2003 TOYOTA TUNDRA battery

’03 TUNDRA_U (L/O 0307)
276
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Be careful not to scratch the glass
surface with the wiper frame.
 When closing the engine hood,
check to see that you have not for-
gotten any tools, rags, etc.Here is a list of parts and tools you will
need to perform do− it−yourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Toyota Genuine Motor Oil” or equiva-
lent
See Section 7 −2 for details about en-
gine oil selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Genuine Long Life Coolant” or
equivalent
See Sec t i on 7 −2 for details about cool-
ant type selection.
Demineralized or distilled water
Tools:
Funnel (only for adding coolant) CHECKING BRAKE FLUID
Parts (if level is low):
SAE J1703 or FMVSS No.116 DOT 3
brake fluid
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Automatic transmission fluid DEXRON II
or III
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts)
Parts and tools

’03 TUNDRA_U (L/O 0307)
295
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
DOITYOURSELF MAINTENANCE
Electrical components
Checking battery condition 296
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 298
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 298
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 299
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . .
Replacing light bulbs 300
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
SECTION 7 3

’03 TUNDRA_U (L/O 0307)
296
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
CAUTION
BATTERY PRECAUTIONS
The battery produces flammable and
explosive hydrogen gas.
Do not cause a spark from the bat-
tery with tools.
Do not smoke or light a match near
the battery.
The electrolyte contains poisonous
and corrosive sulfuric acid.
Avoid contact with eyes, skin or
clothes.
Never ingest electrolyte.
Wear protective safety glasses when
working near the battery.
Keep children away from the bat-
tery.
EMERGENCY MEASURES
If electrolyte gets in your eyes,
flush your eyes with clean water
immediately and get immediate
medical attention. If possible, con-
tinue to apply water with a sponge
or cloth while en route to the medi-
cal office.
If electrolyte gets on your skin,
thoroughly wash the contact area. If
you feel pain or burning, get medi-
cal attention immediately.
If electrolyte gets on your clothes,
there is a possibility of its soaking
through to your skin, so immediate-
ly take off the exposed clothing and
follow the procedure above, if nec-
essary.
If you accidentally swallow electro-
lyte, drink a large quantity of water
or milk. Follow with milk of magne-
sia, beaten raw egg or vegetable
oil. Then go immediately for emer-
gency help.
Warning: Battery posts, terminals
and related accessories contain lead
and lead compounds, chemicals
known to the State of California to
cause cancer and reproductive
harm. Wash hands after handling.
Te r m i n a l s
Ground cable
Hold −down clamp
Check the battery for corroded or loose
terminal connections, cracks, or loose
holddown clamp.
a. If the battery is corroded, wash it off with a solution of warm water and bak-
ing soda. Coat the outside of the termi-
nals with grease to prevent further cor-
rosion.
b. If the terminal connections are loose, tighten their clamp nuts—but do not
overtighten.
c. Tighten the hold− down clamp only
enough to keep the battery firmly in
place. Overtightening may damage the
battery case.
Checking battery c ondition—
—Precautions —Checking battery exterior

’03 TUNDRA_U (L/O 0307)
297
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
NOTICE
Be sure the engine and all accesso-
ries are off before performing main-
tenance.
 When checking the battery, remove
the ground cable from the negative
terminal (“” mark) first and rein-
stall it last.
 Be careful not to cause a short cir-
cuit with tools.
 Take care no solution gets into the
battery when washing it.
Ty p e A
Green Dark Clear or
light yellow
Ty p e B Blue White Red
CHECKING BY INDICATOR
Check the battery condition by the indi-
cator color.
Indicator color
ConditionTy p e ATy p e B
GreenBlueGood
DarkWhite
"\b \b #


 $%

&\f 

 '


\f
Clear or Light
Yellow
Red
Have battery
checked by your
Toyota dealer.
—Checking battery c ondition

’03 TUNDRA_U (L/O 0307)
298
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
During recharging, the battery is pro-
ducing hydrogen gas.
Therefore, before recharging:
1. If recharging with the battery installed on the vehicle, be sure to disconnect
the ground cable.
2. Be sure the power switch on the re- charger is off when connecting the
charger cables to the battery and when
disconnecting them.
CAUTION
Always charge the battery in an un-
confined area. Do not charge the
battery in a garage or closed room
where there is not sufficient ventila-
tion.
Only do a slow charge (5 A or
less). Charging at a quicker rate is
dangerous. The battery may ex-
plode, causing personal injuries.
NOTICE
Never recharge the battery while the
engine is running. Also, be sure all
accessories are turned off.
Ty p e A
Good Blown
Ty p e B
Ty p e C Good Blown
Good Blown
If the headlights or other electrical
components do not work, check the
fuses. If any of the fuses are blown,
they must be replaced.
See “Fuse locations” in Section 7
−1 for
locations of the fuses.
Turn the ignition switch and inoperative
component off. Pull a suspected fuse
straight out and check it.
Determine which fuse may be causing the
problem. The lid of the fuse box shows
the name of the circuit for each fuse. See
Section 8 of this manual for the functions
controlled by each circuit.
Battery recharging precautions Checking and replacing fuses

’03 TUNDRA_U (L/O 0307)
313
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
ENGINE LUBRICATION
Oil capacity (drain and refill), L (qt., Imp.
qt.):
5VZ− FE engine
With filter 5.2 (5.5, 4.6)
Without filter 4.9 (5.2, 4.3)
2UZ− FE engine
With filter 6.2 (6.5, 5.5)
Without filter 5.7 (6.0, 5.0)
“Toyota Genuine Motor Oil” is filled in
your Toyota vehicle. Use Toyota approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and
viscosity.
Oil grade: API grade SL “Energy −Conserving” or
ILSAC multigrade engine oil Recommended oil viscosity:
SAE 5W −30
Outside temperature
Please contact your Toyota dealer for fur-
ther details.
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
With manual transmission 10.0 (10.6, 8.8)
With automatic transmission 5VZ− FE engine 9.9 (10.5, 8.7)
2UZ− FE engine 11.6 (12.3, 10.2) Coolant type:
“Toyota Genuine Long Life Coolant” is
filled in your Toyota vehicle. In order to
avoid technical problems, we strongly
recommend using “Toyota Genuine Long
Life Coolant” or equivalent.
With ethylene− glycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
Please contact your Toyota dealer for
further details.
BATTERY
Open voltage∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af- ter the key is removed with all the
lights turned off
Charging rates: 5 A max.

