2003 TOYOTA TUNDRA Fluid

’03 TUNDRA_U (L/O 0307)
284
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
If any of the above parts are extremely
dirty or you are not sure of their condi-
tion, take your vehicle to a Toyota dealer.
CAUTION
To prevent burning yourself, be care-
ful not to touch the radiator or con-
denser when the engine is hot.
NOTICE
To prevent damage to the radiator
and condenser, do not perform the
work by yourself.
To check the fluid level, simply look at
the seethrough reservoir. The level
should be between the “MAX” and
“MIN” lines on the reservoir.
It is normal for the brake fluid level to go
down slightly as the brake pads wear. So
be sure to keep the reservoir filled.
If the reservoir needs frequent refi lling, it
may indicate a serious mechanical prob-
lem. If the level is low, add SAE J1703 or
FMVSS No.116 DOT 3 brake fluid to the
brake reservoir.
Remove and replace the reservoir cap by
hand. Fill the brake fluid to the dotted
line. This brings the fluid to the correct
level when you put the cap back on.
Use only newly opened brake fluid. Once
opened, brake fluid absorbs moisture from
the air, and excess moisture can cause a
dangerous loss of braking.
CAUTION
Take care when filling the r
eservoir
because brake fluid can harm your
eyes and damage painted surfaces. If
fluid gets in your eyes, flush your
eyes with clean water immediately. If
you still feel uncomfortable with your
eyes, go to the doctor.
NOTICE
If you spill the fluid, be sure to wash
it off with water to prevent it from
damaging the parts or paint.
Checking the radiator and
condenser Checking brake fluid

’03 TUNDRA_U (L/O 0307)
285
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
If cold add
If cold O.K.
If hot add If hot O.K.
Check the fluid level on the dipstick. If
necessary, add automatic transmission
fluid DEXRON II or III.
If the vehicle has been driven around 80
km/h (50 mph) for 20 minutes (a little
more in frigid temperatures), the fluid is
hot (40 C—80 C or 104 F—175 F). You
may also check the level when the fluid
is cold (about room temperature,
0 C—40 C or 32 F—104 F) if the engine
has not been run for about five hours.
a. Clean all dirt from outside of the reser- voir tank.
b. Remove the reservoir cap by turning it counterclockwise and wipe the dipstick
clean. c. Reinstall the reservoir cap.
d. Remove the reservoir cap again and look at the fluid level. If the fluid is
cold, the level should be in the “COLD”
range on the dipstick. Similarly, if it is
hot, the fluid level should be in the
“HOT” range. If the level is at the low
side of either range, add automatic
transmission fluid DEXRON II or III to
bring the level within the range.
e. After replacing the reservoir cap, visu- ally check the steering box case, vane
pump and hose connections for leaks
or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
If hot O.K. Close Open
If cold O.K.
If hot add If cold add
Check the fluid level through the reser-
voir. If necessary, add automatic trans-
mission fluid DEXRON II or III.
If the vehicle has been driven around 80
km/h (50 mph) for 20 minutes (a little
more in frigid temperatures), the fluid is
hot (60 C—80 C or 140 F—175 F). You
may also check the level when the fluid
is cold (about room temperature,
10 C—30 C or 50 F—85 F) if the engine
has not been run for about five hours.
Checking power steering fluid
(5VZFE engine) Checking power steering fluid
(2UZFE engine)

’03 TUNDRA_U (L/O 0307)
286
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the “COLD”
range. Similarly, if it is hot, the fluid level
should be in the “HOT” range. If the level
is at the low side of either range, add
automatic transmission fluid DEXRON II
or III to bring the level within the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the reser-
voir cap, visually check the steering box
case, vane pump and hose connections
for leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
Typ e A (t i re an d lo ad i n g in f o rma-
tion label)Typ e B (t i re an d lo ad i n g in f o rma-
tion label)
Checking tire inflation
pressure

’03 TUNDRA_U (L/O 0307)
295
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
DOITYOURSELF MAINTENANCE
Electrical components
Checking battery condition 296
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery recharging precautions 298
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 298
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 299
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . .
Replacing light bulbs 300
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
SECTION 7 3

