2004 Acura TSX transmission fluid

To thoroughly f lush the transmission,
the technician should drain and ref ill
it with Honda ATF-Z1, then drive the
vehicle a short distance. Do this
three times. Then drain and ref ill the
transmission a f inal time.Insert the dipstick all the way back
into the transmission securely as
shown in the illustration.
Make sure the notch fits in the
dipstick guide and the dipstick is
down all the way.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to add f luid,
contact your Acura dealer. Remove the check bolt and look for
transmission f luid coming out of the
bolt hole. If a small amount of f luid
drips out of the bolt hole, reinstall
the check bolt.
Check the f luid level with the
transmission at normal operating
temperature and the car sitting on
level ground.
To check the transmission f luid level,
remove the two bolts, then pull down
the lef t part of the under cover.
6.
CONT INUED
T ransmission Fluid
Maint enance
6-speed Manual Transmission
257
BOLT
BOLT UNDER COVER CHECK BOLT

Pour the f luid to the f iller hole slowly
and caref ully so you do not spill.
Clean up any spills immediately.
Spilled f luid could damage
components in the engine
compartment.
If Honda MTF is not available, you
may use an SAE 10W-30 or 10W-40
viscosity motor oil with the API
Certif ication seal that says ‘‘FOR
GASOLINE ENGINES’’ as a
temporary replacement. However,
motor oil does not contain the proper
additives, and continued use can
cause stiffer shifting. Replace as
soon as it is convenient.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.If you are not sure how to check and
add f luid, contact your Acura dealer.
If no f luid comes out, remove the
f iller bolt. Slowly add Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the check bolt
hole. Let the f luid run out until it
stops, then reinstall the check bolt
and the f iller bolt.
Af ter checking and adding the f luid,
put the under cover back in place
and tighten the bolts securely.
T ransmission Fluid
Maint enance258
FILLER BOLT

The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. However, the use of
any non-Honda brake fluid can cause
corrosion and decrease the lif e of the
system. Have the brake system
f lushed and ref illed with Honda
Heavy Duty Brake Fluid DOT 3 as
soon as possible.
Check the f luid level in the reser-
voirs monthly. There are up to two
reservoirs, depending on the model.
They are:
Brake f luid reservoir (all models)
Clutch f luid reservoir
(manual transmission only)
The brake f luid should be replaced
according to the time recommenda-
tion in the maintenance schedule.
Brake f luid marked DOT 5 is not
compatible with your car’s braking
system and can cause extensive
damage. Pour the f luid slowly and caref ully so
you do not spill. Clean up any spills
immediately. Spilled f luid could
damage components in the engine
compartment.Brake System
Brake and Clutch Fluid
Maint enance259
MAX MIN

µµÎ
Î
Î
Î
Specif ications
T echnical Inf ormation334
Weights Dimensions
Air Conditioning
Capacities Capacities
1.43 US gal (5.4
)
1.40 US gal (5.3)
Gross vehicle weight rating See the certification label attached to the driver’s doorjamb.
HFC-134a (R-134a)
25 27 oz (700 750 g)
Length
Width
Height
Wheelbase
Track
105.1 in (2,670 mm)
59.6 in (1,515 mm)
59.6 in (1,515 mm) 183.3 in (4,657 mm)
69.4 in (1,762 mm)
57.3 in (1,456 mm)
ND-OIL8
Refrigerant type
Charge quantity
Lubricant type
Fuel tank 1.96 US gal (7.4
)
1.93 US gal (7.3)
4.4 US qt (4.2
)
4.2 US qt (4.0
)
5.6 US qt (5.3
)
2.1 US qt (2.0)
2.3 US qt (2.2)
3.0 US qt (2.8)
6.9 US qt (6.5)
Engine
coolant
Engine oil
Manual trans-
mission oil
Automatic
transmission
fluid
Windshield
washer
reservoir
4.8 US qt (4.5
)
2.6 US qt (2.5)
Including the coolant in the reserve tank and that remaining in the
engine.
Reserve tank capacity: 0.16 US gal (0.6
)
Excluding the oil remaining in the engine.
17.1 US gal (64.7
)
Approx.
Front
Rear
Change
Manual
Automatic
Total Manual
Automatic
Change Including
filter
Without
filter
Total
Change
Total
Change
Total
U.S. Cars
Canada Cars
1:
2:
1
2