’03 TUNDRA_U (L/O 0307)
317
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Engine compartment (5VZFE engine)
Instrument panel
Fuses (type A)
1. MIR HTR 15 A: Outside rear view mir-
ror heaters
2. FOG 15 A: Front fog lights
3. TOW BRK 30 A: Trailer brake control-
ler
4. SUB BATT 30 A: Trailer sub battery
5. TOW TAIL 30 A: Trailer lights (tail
lights)
6. PWR OUTLET 1 15 A: Power outlet
7. ECUB 5 A: Anti−lock brake system
8. HLP RH 10 A: Right−hand headlight
(high beam) 9. PWR OUTLET 2 15 A:
Power outlet
10. DOME 10 A: Interior light, personal
lights, vanity light, ignition switch light,
step light, door courtesy lights, open
door warning light
11. HLP LH 10 A : Left−hand headlight
(high beam)
12. EFI NO.2 10 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system, emission control system
13. RADIO 20 A: Audio system
14. HEAD RL 10 A (with daytime running light system): Right−hand headlight
(low beam)
15. A/C 10 A: Air conditioning system
16. HEAD LL 10 A (with daytime running light system): Left−hand headlight (low
beam)
17. ALTS 7.5 A: Charging system
18. ETCS 10 A (2UZFE engine): Multiport
fuel injection system/sequential multi-
port fuel injection system, electronic
throttle control system
19. HAZ 15 A: Emergency flashers
20. EFI NO.1 20 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system, fuel pump, “EFI NO.2”
fuse

’03 TUNDRA_U (L/O 0307)
1
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
A
Access doors 14
. . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 299
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 32,33
. . . . . . . . . . . . . . . . . . . . . .
Seat belt 38
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 158
. . . . . . . . . . . . . . .
Airbags 47
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 294
. . . . . . . . . .
Anti −glare inside rear view mirror 88 . . . . . . .
Anti −lock brake system warning
light 104
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti −theft steering column lock 112 . . . . . . . .
Appearance care
Cleaning the interior 262
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 260
. . . . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 261
. . . . . . . . . . . . . . . .
Armrest 35
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ashtray 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio remote controls 150
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 113
. . . . . . . . . . . . . . . . . . . . .
Shift pattern 113
. . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 113
. . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 104
. . . . . . . . . . .
Auxiliary boxes 171
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 23
. . . . . . . . . . .
B
Battery
Checking battery condition 296 . . . . . . . . . .
Gas caution 296 . . . . . . . . . . . . . . . . . . . . . . .
Handling safety 296 . . . . . . . . . . . . . . . . . . . .
Recharging precautions 297 . . . . . . . . . . . . .
Winter driving tips 218 . . . . . . . . . . . . . . . . . .
Before starting the engine 214 . . . . . . . . . . . . .
Brake pad wear limit indicators 196 . . . . . . . .
Brake system 193 . . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 104 . . . . . . . . . . . .
Brakes
Fluid level 284 . . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 196 . . . . . . . . . . . .
Parking 123
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 187
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 94
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 128
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 191
. . . . . . . . . . . . .
Cargo and luggage
Capacity 208
. . . . . . . . . . . . . . . . . . . . . . . . . .
Capacity and distribution 209
. . . . . . . . . . . .
Stowage precautions 209
. . . . . . . . . . . . . . .
Cargo lamp 95
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette player 128
. . . . . . . . . . . . . . . . . . . . . .
Cassette tape holder 179
. . . . . . . . . . . . . . . . .
Certification regulation label 197
. . . . . . . . . . .
Checking and replacing fuses 298
. . . . . . . . .
Checking brake fluid 284
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 280
. . . . . . . . . . Checking the radiator and
condenser 284
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 57
. . . . . . . . . . . . . . .
Installation 59,67
. . . . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 82,84
. . . . . . . . . . . . . . . . . . . .
Precautions 56
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 58 . . . . . . . .
Using a top strap 77,79
. . . . . . . . . . . . . . . . .
Cigarette lighter 166
. . . . . . . . . . . . . . . . . . . . . .
Cleaning the interior 262
. . . . . . . . . . . . . . . . . .
Clock 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clutch start cancel switch 126
. . . . . . . . . . . . .
Coin holder 175,177
. . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 218
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc and cassette tape holder
Cassette tape holder 177,178
. . . . . . . . . . .
Compact disc holder 177,178
. . . . . . . . . . . .
Compact disc changer 128
. . . . . . . . . . . . . . . .
Compact disc changer controller 128 . . . . . . .
Compact disc player 128
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 284
. . . . . . . . . . . .
Console box
Rear 173,174
. . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,6
. . . . . . . . . . . .
Cooling system
Coolant level 282
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 238
. . . . . . . . . . . . . . . . .
Radiator and reservoir 282
. . . . . . . . . . . . . .
Radiator cap 238
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 218
. . . . . . . . . . . . . . . . . .
Corrosion prevention 260
. . . . . . . . . . . . . . . . .