’03 TUNDRA_U (L/O 0307)
299
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Type A fuses can be pulled out by the
pull−out tool. The location of the pull −out
tool is shown in the illustration.
If you are not sure whether the fuse has
blown, try replacing the suspected fuse
with one that you know is good.
If the fuse has blown, push a new fuse
into the clip.
Only install a fuse with the amperage rat-
ing designated on the fuse box lid.
If you do not have a spare fuse, in an
emergency you can pull out the “DOME”
or “HTR” fuse, which may be dispensable
for normal driving, and use it if its amper-
age rating is the same.
If you cannot use one of the same amper-
age, use one that is lower, but as close
as possible to the rating. If the amperage
is lower than that specified, the fuse
might blow out again but this does not
indicate anything wrong. Be sure to get
the correct fuse as soon as possible and
return the substitute to its original clip.
It is a good idea to purchase a set of
spare fuses and keep them in your ve-
hicle for emergencies. If the new fuse immediately blows out,
there is a problem with the electrical sys-
tem. Have your Toyota dealer correct it as
soon as possible.
CAUTION
Never use a fuse with a higher am-
perage rating, or any other object, in
place of a fuse. This may cause ex-
tensive damage and possibly a fire.
If any washer does not work or low
windshield washer fluid level warning
light comes on, the washer tank may be
empty. Add washer fluid.
You may use plain water as washer fluid.
However, in cold areas where tempera-
tures range below freezing point, use
washer fluid containing antifreeze. This
product is available at your Toyota dealer
and most auto parts stores. Follow the
manufacturer’s directions for how much to
mix with water.
NOTICE
Do not use engine antifreeze or any
other substitute because it may dam-
age your vehicle’s paint.
Adding washer fluid

’03 TUNDRA_U (L/O 0307)
314
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
CLUTCH
Pedal free play, mm (in.):
5—15 (0.2—0.6)
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSMISSION
Oil capacity, L (qt., Imp. qt.): Tw o −wheel drive models
2.6 (2.7, 2.3)
Four −wheel drive models
2.2 (2.3, 1.9)
Oil type: Gear oil API GL −4 or GL −5
Recommended oil viscosity: SAE 75W −90
AUTOMATIC TRANSMISSION
Fluid capacity (drain and refill), L (qt.,
Imp. qt.): Up to 2.0 (2.1, 1.8)
Fluid type: Toyota Genuine ATF Type T −IV
Change automatic transmission fluid only
as necessary. Generally, it is necessary to change
automatic transmission fluid only if your
vehicle is driven under one of the Special
Operating Conditions listed in your
“Scheduled Maintenance Guide” or
“Owner ’s Manual Supplement”. When
changing the automatic transmission fluid,
use only “Toyota Genuine ATF Type T
−IV”
(ATF JWS3309 or NWS6500) to aid in
assuring optimum transmission perfor-
mance.
Notice: Using automatic transmission
fluid other than “Toyota Genuine ATF
Type TIV” may cause deterioration in
shift quality, locking up of your trans-
mission accompanied by vibration, and
ultimately damage the automatic trans-
mission of your vehicle.
Please contact your Toyota dealer for fur-
ther details.
TRANSFER
Oil capacity, L (qt., Imp. qt.):
1.0 (1.1, 0.9)
Oil type: Gear oil API GL−4 or GL−5
Recommended oil viscosity: SAE 75W −90 DIFFERENTIAL
Oil capacity, L (qt., Imp. qt.):
Front1.15 (1.2, 1.0)
Rear
Tw o −wheel drive models
Standard differential
3.80 (4.0, 3.3)
Limited− slip differential
3.15 (3.3, 2.8)
Four −wheel drive models
Standard differential 3.50 (3.7, 3.1)
Limited− slip differential
2.95 (3.1, 2.6)
Oil type: Standard differentialHypoid gear oil API GL −5
Limited− slip differential
Hypoid gear oil for limited −slip differ-
ential API GL −5

’03 TUNDRA_U (L/O 0307)
315
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
Recommended oil viscosity:
FrontSAE 75W −90
Rear Standard differential
Synthetic oil SAE 75W −140
Limited− slip differential
Above −18 C (0 F)
SAE 90
Below −18 C (0 F)
SAE 80W or 80W −90
CHASSIS LUBRICATION
Propeller shafts: Spiders and slide yokesLithium base chassis grease, NLGI
No.2
Double cardan joint Molybdenum −disulfide lithium base
chassis grease, NLGI No.2 BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):
95 (3.7)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment:
Pedal type—when depressed with the
force of 294 N (30 kgf, 66.1 lbf)8—10 clicks
Lever type—when pulled with the force
of 196 N (20 kgf, 44 lbf) 8—12 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel free play: Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III

