... 178
– changing bulbs ..................... 224
– switching on ......................... 48
Direction indicators
– changing front bulbs ............... 223
– changing rear bulbs ................ 228
– changing side bulbs ................ 227
– switching on ......................... 49
Door mirrors.......................... 25-26
Doors
– centralized locking ................. 19
– child safety lock............... 20-279
– opening/closing
from inside ..................... 19-278
– opening/closing
from outside ................... 18-278
– remote control ....................... 7
– remote locking/unlocking ...... 16
Economy and environment-friendly
driving ..................................... 197
Electronic alarm system................. 11
– automatic engagement ........... 14
– cutting out the siren .............. 15
– description ............................ 11
– interrupting the alarm ............. 14
– ministerial homologation ........ 16
– request for additional
emote controls....................... 12
– switching off ........................ 13
– switching on ......................... 12
– volumetric protection ............. 15
– when the alarm is triggered ..... 14
Electronic control units ................. 270
Emergency starting ................ 191-205
– starting by inertia .................. 207
– starting with an auxiliary
battery ................................. 242
Engine
– identification codes................. 301
– marking ............................... 299
– specifications ......................... 302
Engine compartment
– bonnet ................................. 172
– cleaning................................ 276Engine coolant
– checking level and topping up .. 261
– temperature gauge
and warning light ................... 62
Engine lock system
(Alfa Romeo CODE) ................... 6
Engine oil
– checking level and topping up .. 257
– consumption ......................... 258
Environment
– economy and environment-
friendly driving....................... 197
– emission reducing devices . 187-188
– protecting emission
reducing devices .................... 198
– reducing running costs
and environment pollution ....... 195
– use of non-toxic materials........ 187
EOBD system............................... 182
First-aid kit ................................ 247
Fix&Go (quick tyre repair kit) ........ 212
Flashing main beam headlights ..... 49
Fluids and lubricants .................... 320
Front foglights
– adjustment............................ 177
– changing bulbs ..................... 225
– switching on.......................... 136

ALPHABETICAL INDEX
331
N
umber plate lights
– changing bulbs ................ 229-296
O
ddment recesses
– in the boot ........................... 285
– on centre console ................... 165
– on dashboard ........................ 165
Odometer ................................... 59
Paintwork (maintenance) ............ 275
– colour label ........................... 301
Parking....................................... 191
Parking sensors............................ 187
Partial odometer .......................... 63
Performance................................ 314
Pockets and compartments
on front doors ........................... 165
Pollen filter ................................ 266
Power steering
– checking fluid level
and topping up ..................... 262
Power windows ........................... 27
Pre-tensioning devices ................... 32
Protecting emission reducing
devices ....................................... 198
Q
-system automatic gearbox........ 152
– acoustic warning .................... 159
– automatic operation ............... 154
– checking the oil level .............. 260
– fault signalling ....................... 158
– manual operating mode/
Q-System activation................ 157
– moving off ............................ 152
– push starting ......................... 159
– selecting automatic/
manual gearshifting................ 153
– selecting the driving modes ..... 156
– starting the engine ................. 152
– stopping the car ..................... 157
– towing the car ....................... 160
R
adio transmitters and cellular
telephones ............................... 167
Rain sensor ................................. 51
Rear fog guards
– changing bulbs ............... 227-294
– switching on.......................... 136
Rear light units
– bulb replacement ................... 227
Rear roof lights ............................ 163
– changing bulbs ...................... 231
Rear seats................................... 23– centre armrest ................. 23-280
– headrests ....................... 24-279
– ski compartment.............. 24-280
Rear suspensions
(automatic geometry control) ..... 293
Rearscreen heating................. 26-133
Rearscreen washer ....................... 281
– spray jet ............................... 281
Rearscreen wiper
– blade replacement ................. 281
– operation .............................. 281
Reducing running costs
and environment pollution .......... 197
Refilling ..................................... 319
Remote control ............................ 7-12
– additional remote controls ...... 12
– alarm system ........................ 11
– boot opening ......................... 8
– changing the battery .............. 10
– door opening-closing ............... 7
– ministerial homologation ......... 325
– remote door locking/
unlocking .............................. 16
Rev counter................................. 62
Reversing lights
– changing bulbs ................ 227-294

ALPHABETICAL INDEX
332
Roof bars/ski racks ...................... 292
Roof rack provision ....................... 174
Rubber hoses .............................. 272Safe driving ............................... 192
– before driving off ................... 192
– driving in the fog ................... 194
– driving in the rain ................... 194
– driving on snow and ice .......... 195
– driving with ABS .................... 195
– mountain driving .................... 194
– night driving .......................... 193
– when travelling ...................... 192
Safeguarding the environment ...... 187
Scheduled maintenance
programme .............................. 249
Seat belts ................................... 28
– carrying children safely ........... 35
– front and rear side belt
height adjustment .................. 31
– general instructions ................ 33
– maintenance ......................... 34
– pretensioners......................... 32
– rear central abdominal belt ..... 30
– use ...................................... 28
Seats (front and rear) ............ 21-23
Selespeed gearbox ....................... 141– automatic operation (CITY) ..... 150
– checking the oil level .............. 259
– failure signalling .................... 150
– moving off ............................ 146
– operation with the engine off ... 143
– parking the vehicle ................. 151
– semiautomatic operation
(MANUAL) ............................ 148
– signalling with the buzzer........ 151
– starting the engine ................. 145
– stopping the car ..................... 148
– system activation ................... 142
– towing the vehicle .................. 151
– turning the engine off ............. 145
– warnings .............................. 146
Side lights
– changing front bulbs ............... 226
– changing rear bulbs ............... 228
– switching on.......................... 48
Ski compartment ......................... 24
Snow chains................................ 202
Sound system ...................... 183-293
Sound system presetting
system ............................. 183
Spark plugs (technical data) .......... 305
Speedometer............................... 63
Spray jets – windscreen/rearscreen/
headlight .............................. 274
Starting the engine....................... 189
– emergency starting .......... 191-205
– ignition switch ....................... 17
– procedure for JTD versions ....... 190
– procedure for petrol versions .... 189
– switching off the engine .......... 190
– warming the engine ............... 190
Starting with an auxiliary battery ... 242
Steering system
– specifications ......................... 305
– steering wheel adjustments .... 25
Steering lock .............................. 18
Steering wheel
– adjustment............................ 25
Steering wheel levers ................... 48
Stop lights
– changing bulbs ...................... 228
Sunroof ...................................... 167
– emergency operation ............. 169
– sliding forwards/backwards..... 168
– raising to the quarterlight
position ............................... 168
Sun visors .................................. 166
Symbols .................................... 5-6