2003 TOYOTA TUNDRA hood open

’03 TUNDRA_U (L/O 0307)
2
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
1. Side vents
2. Instrument cluster
3. Center vents
4. Personal lights
5. Garage door opener box or auxiliary
box
6. Side defroster outlet
7. Glove box
8. Power door lock switches
9. Power window switches
10. Manual transmission gear shift lever
11. Front drive control lever
12. Rear condole box
13. Cup holders
14. Parking brake lever
15. Lower vent
16. Hood lock release lever
17. Window lock switch
18. Power rear view mirror control switches
Instrument panel overview
 Vehicles with manual transmission

’03 TUNDRA_U (L/O 0307)
3
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
1. Side vents
2. Instrument cluster
3. Automatic transmission selector lever
4. Center vents
5. Personal lights
6. Garage door opener box or auxiliary
box
7. Side defroster outlet
8. Glove box
9. Power door lock switches
10. Power window switches
11. Auxiliary box
12. Rear condole box
13. Cup holders
14. Lower vent
15. Hood lock release lever
16. Parking brake pedal
17. Window lock switch
18. Power rear view mirror control switches

Vehicles with automatic transmission

’03 TUNDRA_U (L/O 0307)
23
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
3. Slide the tailgate a little to the right
to unhook the left side.
To attach the tailgate, follow the removal
procedure in reverse order.
After closing the tailgate, try pulling it to-
ward you to make sure it is securely
closed.
We recommend you keep the tailgate
closed when not in use.
NOTICE
Make sure the support brackets are
securely latched on both side panels
when installing the tailgate.
LOCKING AND UNLOCKING WITH KEY
Insert the key into the keyhole and turn
it to lock or unlock the tailgate.
To lock: Turn the key clockwise.
To unlock: Turn the key counterclockwise.To open the hood: 1. Pull the hood lock release lever. The hood will spring up slightly.
CAUTION
Before driving, be sure that the hood
is closed and securely locked. Other-
wise, the hood may open unexpected-
ly while driving and an accident may
occur.
Hood

’03 TUNDRA_U (L/O 0307)
238
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
  \b 
\f \f




 ith  

\f \f

\f down to about the
middle position     


  


  
 





At this time, if you depress the accelera-
tor pedal more firmly and slowly, you can
drive your vehicle at low speeds. Have
your vehicle checked by your Toyota deal-
er as soon as possible.
Even if the abnormality of the electronic
throttle control system is corrected during
low speed driving, the system may not be
recovered until the engine is stopped and
the ignition key is turned to “ACC” or
“LOCK” position.
CAUTION
Be especially careful to prevent erro-
neous pedal operation.
  \b 
\f \f




 ith  

\f \f

\f down  
   

 

 
  






At this time, vibration may occur. Howev-
er, if you depress the accelerator pedal
more firmly and slowly, you can drive your
vehicle at low speeds. Have your vehicle
checked by your Toyota dealer as soon as
possible.
Even if the abnormality of the electronic
throttle control system is corrected during
low speed driving, the system may not be
recovered until the engine is stopped and
the ignition key is turned to “ACC” or
“LOCK” position.
CAUTION
Be especially careful to prevent erro-
neous pedal operation.
If your engine coolant temperature
gauge indicates overheating, if you ex-
perience a loss of power, or if you hear
a loud knocking or pinging noise, the
engine has probably overheated. You
should follow this procedure... 1. Pull safely off the road, stop the ve- hicle and turn on your emergency
flashers. Put the transmission in “P”
(automatic) or neutral (manual) and ap-
ply the parking brake. Turn off the air
conditioning if it is being used.
2. If coolant or steam is boiling out of the radiator or reservoir, stop the engine.
Wait until the steam subsides before
opening the hood. If there is no coolant
boiling over or steam, leave the engine
running.
CAUTION
To help avoid personal injury, keep
the hood closed until there is no
steam. Escaping steam or coolant is
a sign of very high pressure.
If you cannot incr ease the
engine speed
(5VZFE engine) If you cannot incr
ease the
engine speed
(2UZFE engine) If your vehicle overheats

’03 TUNDRA_U (L/O 0307)
269
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Doors and engine hood
Check that all doors including tailgate op-
erate smoothly and all latches lock se-
curely. Make sure the engine hood sec-
ondary latch secures the hood from
opening when the primary latch is re-
leased.
Tire inflation pressure
Check the pressure with a gauge ev-
ery two weeks, or at least once a
month. See Section 7−2 for additional
information.
Tire surface and wheel nuts
Check the tires carefully for cuts,
damage or excessive wear. See Sec-
tion 7 −2 for additional information.
When checking the tires, make sure
no nuts are missing, and check the
nuts for looseness. Tighten them if
necessary.
Tire rotation
Rotate the tires according to the
maintenance schedule. (For sched-
uled maintenance information, please
refer to the “Scheduled Maintenance
Guide” or “Owner ’s Manual Supple-
ment”.) See Section 7 −2 for additional
information.
Be on the alert for changes in perfor-
mance, sounds, and visual tip −offs that
indicate service is needed. Some impor-
tant clues are as follows:
Engine missing, stumbling, or pinging
Appreciable loss of power
Strange engine noises
A leak under the vehicle (however, wa-
ter dripping from the air conditioning
after use is normal.)
Change in exhaust sound (This may
indicate a dangerous carbon monoxide
leak. Drive with the windows open and
have the exhaust system checked im-
mediately.)
Flat −looking tire; excessive tire squeal
when cornering; uneven tire wear
Vehicle pulls to one side when driving
straight on a level road
Strange noises related to suspension
movement
Loss of brake effectiveness; spongy
feeling brake or clutch pedal; pedal al-
most touches floor; vehicle pulls to one
side when braking
Engine coolant temperature continually
higher than normal
Engine continually runs hot; oil pres-
sure gauge stays low
If you notice any of these clues, take your
vehicle to your Toyota dealer as soon as
possible. It probably needs adjustment or
repair.
CAUTION
Do not continue driving with the ve-
hicle unchecked. It could result in se-
rious vehicle damage and possibly
personal injury.
Does your vehicle need
repairing?

