2003 TOYOTA TUNDRA radiator cap

’03 TUNDRA_U (L/O 0307)
238
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
  \b 
\f \f




 ith  

\f \f

\f down to about the
middle position     


  


  
 





At this time, if you depress the accelera-
tor pedal more firmly and slowly, you can
drive your vehicle at low speeds. Have
your vehicle checked by your Toyota deal-
er as soon as possible.
Even if the abnormality of the electronic
throttle control system is corrected during
low speed driving, the system may not be
recovered until the engine is stopped and
the ignition key is turned to “ACC” or
“LOCK” position.
CAUTION
Be especially careful to prevent erro-
neous pedal operation.
  \b 
\f \f




 ith  

\f \f

\f down  
   

 

 
  






At this time, vibration may occur. Howev-
er, if you depress the accelerator pedal
more firmly and slowly, you can drive your
vehicle at low speeds. Have your vehicle
checked by your Toyota dealer as soon as
possible.
Even if the abnormality of the electronic
throttle control system is corrected during
low speed driving, the system may not be
recovered until the engine is stopped and
the ignition key is turned to “ACC” or
“LOCK” position.
CAUTION
Be especially careful to prevent erro-
neous pedal operation.
If your engine coolant temperature
gauge indicates overheating, if you ex-
perience a loss of power, or if you hear
a loud knocking or pinging noise, the
engine has probably overheated. You
should follow this procedure... 1. Pull safely off the road, stop the ve- hicle and turn on your emergency
flashers. Put the transmission in “P”
(automatic) or neutral (manual) and ap-
ply the parking brake. Turn off the air
conditioning if it is being used.
2. If coolant or steam is boiling out of the radiator or reservoir, stop the engine.
Wait until the steam subsides before
opening the hood. If there is no coolant
boiling over or steam, leave the engine
running.
CAUTION
To help avoid personal injury, keep
the hood closed until there is no
steam. Escaping steam or coolant is
a sign of very high pressure.
If you cannot incr ease the
engine speed
(5VZFE engine) If you cannot incr
ease the
engine speed
(2UZFE engine) If your vehicle overheats

’03 TUNDRA_U (L/O 0307)
239
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
3. Visually check to see if the engine
drive belt (fan belt) is broken or loose.
Look for obvious coolant leaks from the
radiator, hoses, and under the vehicle.
However, note that water draining from
the air conditioning is normal if it has
been used.
CAUTION
When the engine is running, keep
hands and clothing away from the
moving fan and engine drive belts.
4. If the engine drive belt is broken or thecoolant is leaking, stop the engine im-
mediately. Call a Toyota dealer for as-
sistance.
5. If the engine drive belt is O.K. and there are no obvious leaks, you may
help the engine cool down more quickly
by running it at about 1500 rpm for a
few minutes with the accelerator pedal
lightly depressed.
6. Check the coolant reservoir. If it is dry, add coolant to the reservoir while the
engine is running. Fill it about half full.
CAUTION
Do not attempt to remove the radiator
cap when the engine and radiator are
hot. Serious injury could result from
scalding hot fluid and steam blown
out under pressure.
7. After the engine coolant temperaturehas cooled to normal, again check the
coolant level in the reservoir. If neces-
sary, bring it up to half full again. Seri-
ous coolant loss indicates a leak in the
system. You s hould have it checked as
soon as possible at your Toyota dealer.
1. Reduce your speed gradually, keeping a straight line. Move cau-
tiously off the road to a safe place
well away from the traffic. Avoid
stopping on the center divider of
a highway. Park on a level spot
with firm ground.
2. Stop the engine and turn on your emergency flashers.
3. Firmly set the parking brake and put the transmission in “P” (auto-
matic) or reverse (manual).
4. Have everyone get out of the ve- hicle on the side away from traffic.
5. Read the following instructions thoroughly.
If you have a flat tire—

