2004 Acura RSX maintenance schedule

Always use Honda ATF-Z1
(Automatic Transmission Fluid). If
it’s not available, you may use a
DEXRON
III automatic
transmission f luid as a temporary
replacement. However, continued
use can affect the shift quality. Have
the transmission f lushed and ref illed
with Honda ATF-Z1 as soon as it is
convenient.
To thoroughly f lush the transmission,
the technician should drain and ref ill
it with Honda ATF-Z1, then drive the
vehicle f or a short distance. Do this
three times. Then drain and ref ill the
transmission a f inal time.
Insert the dipstick all the way back
in the transmission.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule. Check the f luid level with the
transmission at normal operating
temperature and the vehicle sitting
on level ground. Remove the
transmission f iller bolt, and caref ully
f eel inside the bolt hole with your
f inger. The f luid level should be up
to the edge of the bolt hole. If it is
not, add Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole. Reinstall
the f iller bolt, and tighten it securely.If Honda MTF is not available, you
may use an SAE 10W-30 or 10W-40
viscosity motor oil with the API
Certif ication seal that says ‘‘FOR
GASOLINE ENGINES’’ as a
temporary replacement. However,
motor oil does not contain the proper
additives, and continued use can
cause stiffer shifting. Replace as
soon as it is convenient.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
6.
A ut omat ic T ransmission Fluid, Manual T ransmission Fluid
Maint enance
Manual Transmission Fluid
170
Correct level
FILLER BOLT

Check the f luid level in the
reservoirs monthly. There are up to
two reservoirs, depending on the
model. They are:Brake f luid reservoir (all models)
Clutch f luid reservoir
(manual transmission only)
The brake f luid should be replaced
according to the time recommenda-
tion in the maintenance schedule.
The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement. However, the use of
any non-Honda brake fluid can cause
corrosion and decrease the lif e of the
system. Have the brake system
f lushed and ref illed with Honda
Heavy Duty Brake Fluid DOT 3 as
soon as possible.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage.
Brake and Clutch Fluid
Maint enance
Brake System
171
MAX
MIN

An auto-tensioner adjusts the tension
of the drive belt. The indicator on
the auto-tensioner should be in the
proper range. It should be checked
accordingtothetimeanddistance
recommendations in the
maintenance schedule.If the indicator is not within the
proper range, have the drive belt
replaced by your Acura dealer as
soon as possible.
Low f luid level can indicate a leak in
the clutch system. Have this system
inspected as soon as possible. The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If it is not, add
brake f luid to bring it up to that level.
Use the same fluid specified for the
brake system.
Manual Transmission only
Brake and Clutch Fluid, Drive Belts
Maint enance
Drive Belt
Clutch System
172
INDICATOR
Proper range
MAX
MIN

Clean the hood latch assembly with a
mild cleaner, then lubricate it with a
multipurpose grease. Lubricate all
the moving parts (as shown),
including the pivot. Follow the time
and distance recommendations in
the Maintenance Schedule. If you
are not sure how to clean and grease
the latch, contact your Acura dealer.
Check the level on the side of the
reservoir when the engine is cold.
The f luid should be between the
UPPER LEVEL and LOWER LEVEL.
If not add power steering f luid to the
UPPER LEVEL mark.
Always use Honda Power Steering
Fluid. You may use another power
steering f luid as an emergency
replacement, but have the power
steering system f lushed and ref illed with Honda PSF as soon as possible.
A low power steering f luid level can
indicate a leak in the system. Check
the f luid level f requently, and have
the system inspected as soon as
possible.
Power Steering Fluid, Hood L atch
Maint enance
Hood L atch
Power Steering Fluid
173
NOTICE:
NOTICE:
UPPER LEVEL
LOWER LEVEL LATCH ASSEMBLY
PIVOTS
T urning the steering wheel to
f ull lef t or right lock and holding it
there can damage the power steering
pump.
Do not spill the power
steering f luid over the body, auto-
tensioner, drive belt and pulleys.
If spilled accidentally, wipe of f any
f luid completely.

If you need to park your vehicle f or
an extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors.Fill the f uel tank.
Change the engine oil and f ilter.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc. are
completely dry.
Leave the parking brake off. Put
the transmission in Reverse
(manual) or Park (automatic). Block the rear wheels.
If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the vehicle is being stored
indoors).
Disconnect the battery.
Support the f ront and rear wiper
blade arms with a f olded towel or
ragsotheydonottouchthe
windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and hatch seals. Also, apply a body
wax to the painted surf aces that
mate with the door and hatch seals.Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, such
as plastic sheeting, trap moisture,
which can damage the paint.
If possible, periodically run the
engine until it reaches f ull
operating temperature (the
cooling f ans cycle on and of f
twice). Pref erably, do this once a
month.
If you store your vehicle f or 12
months or longer, have your Acura
dealer perf orm the inspections called
f or in the 24 months/30,000 miles
(48,000 km) maintenance schedule
(Normal Conditions) as soon as you
take it out of storage (see page ).
The replacements called f or in the
maintenance schedule are not
needed unless the vehicle has
actually reached that time or mileage. 159
Vehicle Storage
Maint enance190