CONT INUED
...
Accessories and Modif ications . 191
................................
Accessories .191
.
Additional Safety Precautions . 192
............................
Modif ications .192
ACCESSORY (Ignition Key .......................................
Position) .81
.............
Accessory Power Socket . 109
....................
Additives, Engine Oil . 246
.....................................
Airbag (SRS) .9
.....................
Air Cleaner Element .261
............................
Air Conditioning .115
..............................
Maintenance .269
.........................................
Usage .115
.......................
Air Pressure, Tires .273
.......................
Alcohol in Gasoline .340
......................................
Antif reeze .249
Anti-lock Brakes (ABS) ................................
Description .213
...............................
Indicator .61, 214
...................................
Operation .213
.
Anti-thef t Steering Column Lock . 80
..........................
Appearance Care .295
..........................................
Armrest .105
........................
Audio System .129, 148 .............
Automatic Speed Control . 174
..............
Automatic Transmission . 204
..........................
Capacity, Fluid .334
...............
Checking Fluid Level . 256
.......................................
Shif ting .204
.
Shif t Lever Position Indicator . 204
................
Shif t Lever Positions . 204
....................
Shif t Lock Release . 210
Battery ......
Charging System Light . 60,318
............................
Jump Starting .312
..............................
Maintenance .265
............................
Specif ications .335
..............................
Bef ore Driving .183
..........................................
Belts, Seat .8
.........................
Beverage Holders .106
...................................
Body Repair .312
Brakes ...........
Anti-lock System (ABS) . 213
.............
Break-in, New Linings . 184
....................
Bulb Replacement .286
...........................................
Fluid .259
.......................................
Parking .104 .........................
System Indicator .60
........................
Wear Indicators .212
.............................
Braking System .213
........................
Break-in, New Car .184
..
Brightness Control, Instruments . 72
........................
Brights, Headlights .70
Bulb Replacement ..........................
Back-up Lights .287
..............................
Brake Lights .286
..............................
Ceiling Light .290
................
Door Courtesy Light . 291
................
Front Parking Lights . 285
.................................
Headlights .282
.........
High-mount Brake Light . 289
...................
License Plate Light . 289
............................
Specif ications .335
...................................
Spotlights .290
...............................
Trunk Light .292
....................
Turn Signal Lights . 284
................
Vanity Mirror Lights . 291
..............................
Bulbs, Halogen .282
Index
A
B
I

Î
............................
Capacities Chart .334
.............
Carbon Monoxide Hazard . 53
.............................
Carrying Cargo .193
..............
CAUTION, Explanation of . ii
..........................
CD Changer .136, 156
........................
CD Pocket, Center .107
........................
Certif ication Label .332
............................................
Chains .278
....................
Changing a Flat Tire .305
............
Changing Engine Coolant . 251
Changing Oil ........................................
How to .246
......................................
When to .234
...
Charging System Indicator . 60,318
............
Checklist, Bef ore Driving . 198
..................
Childproof Door Locks . 87
.......................................
Child Seats .26
..........
Tether Anchorage Points . 39
...................................
Cleaner, Air .261
Cleaning ....................
Aluminum Wheels .297
...................................
Carpeting .298
......................................
Exterior .296
.........................................
Fabric .299 .......................................
Interior .298
.......................................
Leather .299
...................................
Seat Belts .299
...........................................
Vinyl .299
......................................
Window .300
...............
Climate Control System . 114
.................
Clock, Setting the . 135,153
...................................
Clutch Fluid .260
........................
CO in the Exhaust .342
............
Cold Weather, Starting in . 200
..............................
Compact Spare .304
.................
Console Compartment . 105
...............
Consumer Inf ormation . 348
.............
Controls, Instruments and . 57
Coolant ........................................
Adding .249
....................................
Checking .189
.........................
Proper Solution .249
...................
Temperature Gauge . 66
....................
Corrosion Protection .311
Crankcase Emissions Control ........................................
System .342
............
Cruise Control Operation . 174
..........
Customer Relations Of f ice . 348................
DANGER, Explanation of . ii
.......................................
Dashboard .58
................
Daytime Running Lights . 72
............
Def ects, Reporting Saf ety . 350
................
Def ogger, Rear Window . 75
....................................
Dimensions .334
...............
Dimming the Headlights . 70
Dipstick ..........
Automatic Transmission . 256
..................................
Engine Oil .187
..........................
Directional Signals .73
........
Disc Brake Wear Indicators . 212
.....................
Disposal of Used Oil .248
Doors ..............
Locking and Unlocking . 81
..........
DOT Tire Quality Grading . 337
Downshif ting, 5-speed Manual
.............................
Transmission .201
.....................................
Drive Belts .272
...........
Driver and Passenger Safety . 5
...........................................
Driving .197
....................................
Economy .190
.........................
In Bad Weather .219
................
In Foreign Countries . 341
Index
C D
II