’03 TUNDRA_U (L/O 0307)
272
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
1. Power steering fluid reservoir
2. Engine oil level dipstick
3. Engine oil filler cap
4. Brake fluid reservoir
5. Fuse block
6. Battery
7. Engine coolant reservoir
8. Radiator
9. Condenser
10. Windshield washer fluid tank
Engine compartment overview
 5VZFE engine

’03 TUNDRA_U (L/O 0307)
273
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
1. Power steering fluid reservoir
2. Engine oil level dipstick
3. Engine oil filler cap
4. Brake fluid reservoir
5. Fuse block
6. Battery
7. Engine coolant reservoir
8. Radiator
9. Condenser
10. Windshield washer fluid tank

2UZFE engine

’03 TUNDRA_U (L/O 0307)
275
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment—the engine, radiator,
exhaust manifold, power steering
fluid reservoir and spark plug
boots, etc.—will be hot. So be care-
ful not to touch them. Oil, fluids
and spark plugs may also be hot.
If the engine is hot, do not remove
the radiator cap or loosen the drain
plugs to prevent burning yourself.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
Do not leave used oil within the
reach of children.
Dispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Warning: Battery posts, terminals
and related accessories contain lead
and lead compounds, chemicals
known to the State of California to
cause cancer and reproductive
harm. Wash hands after handling.
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
 Add only demineralized or distilled
water to fill the radiator. And if you
spill some of the coolant, be sure
to wash it off with water to prevent
it from damaging the parts or paint.
 Do not allow dirt or anything else
to fall through the spark plug holes.
 Do not pry the outer electrode of a
spark plug against the center elec-
trode.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not overfill automatic transmis-
sion fluid, or the transmission
could be damaged.
 Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.

’03 TUNDRA_U (L/O 0307)
282
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Oil identification marks
Either or both API registered marks are
added to some oil containers to help
you select the oil you should use.
The API Service Symbol is located any-
where on the outside of the container.
The top portion of the label shows the oil
quality by API (American Petroleum Insti-
tute) designations such as SL. The center
portion of the label shows the SAE viscos-
ity grade such as SAE 5W−30. “Energy −
Conserving” shown in the lower portion,
indicates that the oil has fuel −saving ca-
pabilities.
The ILSAC (International Lubricant Stan-
dardization and Approval Committee) Certi-
fication Mark is displayed on the front of
the container.
To ensure excellent lubrication perfor-
mance for your engine, “Toyota Genuine
Motor Oil” is available, which has been
specifically tested and approved for all
Toyota engines.
Please contact your Toyota dealer for fur-
ther details about “Toyota Genuine Motor
Oil”. Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “F” and “L” lines on the reservoir.
If the level is low, add ethyleneglycol
type coolant for a proper corrosion
protection of aluminum components.
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “L” line, add
coolant. Bring the level up to the “F” line.
Always use ethylene
−glycol type coolant
for a proper corrosion protection of alumi-
num components. See information in the
next column.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, radiator cap and drain
cock and water pump.
If you can find no leak, have your Toyota
dealer test the cap pressure and check
for leaks in the cooling system.
CAUTION
To prevent burning yourself, do not
remove the radiator cap when the en-
gine is hot.
Checking the engine coolant
level

’03 TUNDRA_U (L/O 0307)
284
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
If any of the above parts are extremely
dirty or you are not sure of their condi-
tion, take your vehicle to a Toyota dealer.
CAUTION
To prevent burning yourself, be care-
ful not to touch the radiator or con-
denser when the engine is hot.
NOTICE
To prevent damage to the radiator
and condenser, do not perform the
work by yourself.
To check the fluid level, simply look at
the seethrough reservoir. The level
should be between the “MAX” and
“MIN” lines on the reservoir.
It is normal for the brake fluid level to go
down slightly as the brake pads wear. So
be sure to keep the reservoir filled.
If the reservoir needs frequent refi lling, it
may indicate a serious mechanical prob-
lem. If the level is low, add SAE J1703 or
FMVSS No.116 DOT 3 brake fluid to the
brake reservoir.
Remove and replace the reservoir cap by
hand. Fill the brake fluid to the dotted
line. This brings the fluid to the correct
level when you put the cap back on.
Use only newly opened brake fluid. Once
opened, brake fluid absorbs moisture from
the air, and excess moisture can cause a
dangerous loss of braking.
CAUTION
Take care when filling the r
eservoir
because brake fluid can harm your
eyes and damage painted surfaces. If
fluid gets in your eyes, flush your
eyes with clean water immediately. If
you still feel uncomfortable with your
eyes, go to the doctor.
NOTICE
If you spill the fluid, be sure to wash
it off with water to prevent it from
damaging the parts or paint.
Checking the radiator and
condenser Checking brake fluid

