2003 TOYOTA RAV4 light

’03 Rav4_U (L/O 0208)
2462003 RAV4 from Aug. ’02 Prod. (OM42517U)
“TOP” mark
3. Install the rubber cover with the“TOP” mark upward, and fit it se-
curely on the boss. Plug in the con-
nector.
Make sure the rubber cover fits securely
on the bulb base and the mounting body.
Aiming is not necessary after replacing
the bulb. When aiming adjustment is nec-
essary, contact your Toyota dealer.1. Loosen the retainer screw with a Phillipshead screwdriver and take
out the front turn signal light unit.2. Remove the front fog light unit.
—Front fog lights

’03 Rav4_U (L/O 0208)
2472003 RAV4 from Aug. ’02 Prod. (OM42517U)
3. Unplug the connector while depress-ing on the tab.
If the connector is tight, wiggle it.4. Turn the bulb and remove it.5. Install a new bulb and the connector into the mounting hole. Install the
front fog light unit then the front
turn signal light unit, and tighten the
retainer screw.

’03 Rav4_U (L/O 0208)
2482003 RAV4 from Aug. ’02 Prod. (OM42517U)
Use a Phillipshead screwdriver.
—Parking and front side
marker lights—Front turn signal lights
(without front fog lights)

’03 Rav4_U (L/O 0208)
2492003 RAV4 from Aug. ’02 Prod. (OM42517U)
Use a Phillipshead screwdriver.
—Front turn signal lights
(with front fog lights)—Rear turn signal, stop/tail,
rear side marker and backup
lights

’03 Rav4_U (L/O 0208)
2502003 RAV4 from Aug. ’02 Prod. (OM42517U)
a: Stop/tail and rear side marker light
b: Backup light
c: Rear turn signal light
—High mounted stoplight

’03 Rav4_U (L/O 0208)
2512003 RAV4 from Aug. ’02 Prod. (OM42517U)
Use a Flatbladed screwdriver.
—License plate light

’03 Rav4_U (L/O 0208)
2562003 RAV4 from Aug. ’02 Prod. (OM42517U)
Recommended oil viscosity:SAE 5W30
Outside temperature
Please contact your Toyota dealer for fur-
ther details. COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
With manual transaxle 6.3 (6.7, 5.6)
With automatic transaxle 6.2 (6.6, 5.5)
Coolant type:
“Toyota Genuine Long Life Coolant” is
filled in your Toyota vehicle. In order to
avoid technical problems, we strongly
recommend using “Toyota Genuine Long
Life Coolant” or equivalent.
With ethyleneglycol type coolant for a
proper corrosion protection of aluminum
components
Do not use alcohol type antifreeze or
plain water alone.
Please contact your Toyota dealer for
further details.
BATTERY
Open voltage
∗ at 20 C (68 F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights
turned off
Charging rates: 5 A max. CLUTCH
Pedal free play, mm (in.):
5—15 (0.2—0.6)
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
MANUAL TRANSAXLE
Oil capacity, L (qt., Imp. qt.): Twowheel drive models2.5 (2.6, 2.2)
Fourwheel drive models
3.4 (3.6, 3.0)
Oil type: Gear oil API GL4 or GL5
Recommended oil viscosity: SAE 75W90

’03 Rav4_U (L/O 0208)
2582003 RAV4 from Aug. ’02 Prod. (OM42517U)
Tire size:215/70R16 99S
235/60R16 100H
Tire pressure, kPa (kgf/cm
2 or bar, psi):
200 (2.0, 29)
Wheel size: Steel wheel 16 61/2J
Aluminum Wheel 16 7JJ
Wheel nut torque, N
·m (kgf·m, ft·lbf):
103 (10.5, 76)
NOTE: For a complete information on tires (e.g. replacing tires or re-
placing wheels), see “Checking
tire pressure” through “Aluminum
wheel precautions”, pages 233
through 238 in Section 72.
Engine compartment
Instrument panel
Fuses (type A)
1. RADIO 15 A: Car audio system
2. DOME 10 A: Clock, personal light, in-
terior lights, air conditioning system,
wireless remote control system, head-
light high beam indicator light, gauges
and meters
3. CUT 30 A: “RADIO” and “DOME” fuses
4. A/C 5 A: Air conditioning system
5. MAIN 30 A: “HLP RH” and “HLP LH”
fuses
6. HAZ 10 A: Emergency flashers
Tires Fuses