ÎÎ
The burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx) and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons. Con-
trolling the production of NOx, CO,
and HC is important to the environ-
ment. Under certain conditions of
sunlight and climate, NOx and HC
react to f orm photochemical ‘‘smog.’’
Carbon monoxide does not contri-
bute to smog creation, but it is a
poisonous gas.
In Canada, Acura vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured. Your vehicle has a Positive
Crankcase Ventilation System. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The Positive Crank-
case Ventilation valve routes them
from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
157
Emissions Cont rols
T echnical Inf ormation
Crankcase Emissions Control
System
Evaporative Emissions Control
System
The Clean Air Act
225

CONT INUED
...........................
Side Airbag Of f .50
...............................................
SRS .50
Turn Signal and Hazard ...................................
Warning .52
..............................
Washer Level .53
.........
Indicators, Instrument Panel . 49
...............................
Inf ant Restraint .33
Inf ant Seats .........................................
LATCH .37
...........................
Lower Anchors .37
..........
Tether Anchorage Points . 40
...................
Inf lation, Proper Tire . 183
...................................
Inside Mirror .80
.............................
Inspection, Tire .185
........................
Instrument Panel .2 ,49
........
Instrument Panel Brightness . 61
..........
Instrument Panel Indicators . 50
.................................
Interior Lights .83
........................................
Introduction . i
.................
Jacking up the Vehicle . 195
.......................................
Jack, Tire .194
................................
Jump Starting .200 ..................................................
Keys .63
.......................
Label, Certif ication .218
.................
Lane Change, Signaling . 60
..................
Lap/Shoulder Belts . 14,19
...........
LATCH Anchorage System . 37
Lights ....................
Bulb Replacement .174
.....................................
Load Limit .130
......
LOCK (Ignition Key Position) . 65
Locks .......
Anti-thef t Steering Column . 65
............................
Fuel Fill Door .122
....................................
Glove Box .71
............................................
Hatch .68
..............
Power Door and Hatch . 67
........................
Low Coolant Level .125
.........................
Low Fuel Indicator .52
...
Low Oil Pressure Indicator . 51,204
.................................
Lower Anchor .37
...
Lower Gear, Downshif ting to a . 136Lubricant Specif ications
..................................
Chart .220, 221
..............
Luggage, .129
.....
Luggage Cover (Cargo Cover) . 76
..................................
Maintenance .155
...
Owner Maintenance Checks . 158
........................................
Record .161
......................
Required Indicator .54
..........................................
Saf ety .156
.............................
Schedule .159-160
.
Malf unction Indicator Lamp . 51,206
...................
Manual Transmission . 136
...............
Checking Fluid Level . 170
................................
Shif ting the .136
........
Manual Transmission Fluid . 170
...............................
Meters, Gauges .56
..........................
Mirrors, Adjusting .81
...............
Modif ying Your Vehicle . 128
.........................................
Moonroof .80
......................
Closing Manually .209
.....................................
Operation .80
Storing (Cargo)
Index
J K
L
M
V

...................
Neutral Gear Position . 140
..................
New Vehicle Break-in . 121
.....................
Normal Shif t Speeds .137
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 218 ...................
Radiator Overheating . 202
...............
Radio/CD Sound System . 92
...........................
Readiness Codes .228
..
Rear Lights, Bulb Replacement . 178
............................
Rear Seat Access .73
..........................
Rear Seat, Folding .74
............................
Rear View Mirror .80
.................
Rear Window Def ogger . 61
....................
Rear Window Washer .59
.......................
Rear Window Wiper .59
...............
Reclining the Seat Backs . 72
.......
Recommended Shif t Speeds . 137
.......................
Reminder Indicators .49
.......................
Remote Transmitter .69
Replacement Inf ormation ..............
Dust and Pollen Filter . 180
................
Engine Oil and Filter . 165
.................................
Floor Mats .180
..........................................
Fuses .211
................................
Light Bulbs .174
....................................
Schedule .159
...................................
Seat Belts .180
...........................................
Tires .183
.............................
Wiper Blades .181
..............
Panel Brightness Control . 61
........................
Park Gear Position .140
...........................................
Parking .145
.................................
Parking Brake .82
Parking Brake and Brake .................
System Indicator . 51,208
........................
Parking Lights .60, 177
..
Parking Over Things that Burn . 145
............................
Playing the Radio .92
..................................
Playing a CD .101
..................
Playing a CD Changer . 101
.................................
Playing a Tape .98
.............................
PGM-FI System .226
..........................
Power Door Locks .67
.................
Power Socket Locations . 85
..............................
Power Windows .78
.........
Pregnancy, Using Seat Belts . 17
.........
Protecting Adults and Teens . 11
...
Additional Safety Precautions . 17
.....
Advice f or Pregnant Women . 17
........................
Protecting Children .29
.....................
General Guidelines .29
...........................
Protecting Inf ants .33
.............
Protecting Small Children . 34
...
Octane Requirement, Gasoline . 121
.........................................
Odometer .56
...............................
Odometer, Trip .56
Oil ........................
Change, How to .165
......................
Change, When to .159
......................
Checking Engine .125
..............
Pressure Indicator . 51,204
Selecting Proper Viscosity ..............................
Chart .164, 165
...........
ON (Ignition Key Position) . 66
Onboard Ref ueling Vapor ....................................
Recovery .226
..............................
Outside Mirrors .81
....................
Overheating, Engine .202
.......
Owner Maintenance Checks . 158
Index
N
O PR
VI