’03 TUNDRA_U (L/O 0307)
1
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
A
Access doors 14
. . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 299
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 32,33
. . . . . . . . . . . . . . . . . . . . . .
Seat belt 38
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 158
. . . . . . . . . . . . . . .
Airbags 47
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 294
. . . . . . . . . .
Anti −glare inside rear view mirror 88 . . . . . . .
Anti −lock brake system warning
light 104
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti −theft steering column lock 112 . . . . . . . .
Appearance care
Cleaning the interior 262
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 260
. . . . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 261
. . . . . . . . . . . . . . . .
Armrest 35
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ashtray 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio remote controls 150
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 113
. . . . . . . . . . . . . . . . . . . . .
Shift pattern 113
. . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 113
. . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 104
. . . . . . . . . . .
Auxiliary boxes 171
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 23
. . . . . . . . . . .
B
Battery
Checking battery condition 296 . . . . . . . . . .
Gas caution 296 . . . . . . . . . . . . . . . . . . . . . . .
Handling safety 296 . . . . . . . . . . . . . . . . . . . .
Recharging precautions 297 . . . . . . . . . . . . .
Winter driving tips 218 . . . . . . . . . . . . . . . . . .
Before starting the engine 214 . . . . . . . . . . . . .
Brake pad wear limit indicators 196 . . . . . . . .
Brake system 193 . . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 104 . . . . . . . . . . . .
Brakes
Fluid level 284 . . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 196 . . . . . . . . . . . .
Parking 123
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 187
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 94
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 128
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 191
. . . . . . . . . . . . .
Cargo and luggage
Capacity 208
. . . . . . . . . . . . . . . . . . . . . . . . . .
Capacity and distribution 209
. . . . . . . . . . . .
Stowage precautions 209
. . . . . . . . . . . . . . .
Cargo lamp 95
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette player 128
. . . . . . . . . . . . . . . . . . . . . .
Cassette tape holder 179
. . . . . . . . . . . . . . . . .
Certification regulation label 197
. . . . . . . . . . .
Checking and replacing fuses 298
. . . . . . . . .
Checking brake fluid 284
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 280
. . . . . . . . . . Checking the radiator and
condenser 284
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 57
. . . . . . . . . . . . . . .
Installation 59,67
. . . . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 82,84
. . . . . . . . . . . . . . . . . . . .
Precautions 56
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 58 . . . . . . . .
Using a top strap 77,79
. . . . . . . . . . . . . . . . .
Cigarette lighter 166
. . . . . . . . . . . . . . . . . . . . . .
Cleaning the interior 262
. . . . . . . . . . . . . . . . . .
Clock 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clutch start cancel switch 126
. . . . . . . . . . . . .
Coin holder 175,177
. . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 218
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc and cassette tape holder
Cassette tape holder 177,178
. . . . . . . . . . .
Compact disc holder 177,178
. . . . . . . . . . . .
Compact disc changer 128
. . . . . . . . . . . . . . . .
Compact disc changer controller 128 . . . . . . .
Compact disc player 128
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 284
. . . . . . . . . . . .
Console box
Rear 173,174
. . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,6
. . . . . . . . . . . .
Cooling system
Coolant level 282
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 238
. . . . . . . . . . . . . . . . .
Radiator and reservoir 282
. . . . . . . . . . . . . .
Radiator cap 238
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 218
. . . . . . . . . . . . . . . . . .
Corrosion prevention 260
. . . . . . . . . . . . . . . . .