’03 TUNDRA_U (L/O 0307)
301
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Light bulbsBulb
No.WTy p e
Door courtesy
lights1943.8D
Glove box light—1.2D
Step light—1.4D
A: HB2 halogen bulbs
B: HB4 halogen bulbs
C: Wedge base bulbs (amber)
D: Wedge base bulbs
E: Double end bulbs
1. Open the hood. Unplug the connec-
tor. Remove the rubber cover.
If the connector is tight, wiggle it.2. Release the bulb retaining spring and remove the bulb. Install a new
bulb and the bulb retaining spring.
To install a bulb, align the tabs of the
bulb with the cutouts of the mounting
hole.
—Headlights

’03 TUNDRA_U (L/O 0307)
3
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Removing wheel ornament 243
. . . . . . . . . .
Wheel block 243
. . . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 248
. . . . . . . . . . . . . . . . . . . . . . . .
Floor mat 182
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid level
Brake 284
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power steering 285
. . . . . . . . . . . . . . . . . . . . .
Washer fluid 299
. . . . . . . . . . . . . . . . . . . . . . .
Fog light switch, Front 94
. . . . . . . . . . . . . . . . .
Foreign countries, Operation in 189 . . . . . . . .
Four −wheel drive
Operating the four −wheel drive
system 118
. . . . . . . . . . . . . . . . . . . . . . . . . .
Four −wheel drive system warning
buzzer 104
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front door locks 12
. . . . . . . . . . . . . . . . . . . . . .
Front fog light switch 94
. . . . . . . . . . . . . . . . . .
Front passenger ’s seat 34
. . . . . . . . . . . . . . . .
Front passenger ’s seat belt reminder
light 104
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front seat
Rear seat entry 34
. . . . . . . . . . . . . . . . . . . . .
Front seats 31,32,33
. . . . . . . . . . . . . . . . . . . . .
Fuel
Fuel economy 230
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 189
. . . . . . . . . .
Gauge 100
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Operation in foreign countries 189 . . . . . . .
Tank cap 26
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel information 187
. . . . . . . . . . . . . . . . . . . . .
Fuel pump shut off system 189
. . . . . . . . . . . .
Fuse
Fuse box 298
. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 274
. . . . . . . . . . . . . . . . . . . . . . . G
Garage door opener box 168
. . . . . . . . . . . . . .
Gauge
Engine coolant temperature 100
. . . . . . . . .
Engine oil pressure 101
. . . . . . . . . . . . . . . . .
Fuel 100
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Glove box 167
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Good driving practice 113,117
. . . . . . . . . . . . .
H
Hazard switch 93
. . . . . . . . . . . . . . . . . . . . . . . .
Head restraints 37
. . . . . . . . . . . . . . . . . . . . . . .
Headlight switch 92
. . . . . . . . . . . . . . . . . . . . . .
High speed operation
During break −in 187
. . . . . . . . . . . . . . . . . . . .
Hood release, Engine 23
. . . . . . . . . . . . . . . . . .
How to start the engine 214
. . . . . . . . . . . . . . .
I
I/M test 270
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Identification
Engine 198
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tire 201
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Vehicle 197
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition switch 112
. . . . . . . . . . . . . . . . . . . . . . .
Ignition switch light 95
. . . . . . . . . . . . . . . . . . . .
Indicator symbols 8
. . . . . . . . . . . . . . . . . . . . . .
Instrument panel
Ashtray 166
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 94
. . . . . . . . . . . . . . . . . . .
Cigarette lighter 166
. . . . . . . . . . . . . . . . . . . .
Clock 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . Engine oil pressure gauge
101
. . . . . . . . . . .
Fuel gauge 100
. . . . . . . . . . . . . . . . . . . . . . . .
Indicator symbols 8
. . . . . . . . . . . . . . . . . . . .
Odometer 103
. . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 102
. . . . . . . . . . . . . . . . . . . . . . . .
Trip meter 103
. . . . . . . . . . . . . . . . . . . . . . . . .
Instrument panel light control 94
. . . . . . . . . . .
Instrument panel overview 2,6
. . . . . . . . . . . .
J
Jack
Location 241,242 . . . . . . . . . . . . . . . . . . . . . .
Jump starting 235 . . . . . . . . . . . . . . . . . . . . . . . .
K
Key reminder buzzer 104
. . . . . . . . . . . . . . . . .
Keys 12,257
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
L
Light bulbs
Back −up lights 303,304 . . . . . . . . . . . . . . . . .
Cargo lamps 306 . . . . . . . . . . . . . . . . . . . . . . .
Front fog lights 302 . . . . . . . . . . . . . . . . . . . . .
Front side marker lights 302 . . . . . . . . . . . . .
Front turn signal lights 302 . . . . . . . . . . . . . .
Headlights 301 . . . . . . . . . . . . . . . . . . . . . . . .
High mounted stoplight 306 . . . . . . . . . . . . .
Licence plate lights 305 . . . . . . . . . . . . . . . . .
Parking lights 302 . . . . . . . . . . . . . . . . . . . . . .
Rear turn signal lights 303,304 . . . . . . . . . .