CONT INUED
..................
Dust and Pollen Filter . 270
............................
Fabric, Cleaning .299
...................................
Fan, Interior .115
Features, Comfort and ..............................
Convenience .113
....................
Filling the Fuel Tank . 184
Filter .........................
Dust and Pollen .270
...............................................
Oil .246
.............
Flashers, Hazard Warning . 75
...................
Flat Tire, Changing a . 305
Fluids ..........
Automatic Transmission . 256..........................................
Brake .259
.........................................
Clutch .260
..............
Manual Transmission . 257
..........................
Power Steering .260
..................
Windshield Washer . 255
...........................
Folding Rear Seat .94
.....
Foreign Countries, Driving in . 341
..........................
Four-way Flashers .75
.................................................
Fuel .184
......................
Fill Door and Cap .185
...........................................
Gauge .67
................
Octane Requirement . 184
...............................
Oxygenated .340
........................
Tank, Filling the .184
.....................
Fuses, Checking the .324
...............
Gas Mileage, Improving . 190
..........................................
Gasohol .340
.........................................
Gasoline .184
...........................................
Gauge .67
................
Octane Requirement . 184
........................
Tank, Filling the .184
..............................
Economy, Fuel .190
............
Emergencies on the Road . 303
.............
Battery, Jump Starting . 312
...........
Brake System Indicator . 321
................
Changing a Flat Tire . 305
.....
Charging System Indicator . 318
..................
Checking the Fuses . 324
.....
Low Oil Pressure Indicator . 317
...
Malf unction Indicator Lamp . 319
...
Manually Closing Moonroof . 322
..................
Overheated Engine . 315
.........................
Emergency Brake .104
......................
Emergency Flashers .75
......................
Emergency Towing .328
.......................
Emissions Controls .342
Engine ............................................
Belts .272
....
Coolant Temperature Gauge . 66
Malf unction Indicator ................................
Lamp .60, 319
........
Oil Pressure Indicator . 60,317
..............
Oil, What Kind to Use . 244...............................
Overheating .315
............................
Specif ications .335
....................
Speed Limiter . 202,209
.......................................
Starting .199
..........
Engine Speed Limiter . 202,209
......................
Ethanol in Gasoline .340
.
Evaporative Emissions Controls . 342
...............................
Exhaust Fumes .53
Expectant Mothers, Use of Seat ........................................
Belts by .19
..................
Exterior, Cleaning the . 296
Index
E
FG
III

CONT INUED
......
LOCK (Ignition Key Position) . 80
Locks .......
Anti-thef t Steering Column . 80
............................
Fuel Fill Door .184
....................................
Glove Box .89
...........................................
Trunk .87
........................
Low Coolant Level .189
...
Lower Gear, Downshif ting to a . 201
...
Low Oil Pressure Indicator . 60,317
...
Lubricant Specif ications Chart . 334
.........................................
Luggage .193
..................................
Maintenance .229
...
Owner Maintenance Checks . 242
........................................
Record .239
......................
Required Indicator .67
..........................................
Saf ety .230
.............................
Schedule .234-238
.
Malf unction Indicator Lamp . 60,319
...................
Manual Transmission . 202
........
Manual Transmission Fluid . 257
...............................
Meters, Gauges .65
...................
Methanol in Gasoline . 340
........................
Mirrors, Adjusting .102 .......................................
Moonroof .101
......................
Closing Manually .322
...................................
Operation .101
...................
Neutral Gear Position . 206
..................
New Vehicle Break-in . 184
.....................
Normal Shif t Speeds .202
..................
NOTICE, Explanation of . ii
...............
Numbers, Identif ication . 332..............
Panel Brightness Control . 72
........................
Park Gear Position .205
...........................................
Parking .211
...............................
Parking Brake .104
.................................
Parking Lights .70
..
Parking Over Things that Burn . 344
.............................
PGM-FI System .343
..................
Polishing and Waxing . 297
...................................
Pollen Filter .270
............
Pre-Drive Saf ety Checklist . 11
.........
Pregnancy, Using Seat Belts . 19
............................
Protecting Adults .12
...
Additional Safety Precautions . 20
.....
Advice f or Pregnant Women . 19
...
Octane Requirement, Gasoline . 184
.........................................
Odometer .65
Odometer/Outside Temperature ......................................
Indicator .66
...............................
Odometer, Trip .66
Oil ........................
Change, How to .246
......................
Change, When to .232
......................
Checking Engine .187
..............
Pressure Indicator . 60,317
Selecting Proper Viscosity ......................................
Chart .245 ...........
ON (Ignition Key Position) . 81
..
Operation in Foreign Countries . 341
............................
Outside Mirrors .102
.....................
Outside Temperature .66
....................
Overheating, Engine .315
.......
Owner Maintenance Checks . 242
..........................
Oxygenated Fuel .340
Index
MO N
P
V