’03 TUNDRA_U (L/O 0307)
1
2003 TUNDRA from Jul. ’03 Prod. (OM 34430U)
A
Access doors 14
. . . . . . . . . . . . . . . . . . . . . . . . .
Adding washer fluid 299
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 32,33
. . . . . . . . . . . . . . . . . . . . . .
Seat belt 38
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 158
. . . . . . . . . . . . . . .
Airbags 47
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 294
. . . . . . . . . .
Anti −glare inside rear view mirror 88 . . . . . . .
Anti −lock brake system warning
light 104
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti −theft steering column lock 112 . . . . . . . .
Appearance care
Cleaning the interior 262
. . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 260
. . . . . . . . . . . . . . . . . . . . . . . .
Washing and waxing 261
. . . . . . . . . . . . . . . .
Armrest 35
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ashtray 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Audio remote controls 150
. . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 113
. . . . . . . . . . . . . . . . . . . . .
Shift pattern 113
. . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 113
. . . . . . . . . . . . . . . . . . . . .
Automatic transmission fluid temperature warning light 104
. . . . . . . . . . .
Auxiliary boxes 171
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 23
. . . . . . . . . . .
B
Battery
Checking battery condition 296 . . . . . . . . . .
Gas caution 296 . . . . . . . . . . . . . . . . . . . . . . .
Handling safety 296 . . . . . . . . . . . . . . . . . . . .
Recharging precautions 297 . . . . . . . . . . . . .
Winter driving tips 218 . . . . . . . . . . . . . . . . . .
Before starting the engine 214 . . . . . . . . . . . . .
Brake pad wear limit indicators 196 . . . . . . . .
Brake system 193 . . . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 104 . . . . . . . . . . . .
Brakes
Fluid level 284 . . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 196 . . . . . . . . . . . .
Parking 123
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 187
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 94
. . . . . . . . . . . . . . . . . . . . .
C
Car audio system 128
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 191
. . . . . . . . . . . . .
Cargo and luggage
Capacity 208
. . . . . . . . . . . . . . . . . . . . . . . . . .
Capacity and distribution 209
. . . . . . . . . . . .
Stowage precautions 209
. . . . . . . . . . . . . . .
Cargo lamp 95
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Cassette player 128
. . . . . . . . . . . . . . . . . . . . . .
Cassette tape holder 179
. . . . . . . . . . . . . . . . .
Certification regulation label 197
. . . . . . . . . . .
Checking and replacing fuses 298
. . . . . . . . .
Checking brake fluid 284
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 280
. . . . . . . . . . Checking the radiator and
condenser 284
. . . . . . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 57
. . . . . . . . . . . . . . .
Installation 59,67
. . . . . . . . . . . . . . . . . . . . . .
Installation with child restraint lower anchorages 82,84
. . . . . . . . . . . . . . . . . . . .
Precautions 56
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 58 . . . . . . . .
Using a top strap 77,79
. . . . . . . . . . . . . . . . .
Cigarette lighter 166
. . . . . . . . . . . . . . . . . . . . . .
Cleaning the interior 262
. . . . . . . . . . . . . . . . . .
Clock 166
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clutch start cancel switch 126
. . . . . . . . . . . . .
Coin holder 175,177
. . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 218
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc and cassette tape holder
Cassette tape holder 177,178
. . . . . . . . . . .
Compact disc holder 177,178
. . . . . . . . . . . .
Compact disc changer 128
. . . . . . . . . . . . . . . .
Compact disc changer controller 128 . . . . . . .
Compact disc player 128
. . . . . . . . . . . . . . . . . .
Condenser
Checking the condenser 284
. . . . . . . . . . . .
Console box
Rear 173,174
. . . . . . . . . . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2,6
. . . . . . . . . . . .
Cooling system
Coolant level 282
. . . . . . . . . . . . . . . . . . . . . .
Engine overheating 238
. . . . . . . . . . . . . . . . .
Radiator and reservoir 282
. . . . . . . . . . . . . .
Radiator cap 238
. . . . . . . . . . . . . . . . . . . . . . .
Winter driving tips 218
. . . . . . . . . . . . . . . . . .
Corrosion prevention 260
. . . . . . . . . . . . . . . . .